1990 Volkswagen Vanagon
Safety Recalls & Notices
3 Active Recalls
Requires attention
EQUIPMENT:APPLIANCE:AIR CONDITIONER
Summary
THE PLASTIC MATERIAL OF THE CENTER AIR FLOW DUCT, WHICH IS FASTENED BY TWO MOUNTING SCREWS TO THE CEILING OF THE PASSENGER COMPARTMENT, CAN CRACK AND EVENTUALLY BREAK.
Potential Consequence
IF THE PLASTIC BREAKS WHERE IT IS HELD AT THE TWOMOUNTING SCREWS, THE CENTER AIR FLOW DUCT CAN SEPARATE FROM ITS SUPPORTS ANDCAUSE INJURY TO THE PASSENGERS SITTING IN THE CENTER SEAT OF THE VEHICLE.
Remedy
DEALERS WILL INSTALL A REINFORCEMENT PLATE AT THE CONNECTIONS OF BOTH THE CENTER AND REAR AIR FLOW DUCTS.
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary
THE FUEL HOSE ATTACHED TO THE FUEL DISTRIBUTION RAIL ON THE ENGINE MAY SHRINK BEYOND THE CLAMP FORCE OF THE FUEL HOSE CLAMPS, ALLOWING FUEL TO LEAK.
Potential Consequence
FUEL LEAKAGE IN THE ENGINE COMPARTMENT CAN CAUSE AN UNDERHOOD FIRE IF THE FUEL COMES IN CONTACT WITH A SOURCE OF IGNITION.
Remedy
REPLACE THE FUEL HOSE ATTACHED TO THE FUEL RAIL AND INSTALL A NEW SPRING TYPE SELF-TIGHTENING CLAMP.
Lights And Instruments
Summary
THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 108 - LIGHTING. DAYTIME RUNNING LIGHTS WILL NOT OPERATE WITH THE THREE POSITION LIGHT SWITCH IN THE SECOND POSITION. CORRECTION: MAIN LIGHT SWITCH WILL BE REPLACED ON JETTA, CORRADO AND PASSAT AND A RELAY WITH WIRING HARNESS WILL BE INSTALLED.
Generated by Cardog • December 16, 2025
1990 Volkswagen Vanagon
Safety Recalls & Notices
3 Active Recalls
Requires attention
