2011 Avalon

Issue: This recall is for certain block heater kits installed on certain vehicles or sold as accessories at Toyota or Lexus dealerships. On certain vehicles, the engine block heater cable may not have enough heat protection and could be damaged by high temperatures. If this happens, the cable could short circuit while plugged in, and cause the wiring to overheat or melt. Note: This recall only affects the following block heater/cord part numbers: C014003034 PK5A408J09 PU14000904 C014003151 PK5A408J13 PU14000905 C014000885 PK5A489J11 PU14000907 C014000888 PK5A489J22 PU14000909 C014000907 PK5A410H00 PU14000911 C014100904 PU14000900 PU14000913 C014100907 PU14000901 PU14003571 C014100911 PU14000902 PK5A489J14 PK5A408J05 PU14000903 Safety Risk: Engine block heater wiring that overheats or melts could create the risk of a fire. Corrective Actions: Toyota recommends that you should stop using the engine block heater immediately. Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to disable the engine block heater. For some vehicles, the corrective actions for this recall are under development. For others, a new engine block heater cannot be installed, and the owner will receive a refund of the purchase price of the engine block heater.

2021723 · 55,683 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles equipped with a trunk-mounted sub-woofer, cargo in the trunk could contact the sub-woofer's soft braided wire, which could cause the wire to move out of its normal position. If one of these wires were to come into contact with the metal frame of the sub-woofer, it could result in an intermittent short, causing the integrated circuit (IC) in the audio amplifier to become damaged. In some cases, the damaged IC could create a closed circuit between the power supply and sub-woofer, and electric current could continue to flow to the sub-woofer. If this were to occur, the sub-woofer could overheat, increasing the risk of fire, causing injury and/or damage to property. Correction: Dealers will replace the audio system amplifier and install a protective cover around the subwoofer. In the interim, dealers will disconnect the rear sub-woofer.

2015038 · 1,285 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2012 Toyota Avalon vehicles manufactured February 9, 2010, to October 22, 2012. In the affected vehicles, the sub-woofer speaker located in the trunk may experience an intermittent electrical short which may cause damage to the integrated circuit (IC) in the audio amplifier. In some cases, the damaged IC may allow a constant electrical current flow to the sub-woofer.

15V047000 · 51,495 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer