1989 Ford Aerostar
Safety Recalls & Notices
We found 9 safety recalls for the 1989 Ford Aerostar. Recalls are sourced from both NHTSA (US) and Transport Canada databases. Contact your authorized Ford dealer to schedule free repairs.
Summary
A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. CORRECTION: IGNITION SWITCH WILL BE REPLACED WITH A REVISED DESIGN SWITCH.
Summary
THE PARK MECHANISM OF THE A4LD AUTOMATIC TRANSMISSION MAY NOT ENGAGE WHEN THE SELECTOR LEVER IS PLACED IN THE "PARK" POSITION. IF PARKED ON AN INCLINE, THE VEHICLE MAY ROLL AS IF IN NEUTRAL IF THE PARKING BRAKE IS NOT SET. THIS COULD RESULT IN A VEHICLE ACCIDENT OR PERSONAL INJURY. CORRECTION: OWNERS WILL BE NOTIFIED OF CONDITION AND ADVISED TO SET THE PARKING BRAKE EACH TIME THEY PARK THEIR VEHICLE. OWNERS WILL ALSO BE ADVISED WHEN DEALERS RECEIVE PARTS AND REPAIR INSTRUCTIONS AFTER FURTHER INVESTIGATION BY FORD.
Summary
NOTE: VEHICLES EQUIPPED WITH QUAD CAPTAIN'S CHAIRS. THE LATCH RETAINING THE SECOND ROW RIGHT HAND SEAT ASSEMBLY MAY RELEASE UNDER SEVERE FRONTAL IMPACT CONDITIONS. THIS WOULD ALLOW THE SEAT TO PIVOT FORWARD AND COULD RESULT IN OCCUPANT INJURY. CORRECTION: LATCH PAWL ASSEMBLY WILL BE REPLACED WITH ONE OF A REVISED DESIGN.
Summary
VEHICLE DESCRIPTION: MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA (10 SOUTHERN COUNTIES OF LOS ANGELES, ORANGE, SAN BERNADINO, SAN DIEGO, RIVERSIDE, VENTURA, SANTA BARBARA, SAN LUIS OBISPO, IMPERIAL, AND KERN), FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA (CLARK COUNTY), OKLAHOMA, SOUTH CAROLINA, AND TEXAS, AND IN THE U.S. TERRITORIES COVERED BY THE FEDERAL STATUTES. THE UPPER PORTION OF THE FUEL TANK CAN DEVELOP SMALL CRACKS DUE TO EXTENDED EXPOSURE TO VERY HIGH AMBIENT TEMPERATURES. FUEL VAPOR OR LEAKAGE COULD OCCUR AT THESE CRACKS.
Potential Consequence
IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy
DEALERS WILL REPLACE THE FUEL TANK, REGARDLESS OF MILEAGE, THROUGH MARCH 31, 2002. THIS COVERAGE WILL ONLY BE FOR STRUCTURAL CRACKS AT THE TOP OF THE TANK AND WILL NOT INCLUDE OTHER DAMAGE CAUSED BY AN ACCIDENT OR ROAD DEBRIS.
Summary
EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.
Potential Consequence
LOSS OF BRAKING CAN RESULT.
Remedy
AIMCO WILL REIMBURSE CONSUMERS/INSTALLERS FOR THE COST OF REPLACEMENT ROTORS AND INSTALLATION. CONSUMERS ARE REQUESTED TO RETURN TO THE LOCATION WHERE THE ROTORS WERE ORIGINALLY PURCHASED/INSTALLED FOR REPLACEMENT.
Summary
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Potential Consequence
THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy
DEALERS WILL REPLACE THE IGNITION SWITCH.
Summary
WHEN THE AUTOMATIC TRANSMISSION SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARK PAWL DOES NOT ALWAYS ABUT OR ENGAGE THE PARK GEAR.
Potential Consequence
DRIVER MAY BELIEVE THE VEHICLE IS SAFELY ENGAGED IN PARKWHEN THE GEAR IS NOT TRULY ENGAGED. THIS CAN LEAD TO THE VEHICLE JUMPING OUT OFGEAR UNINTENTIONALLY, VEHICLE ROLLAWAY WHEN PARKED ON A SLOPED SURFACE, ANDINADVERTENT MOTION WHEN THE VEHICLE IS STARTED. ALL OF THESE CONDITIONS CANRESULT IN A VEHICLE ACCIDENT.
Remedy
REPAIR THE TRANSMISSION WITH A NEW PARK PAWL.
Summary
SEAT BELT ANCHORAGE BAR FOR REAR SOFA FAILED TO SUSTAIN LOADS REQUIRED BY FMVSS 210.
Potential Consequence
VEHICLES WOULD NOT COMPLY WITH FMVSS 210.
Remedy
REPLACE NONCOMPLYING SOFA BAR WITH BAR THAT MEETS REQUIREMENTS.
Summary
THE SECOND ROW RIGHT HAND SEAT ASSEMBLY HAS A TILT FORWARD FUNCTION. A LATCH RETAINS THE SEAT IN THE NORMAL RIDE POSTION, AND THIS LATCH MAY RELEASE UNDER SEVERE FRONTAL IMPACT CONDITIONS, ALLOWING THE SEAT TO PIVOT FORWARD.
Potential Consequence
IN THE EVENT OF VEHICLE ACCIDENT, THE SEAT COULD PIVOTFORWARD, INCREASING THE RISK OF INJURY TO THE OCCUPANT.
Remedy
REPLACE SEAT PAWL ASSEMBLY WITH A REVISED DESIGN ASSEMBLY.
9 Active Recalls
Requires attention
Ford Aerostar by Year
1989 Ford Aerostar Recall FAQs
Common questions about recalls for this vehicle
Related Recall Checks
Compare recall history with competitors and alternatives to the 1989 Ford Aerostar.