Volkswagen
Jetta

While driving home from work last night, I heard a loud noise that sounded like a gun going off right in the passenger compartment of my Jetta. A lot of wind noise followed. I thought initially that a tire might have blown out, but it was the car’s sunroof that had spontaneously and inexplicably exploded. There was no one close to me on the road, so I don’t believe a foreign object struck the roof. I was able to drive the car home, but the sunroof is demolished.

The rear brake pads on my 2021 Volkswagen Jetta have worn out prematurely twice by 20,000 miles. The first replacement occurred at only 8,006 miles in April 2023. At that time, Volkswagen acknowledged the problem and provided “goodwill” coverage of 50% since my vehicle was only one month outside of the Rear Brake Pad Limited Warranty Extension. Now at approximately 20,846 miles in September 2025, the rear pads have worn out again and required replacement. Volkswagen has refused to provide any assistance this time. Normally, front brake pads wear faster than the rear. In this case, the rear pads are failing far earlier than expected, which creates a potential safety issue since brake performance is being compromised at very low mileage. Volkswagen has already acknowledged this defect by issuing the warranty extension for 2020–2023 Jettas, but coverage expired by time, not mileage, leaving owners like me with repeated failures and no support. When I raised the issue with my dealership, they suggested that the premature wear is due to the emergency brake always being engaged when the car is parked. This explanation does not make sense, since pads do not normally wear when the car is stationary. The fact that VW created a warranty extension for this exact problem shows this is a design defect, not a misuse issue. This issue has been confirmed by a Volkswagen dealer and independent service centers, and is well-documented among other owners. If the pads continue to wear this quickly, it poses a recurring safety risk and results in abnormally high repair costs for a critical safety component. I am reporting this so NHTSA is aware that the defect continues to affect owners even beyond the limited warranty extension and goodwill offers, and that a long-term solution is needed.

On steep hills the car automatically holds the brake for a predetermined amount of time, I believe 2.5 to 3 sec. I have a manual transmission car and when its time to move the brake assist won't release no matter what until the time interval is satisfied. The problem this creates is a stall issue. Its hard to coordinate when to depress the clutch and give gas. Too early and you lead to premature clutch wear or clutch overheating. Too late and the car stalls and you have to restart it. This is very because now you have to restart the car and can cause an accident.

Shifting vehicle into reverse, turns of back up camera, then shifting into drive camera remains on for a set period of time, if shifted back into reverse as camera turns off, camera will not come back on. Android Auto was being used.

Starting in 2022 at 16,000 miles this vehicle has been to dealership 8 times for check engine light related to the EVAP. Multiple repairs have been done and still same issue. VW does not seem interested in properly addressing this problem.

The car is at the dealer service department for the fifth time for EVAP system faults.

Door stopped opening from handle from outside after unlocking with remote only opens from inside door handle

Driver door lock actuator motier lock sticking not opening from outside have to open from inside handle after unlocking with the remote