Mercedes-Benz
Sl-Class

To who may this concerned, I have a 2003 Mercedes SL500 and recently found my battery control module caught on fire and burnt a section of my car. I have tried reaching out to Mercedes directly first and they said the car is 20 years ago and it could have not be a manufactured defect. Please I need help this problem could’ve burn down my house or while I was driving. Mercedes requested I send them a letter in writing if I have to get the car inspected. Please setup and date so I can write them this is 100% liability on their brand as there is no schedule maintenance for a battery control module.

I am concerned with the battery control module. I have noticed there has been a lot of incidents out there where the battery control module in the SL 500s have caught fire! I am concerned for my safety due to this defect!

The battery control module (known as the BCM or BNS) failed, triggering a fire. The incident occurred while the vehicle was parked in a garage and had not been operated for several weeks. The fire consumed the module, insulation on wiring connected to and close to the module, part of the trunk lining material, and burned through a total of five hydraulic lines (retractable roof hydraulics). It appears that the trunk seal limited air to the point that the fire was self extinguished. This is the only thing that saved the attached garage and house. The vehicle valued at $30,000 was determined to be a total loss due to the extensive repairs required to restore it to an operating condition. I have since joined a Facebook group "Mercedes BNS/BCM Fires" that has nearly 1000 members and found that this is a common issue with the Mercedes R230 model and fires have occurred dozens if not hundreds of times. We have determined that the module has undergone numerous changes, but there is no confirmation that any are safe. Mercedes refuses to provide guidance or solutions to this issue and apparently has no regard for the safety of current owners. I have retained the failed module, wiring, hydraulic lines, and burned portion of the trunk lining. It is available for inspection or analysis. I am a mechanical engineer with over 35 years experience in the automotive and industrial areas.

The contact owns a 2003 Mercedes-Benz SL500. The contact stated while driving at various speeds, the ABC warning light illuminated. Additionally, the message "Drive Carefully" was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed that the ABC tandem pump, struts, and hoses needed to be replaced. The dealer was notified of the failure and informed the contact that they did not provide service for older vehicles. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 88,000.

It appears the BCM (Battery Control Module) caught fire and burned a significant portion of the trunk and associated wiring.

My car (the SL55 and all SL models) has a "Battery Control Module" (BCM) also referred to as the "Battery Stabilization Control Load Module" which shows signs of imminent failure which will lead to a meltdown or fire. I inspected the module after finding that this was a common problem with these cars online. This model of car has been documented to completely catch on fire, even when parked after driving. I have pictures of the burnt board inside my BCM. I am very concerned as it could literally burn my house down. The typical warning for this issue is a red colored warning on the dash LCD display, however I didn't have that warning as my unit is apparently still functioning even though it's compromised.

ABC (Active Body Control) light keeps coming on and body goes up and down when I drove car. Light says do not drive. Mercedes would not take responsibility for this in spite there are so many complaints about this. Really irresponsible by Mercedes.

I was driving my car at 45 mph and suddenly, unexpectedly a red light flashed ABC do not drive. Smoke was coming from under the car and the front end of the vehicle collapsed downwardly. I had to call for a tow truck to take my vehicle to the MB dealership. I'm I am waiting for the prognosis. I've had numerous issues with the All Body Control system. Expensive repairs in the $3000-$8000 range. This is a safety issue the breakdown happens abruptly and I was fortunate other cars weren't on the parkway with me. Otherwise a crash could gave occurred.