Chevrolet
Volt

Why in operation the car goes into Shift to Park and Also getting a Propulsion Power Reduce

Component: Battery Energy Control Module, available from dealership ATM Daughter's safety compromised when vehicle power decreased quickly to 5mph in the middle of fast heavy city traffic. The problem has been confirmed by Chevrolet dealership service department The vehicle has not been inspected by other than dealership service center. I contacted GM, and was told that the component was replaced once already in 2021, so they will not replace it a second time on special coverage N232432680 released March 6, 2024. Warnings:Propulsion 11/3/25 Power Reduced and check engine light on 11/3/25. GM dealer service center cleared codes, did a software update 11/7/25: Propulsion Power Reduced and check engine light again. Vehicle is at GM dealer service center.

My wife and I were on a 200 mile trip and the engine failed about 150 miles into the trip. Was driving and the instrument panel indicated that the engine was in reduced power mode. I switched over to battery power but had only approximately 10 miles of range left so after a couple of miles I switched back to engine power and was almost immediately informed by the instrument panel that the engine was in failure mode. Was fortunate that there was an exit nearby and was able to use the remaining battery power to exit the highway and pack the car before there was no power.the car was towed to a dealer and we were told that the egr valve and cooler had failed.they were replaced and I was told that they were not covered by the federal emissions warranty so the cost would be $4000.the car was driven with the vast majority being electric power.

The EGR valve clogged, causing a a servo to blow the F3 fuse, disabling the engine while driving. This occured suddenly while driving on a busy road with no shoulders. I managed to coast into a parking lot not too far away but I had no charge left in my battery. I could only get the engine to start back up for less than a minute at a time. I got my car inspected by Chevrolet and they confirmed they issue. Very shortly before the engine cut off, the car started jolting. There weren't any warning lights or error codes before this.

Chevy had done an update for the Propulsion Power being reduced. In 2024, I had to do another update when the check engine light came on. After that the electric battery power decreased, I am only getting 17 miles per charge. August 2025, the check engine light came on again. I had it check and no codes came up. While driving home on the freeway, the Propulsion Power being reduced warning came up. I had to pull off the freeway. Once I turned my vehicle off, I was unable to drive my car. There was not any acceleration. I had to have my car towed 50 miles home. A mechanic was able to repair it at that time. On 10/7/2025 the check engine light came on again and once again no codes appeared, on 10/14/25 the Propulsion Power being reduced warning came on again. I was able to get home safely, but I got off the freeway and took side streets home. At this time, the vehicle will not accelerate.

The car can't decide if it wants to use the battery or the engine. It shows zero charge even though it is full. It lurches at stop lights as it tries to decide whether to use battery or engine. It says "propulsion power reduced". "Not able to charge". "Shift to park". Check engine light is on.

Dashboard displays “Shift to Park” message even when the shifter is in the park position for the past month. I am unable to turn off the vehicle completely until I Shift to drive then back to park multiple times.

The dealer reported having repaired an emissions recall for a fuel vapor leak, however the repair was ineffective and the vehicle still reports the leak as a fault code "slow" and "fast" emissions leak. The dealer refused to recheck their work without payment. Recently I came into possesion of a borescope camera and was able to photograph the dealer's "repair". The photos clearly show the parts for the emissions repair are located in the wrong place as compared with GM's own service bulletin. Therefore the dealer did not do the repair, or failed to do the repair, and refused to check there own work without compensation when informed of the continuing problems and left me to do their recheck of their work at my own expense. I have provided photos of the GM prescribed parts placement and the incorrectly placed parts in my car as well as the resulting damage. We never experienced the relief intended to be provided by the repair service. They claim to have performed the necessary recall service, but THAT IS A FALSE CLAIM. See Chevrolet TSB N192273600. NOT PERFORMED CORRECTLY SO FAILED. The dealer, Haselwood Chevrolet, Bremerton Washington, was contacted by phone and email but offers no response. They have the pictures of the botched repair job. Additionally the car needs warranty service for a bad park switch which service they refuse to perform without my agreeing in advance to pay for that in warranty repair.