Ford
Explorer

Steering drifts to left and will not return to center with out darting to the right when correcting , a constant movement back and forth to keep it in your lane !

“I rented vehicle VIN [XXX] from Budget Rental Car in Panama City Beach, FL (Reservation #XXX, Rental Agreement XXX). I later discovered the vehicle had an unrepaired federal safety recall (NHTSA Recall 25V543 / Manufacturer Recall 25C42) involving the Body Control Module. Budget never informed me of the recall at any time. On November 11, 2025, when I attempted to extend my rental, the representative told me the vehicle had been ‘sold’ and must be returned within two days. When I attempted to exchange it on November 12–13 at three different Budget locations in Lansing, MI, they refused to take the vehicle, stating it had a safety recall and should not have been rented out. Only after this did I check the VIN myself and learn of the safety recall. The recall affects multiple electrical and visibility-related components: trailer lights, interior lights, mirrors, windows, rear defroster, USB/12V ports, and HVAC systems. These issues can reduce driver visibility and increase the risk of a crash. While driving the vehicle, I experienced visibility problems. The windows fogged up severely, and the defroster did not operate properly. As a result, I was unable to see an animal that entered the roadway and unfortunately struck it. There is now damage to the front driver’s side of the vehicle. This visibility impairment aligns with the Body Control Module recall defects described by NHTSA. This vehicle should not have been rented to any customer, especially with the remedy unavailable until late 2025. I am reporting this because an unrepaired safety recall vehicle placed into active rental service directly resulted in a visibility hazard and an unavoidable collision while I was driving.” I did not make it back in time to return the vehicle yesterday 11/14/2025 I am finishing up this report and on my way to Budget in Panama City Beach Florida to return it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Ever since the last recall got resolved the car has failed to go into the gear it’s set to. Such as it fails to go in park when you shift it into park. This is a serious issue as I have now almost rear ended cars in parking lots a few times because of this issue.

See Attached Repair Order

Stopped at traffic light when changed to green pushed on the gas started to roll backwards . Got it stopped and pushed on gas would barely go sounded like transmission slipping. Finally got it thru the stoplight and it started again. Got it home called local dealership took it in and have to take it back Friday morning at 8. Scary!

Three times in 5 months since purchasing our 2025 Ford Explorer, all dash lights will come on while driving and vehicle will come to a stop. Braking pressure is reduced greatly and then vehicle will not continue in forward or reverse. Multiple restart attempts will allow the vehicle to move under 5 MPH but will brake hard to a stop if it goes over 5MPH. Two different dealerships have inspected and preformed the same software updates Ford is recommending and its not fixing the issue. Ford is refusing to do anything about it at this time because they claim the software update is as far as they are allowed to go in diagnoses. I have a Ford Case #XXX

My 2025 Ford Explorer ST-Line is up to date on recalls as of October 7, 2025. However, I am still experiencing engine "shudder" and hesitation at low RPMs (between idle and 1500 RPM) when accelerating. The 10 speed transmission is also continuing to shift harshly at times. I am very concerned that the hesitation and shudder could be an issue when pulling out into traffic. By comparison, my previous 2017 Explorer did not exhibit this behavior, whichh I consider disconcerting. Also, this car (and all 2025 Explorer models ) injects Fake Engine Noise into the audio speakers to make the 2.5L engine sound more powerful. These fake "bass tones" are disturbing to some passengers with hearing aides, and per Ford's website there is no way to disable the fake noise. Thus, some people with a hearing disability cannot ride in my car without removing their hearing aides. It should be unacceptable to not be able to disable that feature. Note updated form dated 8/1/25 states Fake Noise cannot be turned off.

The carpet on the wheel wells is not functional. We live out on a ranch on a dirt road and when it rains the mud gets stuck on the carpet and weighs is down. This can cause more damage to the vehicle. We took it in to a dealership and they said there was nothing they could do until the carpet gets ripped off. When we bought an expensive 4x4 vehicle we expected it to be sturdy enough to not have to worry about mud (especially when the car has a built in mud feature).