Chevrolet
Traverse

Weld on exhaust was faulty the bracket malfunction. The exhaust system has leak and rattle with exhaust noises, causing the converter fail.

Leaking exhaust noise at start up began around 9/22/25. Noise became louder over the following week. Check engine light came on morning of 9/24/25. Immediately took it to local GM dealership for inspection. Dealership first said it was a cracked front exhaust pipe at the bracket and then they called back and said rear pipe at the bracket was broken also the whole system needed to be replaced because the brackets were not separate but welded directly to the pipe. The estimate was over $1300. Dealership then said the error coded was probably because of the exhaust pipe and catalytic converter and that they require replacement. I discovered there are already recalls and special coverage for the same issue on the 2019, 2021 and 2022 year models of this vehicle. I contacted GM and they acknowledged the problem in other model years before and after but said there isn't enough complaints for this model year. This is a known problem and design flaw. This needs to be addressed by GM immediately. NONE of the welds have held on any parts of the exhaust system or the catalytic converter.

Due to exhaust bracket failure where converter with muffler and side down pipe needs replaced. This was diagnosed at the Chevy dealer and appointment for repair is made. The exhaust suddenly became very loud so I took it to the dealership. There were no messages or warning lamps.

The contact owns a 2020 Chevrolet Traverse. The contact stated that while driving at undisclosed speeds, there were abnormal sounds coming from the exhaust system. The contact stated that the vehicle sounded like a motorcycle. The contact stated that the check engine warning light was illuminated, and DTC: P0171 was displayed. Additionally, the contact stated that there were exhaust fumes entering the cabin of the vehicle. The contact had taken the vehicle to a local dealer, where it was diagnosed, and it was determined that there were cracks in the exhaust pipe and the catalytic converter pipe at Bank 2 and Bank 1 that needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to Technical Service Bulletin Number: PIP5681A. The contact had called the dealer to advise that there was a bulletin covering the cracks on the exhaust and the catalytic converter pipes, but was informed that the cracks on the pipes were on the wrong side and that the vehicle was not covered under warranty. The manufacturer was not informed of the failure. The failure mileage was 110,045.

When I put my car in park and turn it off I get an error message that I need to "Shift to Park". It shows in the dash that it is in park but my radio, and lights stay on. I have to restart my car and put it in park, reverse, or neutral and try to put it in park again. I takes several try's to make the error message go away.

The car has 45,000 and started burning oil. The car is in brand new condition and well under mileage for an issue of such to be occurring. Took to car dealership where purchased and was told $8,500 fix!

A few months ago I was driving and without any warning the steering wheel would lock up and I couldn’t turn it at all. I had to use my strength to wiggle it to unlock it. It happened several times on busy roads and highways. It’s currently at the dealership for the past 2 months because there is a short and the steering gear box needs to be replaced but the part is on back order with no date of when it’ll become available. I obviously can’t drive it due to the steering locking up and that it’s a danger to not only myself and my family but other drivers on the road. Anyone could have been seriously injured or killed had it locked up and caused an accident. It would happen no matter what speed I was going.

Receiving a persistent “Shift to Park” message, after the car has been placed in Park. This causes an inability to turn off my engine completely and is draining my battery. As a temp fix, I've had to wiggle the shifter many times, turn the car on and off, place the car from park into drive many times to get the car to realize it's in Park. Scheduled with the dealership and referenced the TSB that was issued for this specific safety issue (in writing). Brought the car in for the repair and the technician and intake person were both aware of this major problem and have seen other Chevy's with the same issue. Repair is $809.00 for a shifter assembly. [XXX] - [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)