Jeep
Wrangler

I am filing this complaint regarding a known safety defect affecting my 2019 Jeep Wrangler Sahara (VIN: [XXX] ) - specifically the steering damper column defect commonly referred to as "Death Wobble." ISSUE: My vehicle experiences violent and uncontrollable steering wheel oscillation when hitting bumps or road imperfections at highway speeds (typically above 55 mph). This phenomenon causes the entire front end to shake violently, requiring me to immediately slow down to regain control of the vehicle. This poses an extreme safety risk to myself, my passengers, and other motorists. DIAGNOSIS: A certified mechanic has diagnosed my vehicle with steering damper failure - the exact same defect addressed in Customer Satisfaction Notification V41 issued by FCA in June 2019. THE PROBLEM: While FCA issued CSN V41 covering approximately 192,000 2018-2019 Jeep Wranglers for steering damper defects, my VIN was arbitrarily excluded from this notification despite experiencing the identical safety defect. FCA selectively applied the remedy to certain VINs rather than addressing all affected vehicles from these model years. SAFETY CONCERNS: This defect creates loss of vehicle control at highway speeds, significantly increasing crash risk. The NHTSA investigation (PE19-012) identified frame weld quality deficiencies and steering-related defects in 2018-2019 Wranglers affecting approximately 270,000 vehicles. Multiple investigations have documented steering looseness, steering wobble/shimmy, and loss of steering control in these model years. MANUFACTURER REFUSAL: Despite the known defect and my vehicle exhibiting the exact symptoms addressed in CSN V41, Jeep/Stellantis refuses to repair this safety issue under warranty, forcing me to bear the financial burden for a known manufacturing defect. REQUEST: I request NHTSA investigate why FCA limited CSN V41 to select VINs when the defect clearly affects a broader population of 2018-2019 Wranglers, and mandate a comprehensi INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The steering wheel started to shake and then escalated to the whole car shaking at which time I had to stop the vehicle on the highway to make it stop shaking. This isn’t the first time this has happened.

Cluster went dark. No way of seeing gauges moving, no speed info, nothing. Jeep runs but dash is dark.

Main cluster went out cannot see gas or mileage noting important will display

The instrument cluster has stop functioning and you can't see milage, gas or any of the warning lights within the cluster panel. I was not in an accident but wanted to report the problem of the cluster since my jeep was not included in the recall. I have an estimate of 1,600. for a repair from jeep mechanic.I feel that it should have been included in the recall.

Wires going to the trailer hitch lights plug was too close to the muffler melting the insulation and shorting to ground for the left trailer turning light.

The problem occurs in my 2019 Jeep Wrangler, suddenly, typically after hitting a small bump or uneven section of pavement at around 60–70 mph. The entire front end begins to shake violently, and the steering wheel jerks rapidly back and forth, making it extremely difficult to maintain control of the vehicle. The only way to stop the shaking is to brake hard and slow down below 50 mph, which creates a dangerous situation. This violent steering vibration causes loss of directional stability and could easily lead to an accident if it happens in traffic or during lane changes. The sensation is so severe that it feels as if the front suspension or wheels are coming loose. I brought my Jeep to Wallace Jeep in Stuart, Florida where the technicians confirmed steering instability but stated that the steering damper is covered but the steering gear is not covered under warranty. I also contacted Jeep Cares, case # [XXX], and was told that Jeep “does not have to cover” my vehicle, even though it falls directly within the affected 2018–2020 Wrangler JL range identified in the [XXX]. v. FCA US LLC class action settlement related to the Death Wobble. The dealership’s refusal contradicts Jeep’s own Technical Service Bulletin 08-074-20 REV. E (“Improved Steering Feel”), which addresses steering wander, pull, and excessive play by replacing the steering gear and updating the EHPS software — exactly the symptoms I’m experiencing. This is a serious safety issue that occurs without warning and has not been resolved through the repairs or coverage Jeep has offered. The manufacturer’s denial of responsibility despite a known defect leaves drivers at risk of losing control at highway speeds. I am requesting that the NHTSA investigate and require Jeep/Stellantis to expand the recall or provide full coverage for all steering-related components contributing to this dangerous condition. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The internal cluster went out all of a sudden. Stenallis has no part for us to repair it with. We have been without the car and no loaner for almost 4 months. There is a recall on this part on this model in this year. However, Stenallis won't recall my particular car which is currently affected. The recall should expand because it is on more models than they admit.