Ford
Expedition

I was driving down the road at 45 MPH, I pushed the accelerator then my vehicle shifted out of drive to neutral, the RPM increased, the car speed decelerated, then the vehicle put itself back in gear severely downshifted so much that my car lost 20 MPH then the engine returned to normal after a violent shake and loud grinding noise. The car could have caused an accident had there been anyone behind me. Luckily there were no other cars around me. I had the vehicle towed to the dealer. They are unable to duplicate the issue I stated but did indicate a skip in cylinders when they hooked it up. I had the transmission overhauled at 53K when it was not shifting properly. I asked Ford to replace the transmission however they elected to overhaul it. From time to time the transmission would shift odd but nothing of over concern. The incident on Nov 3 was very unusual and safety of travel for me. The vehicle had done something similar earlier that morning but that time it was from a stop and no speed so not nearly as violent as the one later that evening. The vehicle is currently sitting at a dealer needing a transmission replaced, however the vehicle is 500 miles over the 75K ESP. Ford is refusing to discuss the problem.

Passenger side daytime running lights (DRL) have dimmed, diminishing daytime visibility . LED bulb may be out. Seems to be a common problem per other Expedition owners. There were no warnings or messages stating problem. The only way to fix the problem is by replacing the entire headlamp assembly ($1,200 plus labor).

The transmission started jerking and downshifting and and like the brakes was coming on and stoping you and I was pulling out onto the road and it wouldn’t go and I was setting in the middle of the road with oncoming traffic and scared for my life, luckily I didn’t have anyone with me and it moved a little and I was finally able to get it out of the road. This is the problem everyone is having FORD you need to recall these transmissions and replace them with new ones that are better this is a shame and bad business. It is hard enough to afford buying vehicles in this day and time and then it need a transmission that is expensive to replace.

Since November 2024 to date the transmission has reduced power when trying to accelerate thus being unsafe when trying to pull out into traffic. It also will not engage reverse thus again impeding when in traffic. It appears randomly. Verified software has been updated. Ford is saying complete transmission replacement is needed on a vehicle that is only 7 years old.

The sunroof on my 2018 Ford Expedition is leaking at multiple points and has become stuck and inoperable. The dealership advised that the brackets are broken and the entire sunroof assembly must be replaced. The leak occurs in several areas across the Vista Roof, causing water to enter the cabin. This appears to be related to known design defects already referenced in multiple Ford Technical Service Bulletins (TSB 18-2374, TSB 19-2374, and TSB 21-2292). Details: I purchased this 2018 Ford Expedition on August 17, 2024, from Battlefield Ford in Culpeper, Virginia, where it underwent a Ford Blue Warranty inspection before sale. The vehicle had approximately 98,000 miles at purchase and now has around 109,000 miles. Shortly after purchase, I noticed water intrusion from the sunroof area. The vehicle was inspected at Sheridan Ford in Smyrna, Delaware, where technicians confirmed leaks at four separate points, broken sunroof brackets, and recommended complete sunroof replacement. In addition to the leaks, the sunroof is stuck and will not operate properly. Ford customer service was contacted, but they stated that no assistance or goodwill coverage would be provided. I find this unacceptable given the severity of the issue, the existence of related TSBs, and the potential safety hazards associated with electrical and visibility impairment due to water intrusion. The vehicle also required brake replacement shortly after purchase, despite being reported as low 3 mm during the Blue Warranty inspection, which raises additional concerns about the adequacy of Ford’s inspection process and potential oversight of critical components. Safety Concerns: Water intrusion may affect electrical components, airbags, or roof-mounted sensors, increasing the risk of malfunction or short circuits. The sunroof’s inability to close or seal properly could result in driver distraction, loss of visibility, or mold and corrosion inside the cabin.

The contact owns a 2018 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V197000 (Seat Belts); however, the part to do the recall repair was not yet available. The contact stated that while refueling the vehicle, the contact heard an abnormal firecracker-like sound coming from the vehicle. The contact later noticed that the front driver's side seat belt had retracted and was locked. The vehicle was taken to an independent mechanic, where the contact was informed that the seat belt pretensioner had deployed, causing the seat belt to be locked. The vehicle was taken to the dealer, where the same assessment was made; however, the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the manufacturer was made aware of the failure and advised the contact to continue driving the vehicle even though the front driver's side seat belt was inoperable. The failure mileage was approximately 121,992.

-The transmission shifts hard and often skips a gear while driving -On slick roads it is easy to loose control from the sudden shift and jerk. -Yes, I have taken it to the dealer and they confirmed the problem and said that it is a known issue. -Yes the dealer has inspected it -There were no warning lamps or messages.

At highway speed the car erratically shifted and lost power most likely due to cdf drum failure in the transmission. It happens randomly due to a known transmission issue. Can you imagine loosing power at hwy speed with a vehicle full of children?