1990 Volkswagen Passat
Safety Recalls & Notices
5 Active Recalls
Requires attention
Seats And Restraints
Summary
On certain vehicles equipped with seat heating units, the front seat back heaters may supply concentrated heat in a localized area of the seat back or produce excessive heat that could not be reduced by operating the seat heater controls except by switching off the controls completely. The concentrated heat could singe the fabric at the lower backrest and, in some instances, injure the seat occupant. Correction: Dealers will affect repairs.
Heater And Defroster
Summary
INCREASED COOLANT PRESSURE DUE TO ENGINE OVERHEATING COULD RESULT IN RUPTURE OF HEAT EXCHANGER CAUSING PERSONAL INJURY, OR, STEAMING OF INTERIOR. CORRECTION: HEAT EXCHANGER WILL BE REPLACED ON AFFECTED VEHICLES.
ENGINE AND ENGINE COOLING:COOLING SYSTEM
Summary
IN THE EVENT THE ENGINE OVERHEATS AND THE VEHICLE IS OPERATED CONTINUOUSLY IN THAT CONDITION, THE COOLANT PRESSURE WILL RISE TO A LEVEL AT WHICH THE HEAT EXCHANGER COULD LEAK.
Potential Consequence
A LEAKING HEAT EXCHANGER WILL ALLOW HOT COOLANT TO ESCAPE CAUSING INJURY TO THE DRIVER'S FEET OR COULD STEAM UP THE INTERIOR OF THE VEHICLE TEMPORARILY IMPAIRING THE DRIVER'S VISIBILITY, INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy
DEALERS WILL REPLACE THE HEAT EXCHANGER ON THESE VEHICLES.
VEHICLE SPEED CONTROL
Summary
THE VENTURI TUBE LOCATED IN THE THROTTLE VALVE HOUSING CAN BECOME LOOSE AND FALL AGAINST THE THROTTLE PLATE.
Potential Consequence
THE VENTURI TUBE CAN PARTIALLY BLOCK THE THROTTLE PLATEAND PREVENT IT FROM RETURNING TO ITS FULL IDLE POSITION, RESULTING IN UNWANTEDENGINE SPEED WHEN THE VEHICLE IS PLACED IN A FORWARD OR REVERSE GEAR.
Remedy
REPLACE THE PRESS-FIT VENTURI TUBE WITH A THREAD TYPE TUBE.
Lights And Instruments
Summary
THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 108 - LIGHTING. DAYTIME RUNNING LIGHTS WILL NOT OPERATE WITH THE THREE POSITION LIGHT SWITCH IN THE SECOND POSITION. CORRECTION: MAIN LIGHT SWITCH WILL BE REPLACED ON JETTA, CORRADO AND PASSAT AND A RELAY WITH WIRING HARNESS WILL BE INSTALLED.
Generated by Cardog • December 16, 2025
1990 Volkswagen Passat
Safety Recalls & Notices
5 Active Recalls
Requires attention
