2000 Volkswagen Golf
Safety Recalls & Notices
12 Active Recalls
Requires attention
ENGINE AND ENGINE COOLING:ENGINE
Summary
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Potential Consequence
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Remedy
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
EXTERIOR LIGHTING:HEADLIGHTS
Summary
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Potential Consequence
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
EXTERIOR LIGHTING
Summary
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Potential Consequence
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Summary
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Potential Consequence
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Lights And Instruments
Summary
On certain Golf, GTI, Jetta, Jetta wagon, New Beetle, New Beetle convertible, Passat and Passat wagon, the brake lamp switch may malfunction. If this happens, the brake lamps could become inoperative; or could come on and stay on, even though the vehicle is parked. Correction: Dealers will replace the brake lamp switch with a newly revised version. This action includes vehicles previously affected by Transport Canada recall 03-184 and 04-075. The switch installed during this prior repair may not function properly. Note: parts available December 2006.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH GASOLINE ENGINES AND DOUBLE-LAYER FUEL TANKS, TENSION ON THE FUEL SUPPLY LINE MAY CAUSE THE FUEL PUMP SUPPLY NIPPLE TO CRACK WHICH COULD RESULT IN A LEAK.
Potential Consequence
LEAKING FUEL, IN THE PRESENCE OF AN IGNITION SOURCE, MAY CAUSE A FIRE.
Remedy
DEALERS WILL INSPECT THE FUEL SUPPLY LINE FOR TENSION, AND INSPECT THE FUEL PUMP SUPPLY NIPPLE FOR CRACKING. IF NECESSARY THE FUEL LINE AND THE FUEL PUMP WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JULY 25, 2005. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Fuel System
Summary
On certain vehicles equipped with a gasoline engine, fuel supply line tension may cause the fuel pump supply nipple to crack, which could result in a leak. A fuel leak, in the presence of an ignition source, may cause a fire. Correction: Dealers will inspect the fuel supply line for tension, and inspect the fuel pump supply nipple for cracks. If tension is present in the fuel supply line, it will be replaced. If the fuel pump supply nipple is cracked, both the fuel line and the fuel pump will be replaced.
EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH
Summary
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Potential Consequence
THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy
DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Electrical
Summary
On certain vehicles, the hazard switch and flasher system function may degrade over time because of distortion and material transfer of the contacts of certain hazard switch relays which occurs due to substantially increased electrical current load from higher-wattage turn signal bulbs. The subject vehicles utilize a 27-watt turn signal bulb, instead of the 21-watt bulb used in other VW vehicles, which results in substantially higher current draw through the hazard switch relay. This may result in intermittent or inoperative turn signal and hazard flasher function. Correction: Dealers will replace the hazard switch relay.
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Summary
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
Potential Consequence
THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
Remedy
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
Steering
Summary
On certain vehicles, one of two brackets used to bolt the front control arm to the body structure may not have been welded to specifications. Depending on the strength of the weld seams, the control arm could gradually loosen and ultimately separate from its bracket resulting in control difficulty or possible loss of vehicle control. Correction: Vehicles will be inspected and suspect control arms will be replaced.
SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
Summary
VEHICLE DESCRIPTION: PASSENGER VEHICLES. ONE OF TWO BRACKETS USED TO BOLT THE FRONT SUSPENSION CONTROL ARM IN FRONT OF THE VEHICLE TO THE BODY STRUCTURE MAY NOT HAVE BEEN WELDED SUFFICIENTLY.
Potential Consequence
THE CONTROL ARM COULD GRADUALLY LOOSEN AND ULTIMATELY SEPARATE FROM ITS BRACKET IN NORMAL DRIVING WHICH COULD CAUSE THE VEHICLE TO BE DIFFICULT TO CONTROL OR RESULT IN LOSS OF CONTROL. AS THE BRACKET LOOSENS, LOUD METALLIC KNOCKING SOUNDS IN FROM THE VEHICLE WILL BE HEARD.
Remedy
DEALERS WILL INSPECT THE BRACKET AND IF THE WELDING IS INSUFFICIENT, WILL REPLACE THE CONTROL ARM.
Generated by Cardog • December 17, 2025
2000 Volkswagen Golf
Safety Recalls & Notices
12 Active Recalls
Requires attention
