2002 Envoy

Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.

2019420 · 5,327 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles, the multifunction switch may develop an open circuit condition with the bottom contact of the hazard switch, causing the stop lamps and the hazard lamps to become inoperable (the center high mounted stop lamp and turn signal functions are not affected). The loss of stop lamp and rear hazard lamp function could fail to warn a following driver that the vehicle is braking and/or is stopped, which could result in a crash causing personal injury or death. Correction: Dealers will inspect and replace either the hazard warning switch, or the multifunction switch assembly. Note: This campaign expands the population of recall 2001285.

2008178 · 1,916 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NO 335-1120L-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. DURING PRODUCTION THE LAMP HOUSING SHAPE DEFORMED DISTORTING THE ASSEMBLY ANGLE OF THE REFLECTOR AND INFLUENCED THE AIMING POSITION. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

07E014000 · 308 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

Certain vehicles located in Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador have a rear side door latch that may not latch or not unlatch due to corrosion caused by road splash, such as water and road salt. If the door is not latched properly and goes unnoticed, it could open while the vehicle is in motion. Correction: Dealers will install a seal along the lower part of the rocker panel to prevent intrusion of corrosive material, and inspect the door latch. Functional latches will be cleaned and lubricated. Non-functioning latches will be replaced.

2005328 · 5,138 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA.

05V494000 · 98,007 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.

04V527000 · 871,473 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles, vibration and heat may cause the tail lamp/stop lamp bulb to loosen in its socket. If this occurs, the bulb may flicker and eventually become inoperative. The loss of one or both of the tail lamps/stop lamps could reduce the vehicle's visibility to following drivers and fail to warn others that the vehicle is braking and/or is stopped, which could lead to a vehicle crash. Correction: Dealers will inspect the tail lamp/stop lamp assemblies and, if necessary, replace them.

2004390 · 38,598 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

SOME SPORT UTILITY VEHICLES EQUIPPED WITH AN ELECTRONICALLY CONTROLLED AIR SUSPENSION (ECAS) HAVE A CONDITION IN WHICH THE ECAS MAY PRODUCE A BRIEF ELECTRICAL SPIKE WHILE THE VEHICLE IS OPERATING. THIS ELECTRICAL SPIKE CAN DISRUPT THE POWERTRAIN CONTROL MODULE (PCM) CAUSING THE VEHICLE TO STALL.

04V289000 · 29,951 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles, the Electronically Controlled Air Suspension (ECAS) may produce a brief electrical spike while the vehicle is operating. This electrical spike can disrupt the Powertrain Control Module (PCM) causing the vehicle to stall. If the spike damages the PCM, the vehicle may not restart. Correction: Problem previously addressed by Technical Service Bulletin A001831 in January 2002.

2004195 · 2,974 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

Certain vehicles fail to conform to CMVSS 209, seat belt assemblies. These vehicles have a condition where one or two sensors in the driver's and front seat passengers seat belt retractors may be inoperative. The seat belt retractors will lock when the belt webbing is extracted during a crash; however the mechanism that locks the seat belt retractor when the vehicle decelerates quickly, such as during heavy braking, may not restrain the occupant as intended during a crash, and could result in injury to the occupant. Correction: Dealers will inspect the seat belt assemblies to determine proper vehicle sensor function, and replace them if necessary.

2004158 · 10,976 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

CERTAIN LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." ONE OF THE TWO SENSORS IN THE DRIVER'S AND FRONT PASSENGER'S SEAT BELT RETRACTORS COULD BE INOPERATIVE. THE SEAT BELT RETRACTORS WILL LOCK WHEN THE BELT WEBBING IS EXTRACTED DURING A CRASH; HOWEVER, THE MECHANISM THAT LOCKS THE SEAT BELT RETRACTOR WHEN THE VEHICLE DECELERATES QUICKLY, SUCH AS HEAVY BRAKING, MAY NOT OPERATE AS INTENDED.

04V201000 · 261,801 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles, the brake hoses are not labelled with a designation that identifies the manufacturer of the assembly as required by CMVSS 106. This non-compliance has no effect on the performance of the involved brake hose assemblies. Correction: Since this does not pose a safety risk, no corrective action is required.

2004088 · 52,776 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles, water may seep into the windshield wiper module. If this were to happen, it could result in windshield wipers that will not turn on, cease operation while driving, fail to turn off, turn on by themselves, and/or continuous windshield washer pump operation. Improper operation of the windshield wiper system in a severe weather situation could reduce the driver's visibility, resulting in a possible vehicle crash without prior warning. Correction: Dealer will install a Gore-Tex patch over the windshield wiper module vent-hole. The wiper motor, circuit board, and electrical connector will be inspected for signs of water intrusion and/or corrosion and replaced as required.

2004045 · 28,986 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.

04V046000 · 581,394 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.

03V250000 · 1,707,825 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARDS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION" AND NO. 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES HAVE AN INTERMITTENT CONDITION DURING VEHICLE START-UP IN WHICH THE INSTRUMENT PANEL CLUSTER MAY NOT PROPERLY POWER UP, RESULTING IN MOST OF THE DISPLAYS, TELLTALE LIGHTS, AND FUNCTIONS (EXCEPT THE SERVICE ENGINE LIGHT, TURN SIGNAL INDICATORS, AND THE INSTRUMENT PANEL CLUSTER BACKLIGHTING) BEING INOPERATIVE.

03V096000 · 314,300 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES ARE EQUIPPED WITH A MECHANICAL OVERRIDE THAT COULD ALLOW THE IGNITION KEY TO BE REMOVED WITH THE SHIFT LEVER IN A POSITION OTHER THAN PARK. IN ADDITION, THESE VEHICLES HAVE AN OVERRIDE THAT CAN ALLOW THE TRANSMISSION TO BE SHIFTED OUT OF PARK WITH THE IGNITION IN THE OFF POSITION.

03V075000 · 511,167 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

Certain vehicles fail to conform to CMVSS 114 - Theft Protection. These vehicles are equipped with a mechanical override that could allow the ignition key to be removed with the shift lever in a position other than park. In addition, these vehicles have an override that can allow the transmission to be shifted out of park with the ignition in the off position. These overrides are not permitted unless the vehicle has a locking steering column and the overrides have covers that can only be removed with a screwdriver or other tool. Correction: Dealers are to eliminate these conditions by disabling the overrides.

2003048 · 24,685 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

CERTAIN SPORT UTILITY VEHICLES ARE MISSING WELDS ON THE REAR FLOOR PLAN.

02V273000 · 46 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

ON CERTAIN SPORT UTILITY VEHICLES, A FUEL FILTER FITTING CAN BECOME DISCONNECTED. IF THIS WERE TO OCCUR WHILE ATTEMPTING TO START THE ENGINE, A NO-START CONDITION WOULD RESULT AND FUEL WOULD BE PUMPED OUT THE FUEL FILTER ONTO THE GROUND.

02V121000 · 136,511 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

Certain vehicles may have a driver's side airbag inflator that could fracture at a weld during a deployment. Pieces of the inflator could strike and injure vehicle occupants and the airbag cushion would not inflate fully, reducing the capacity of the bag to protect the driver. Correction: Dealers are to inspect and if necessary replace the driver side airbag module assembly.

2002151 · 14,654 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

02V222000 · 133,221 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

Certain vehicles may have a fuel filter fitting which becomes disconnected. This could result in a fire or engine stalling. Correction: Dealers will replace the fuel filter quick connect retainers.

2002070 · 5,463 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

Certain (4 wheel-drive) Trailblazer and GMC Envoy vehicle. The calibration of the active transfer case control module may cause insufficient high speed gear engagement. If the gear is not engaged, the vehicle can roll when the transmission is in "park" and a crash could result without warning. Correction: dealers are to reprogram the active transfer case control module (ATCM) calibration to increase gear engagement.

2001253 · 4,631 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

Certain sport utility vehicles Trailblazer and GMC Envoy (4 wheel-drive). The calibration of the automatic transfer case control module or a range shift collar that was not machined properly may cause insufficient high speed gear engagement. If the gear is not engaged, the vehicle can roll when the transmission is in "Park" and a crash could result without warning . Correction: Dealers are to perform a "clean neutral" test, as described in the bulletin and if the ratcheting noise is detected during the test, the dealers are to replace the transfer case.

2001252 · 1,068 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE CALIBRATION OF THE TRANSFER CASE CONTROL MODULE COULD CAUSE INSUFFICIENT HIGH SPEED GEAR ENGAGEMENT.

01V334000 · 78,004 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

Certain 4WD vehicles were built with a range shift collar in the transmission transfer case that contains cracks. This condition could result in a complete fracture of the range shift collar and subsequent loss of vehicle forward and reverse gears, and the inability to maintain "park" position. This increases the risk of a vehicle crash resulting from unintended movement of a parked vehicle. Correction: Dealers will replace the transfer cases and update the control module calibration.

2001226 · 64 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES (4 WHEEL-DRIVE). SOME OF THESE VEHICLES WERE BUILT WITH A RANGE SHIFT COLLAR IN THE TRANSMISSION TRANSFER CASE THAT CONTAINS CRACKS.

01V283000 · 895 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

Certain vehicles fail to comply with requirements of CMVSS 201, "Occupant Protection." These vehicles have a console cover/armrest lid latch that could release at less than the 10g vertical load requirement of the standard. In the event of a crash, the console cover could open and the cover or items stored under it could injure an occupant. Correction: Dealers will replace the console latch mechanism and install a separate striker plate.

2001129 · 325 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACTS." THESE VEHICLES HAVE A CONSOLE COVER/ARMREST LID LATCH THAT COULD RELEASE AT LESS THAN THE 10G VERTICAL LOAD REQUIREMENT OF THE STANDARD.

01V158000 · 8,197 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles, either front lower control arm brackets may fracture, which could result in separation of the front lower control arm from the frame. This could result in loss of vehicle control, and a crash without prior warning. Correction: Dealers will replace the left and right front lower control arm brackets.

2001098 · 1,016 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CIRCUMSTANCES THE FRONT LOWER CONTROL ARM BRACKETS MAY FRACTURE. THIS FRACTURE COULD RESULT IN SEPARATION OF THE FRONT LOWER CONTROL ARM FROM THE FRAME.

01V126000 · 30,476 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer