Audi
A6

The water pump on my 2016 Audi A6 has failed multiple times prematurely. The first water pump failed at 36,965 miles in May 2019. That repair was covered under an extended warranty I purchased. The second water pump failed around 83,000 miles in September 2025, and Audi is now quoting me $2,350 out of pocket to replace it. I am now facing a third water pump replacement, which is far earlier than expected for this type of component. These repeated failures create a significant safety concern, as sudden coolant loss can cause the engine to overheat, potentially leading to engine failure or loss of power while driving. Each problem has been diagnosed and confirmed by an authorized Audi service center. The vehicle was inspected by Audi technicians, and repairs were recommended both times. The repeated failure of this critical component strongly suggests a systemic defect with the water pump design on this model. Despite a recent Audi water pump settlement, my vehicle was excluded, even though it has now experienced two failures and is requiring a third replacement.

This vehicle had a claim for water pump replacement and the 3.0 model has a recall for the turbo charger. This vehicle is experiencing the same issues and went from 70 mph to 0 and stalled on the freeway. Thankfully the semi and other vehicles were able to avoid me or my family would be reaching out instead of me. Currently the vehicle is parked in my garage because it is unsafe to drive. Can you please advise Audi to take responsibility and offer the same recalls on the 2.0 vehicles for the water pump and turbo charger because they have the same internal parts as the 3.0 vehicles that failed and these parts were covered.

Engine area of car caught fire with ignition off

The contact owns a 2016 Audi A6. The contact stated that while driving approximately 40 MPH, the vehicle suddenly experienced a loss of motive power and stalled. During the failure, the message Electric Power Control "EPC" was displayed. The vehicle was later towed to the local dealer who diagnosed that the electric wiring harness located in the engine compartment had failed due to moisture intrusion and the harness along with an internal computer needed to be replaced. No further information was available. The vehicle was not yet repaired. The failure mileage was 49,000.

I took the vehicle into a repair shop because the check engine light is on. I was advised that the water pump is leaking and it needs to be replaced along with the thermostat. The turbo charger assembly also needs to be replaced. Both of these items appear to be deficient and were listed under recent recalls on similar Audi vehicles and this VIN was not included in either recall. However, it appears to be a similar concern and should be resolved by the Manufacturer.

I am the original owner of my vehicle and have had my vehicle maintenance done at Niello Audi in Sacramento, CA. In May 2023, the forward facing camera on my 2016 Audi A6 stopped working. The dashboard error message was "ACC and Audi braking guard Unavailable". As a result, the automatic emergency braking, forward collision warning, lane keeping assist, and cruise control stopped working. In June of 2023 I took the vehicle in to the above named dealer and they indicated that the front facing camera would need to be replaced but they could not do so because the part in on back order. The part number is 4H0907217FX. Ever since June 2023, the dealer has indicated that the part is still on back order and unavailable. Today March 28, 2024, I contacted AUDI USA and was informed that Audi stopped making that part and it is no longer available. I have been waiting almost a year for Audi to correct this to no avail. The part in question is tied to several safety systems (emergency braking, collision warnings, etc.) and I feel that my vehicle is unsafe to drive. Obviously, this concerning safety issue affects all Audi owners in the United States and I think Audi should immediately be required to fix this safety issue.

The camera associated with the adaptive cruise control and collision warning systems thought there was an object in the road multiple times while on active cruise control. This resulted in the brakes being engaged - could have been rear ended very easily causing an accident. The camera system has now stopped working all together resulting in the safety systems being disabled entirely as well as the cruise control. After researching the issue and talking to the dealership I have found the camera to be a very common part failure with all Audi's. I can't even get the part there is such a large demand for repairs.

While driving the car, the steering column failed, making the car unable to steer. Mileage 81,312. The error message was Steering Malfunction, do not drive. and you could not turn the wheel. The independent service center confirmed and replaced the steering column. They stated they are doing 1-2 a week and Audi knows it's an issue as they are stocking the column. The repair cost me $5,000.00. There was no warning until it didn't work.