Toyota
Prius

The contact owned a 2006 Toyota Prius. The contact stated that while slowly driving into an intersection and turning left at less than 3 MPH, the owner of a Ford F-150 coming from the driver's side of the vehicle at 35 MPH crashed into their driver's side door. The crash caused the vehicle to slide to a complete stop. None of the air bags deployed. The driver of the Ford F-150 stated that the sun created a glare, preventing them from noticing the red light they had driven through. The contact's vehicle was towed and deemed totaled by their insurance. A police report was filed. The contact received a broken rib, rotator cuff, whiplash, and back injuries. Medical attention was needed. The dealer was not informed of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000

The following describes a near total failure of the brake system that accompanies and is triggered by routine aging of the battery. I believe this applies to multiple model years and editions of the Prius, based on reports by other owners on owners' discussion groups. I believe this should have the highest severity level. Here is what happens: An alarm is sounded, several warning lights ABS, VCS appear, and soon after that, the front brakes stop working. The rear brakes then prove ineffective and lock up. The happens with high frequency under any of the following conditions: (a) as the battery approaches 3yrs age, (b) it is excessively cold outside. (c) there is a higher than typical load on the 12V system from any of a variety of reasons. After installing a fresh new 12V battery, the above happens with much less frequency. There no warning on the dashboard to indicate that the condition of the 12V battery is not safe for operation of the vehicle. It seems clear that the route cause is that the brake control unit is configured within inadequate tolerance for the normal aging of the 12V battery, compounded by the absence of warning on the dash. This probably traces back to a poorly chosen LDO voltage regulator in the design of the brake control unit. Recommendation: Review the electrical designs for the brake control unit, all model years, replace as needed and update the dash board computer to provide warning when the battery condition is not sufficient for safe operation of the vehicle. I further recommend that this be done with all due haste, as the condition is quite dangerous. Qualifications: PhD Chemical Physics and Electrical Engineer

The light up display for the odometer, fuel gauge, and speedometer does not always light up. When it is not lit, the cruise control and any warning and informative alarms/lights also do not work. This is a well-known issue among owners of these cars, related to the capacitors on the circuit board for the display being defective, and there is extensive documentation of it online. It may also have had a technical service bulletin released for the issue, but I'm not entirely sure. The light goes out intermittently and is not always consistently out. I did mention it to the service personnel when I took it in to get recalls repaired recently, and they didn't seem surprised or unaware of the issue. I did not ask them to diagnose or fix it, as I know I can get it done for a better deal elsewhere.

The right or left headlight will rabdomly turn off, and tyrn back there 8s no ryme or readon to it,and while driving at night it is cery dangerous, aparebtly its not just this car, this is a common issue and it needs to be fixed

The actuator failed. The car is no longer safe to drive. This is a known issue. The company refused to fix the issue or recall the car. The warning lights and a loud beep are present if the vehicle is started.

The contact owns a 2006 Toyota Prius. The contact stated that while driving approximately 35 MPH, the steering wheel erroneously steered to the left direction on its own. The contact used force to maneuver the vehicle however the steering wheel independently veered again to the left, right, left, and then back to the right. The vehicle crashed into a curb, and violently accelerated across 2 lanes of oncoming traffic where a van crashed into the vehicle head-on. The air bags deployed upon impact. The contact sustained 11 fractured bones (L1 through L5 lower lumbar, pelvic, pelvis, 11th rib, and sacrum) and received medical attention via trauma center where she remained for over 2 weeks. The other driver of the van sustained unknown injuries but did not receive any known medical attention. A police report was not on file for the incident. A dealer was not contacted. The manufacturer was not notified of the failure. The VIN was not available. The failure mileage was 77,000.

One afternoon, in the Summer of 23, I entered my Toyota Prius to run some errands. Once I proceeded to power on the car, none of the dashboard lights illuminated. This included the gas gauge, speedometer & transmission indicator. Fortunately, I was only driving a few blocks down the road from my residence as I live in a small rural town with little congestion, little traffic and mostly two-lane roads. I can't imagine this occurring in a much larger metropolitan city. When I arrived at my destination, I discovered that my Prius wouldn't shut off. This dashboard malfunction was preventing the Toyota from powering off. I quickly completed my errands with my vehicle running during this entire ordeal. Finally, when I returned home, I frantically researched on YouTube regarding this issue and discovered many others who also were having these no-illuminating-dashboard problems. Some YouTubers offered workarounds but the solutions will be temporary as the problem will eventually worsen until the Prius owners have no working dashboard lights. From the way I understand it, this problem is nothing more than a small computer board that's behind the speedometer and this computer board has a small diode that tends to burn out on all kinds of Toyota Priuses when it reaches around 150,000 miles.

The ABS Sensor on the brakes failed while driving on the highway. This could have caused an accident. These modules should last the lifetime of the car.