1992 Volkswagen Jetta
Safety Recalls & Notices
7 Active Recalls
Requires attention
EXTERIOR LIGHTING
Summary
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Potential Consequence
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
SERVICE BRAKES, HYDRAULIC
Summary
CERTAIN HYDRAULIC BRAKE HOSES, P/N 171.611.107B, SOLD AS REPLACEMENT EQUIPMENT FOR 1975-1985 VOLKSWAGEN (VW) RABBIT; 1985-1992 VW GOLF; AND 1980-1992 VW JETTA PASSENGER VEHICLES. POSSIBLE BRAKE HOSE RUPTURE COULD OCCUR WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 106, "BRAKE HOSES."
Potential Consequence
BRAKE HOSE RUPTURE COULD RESULT IN LOSS OF BRAKING ABILITY, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy
FOREIGN PARTS DISTRIBUTORS WILL NOTIFY OWNERS AND REPLACE THE BRAKE HOSES WITH COMPLIANT BRAKE HOSES. THE RECALL BEGAN ON MARCH 30, 2006. OWNERS MAY CONTACT FOREIGN PARTS DISTRIBUTORS AT 305-885-8646 EXT. 11.
Engine
Summary
NOTE: GASOLINE POWERED FUEL INJECTED VEHICLES. DURING WINTER PERIODS OF LOW TEMPERATURE WITH HIGH HUMIDITY, THE AIR PRE-HEATING SYSTEM MAY NOT BE SUFFICIENT TO PREVENT THROTTLE ICING DURING LONG DISTANCE DRIVING DUE TO PRE-HEATER VACUUM SWITCH CONTAMINATION. THIS COULD PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION WHEN THE ACCELERATOR PEDAL IS RELEASED. CORRECTION: A DE-ICING KIT WILL BE INSTALLED IN AFFECTED VEHICLES.
Fuel System
Summary
FUEL LEAKAGE MAY OCCUR AT THE FUEL HOSE TO FUEL RAIL CONNECTION. ESCAPING FUEL COULD COME INTO CONTACT WITH HOT ENGINE COMPONENTS AND POSSIBLY CAUSE AN ENGINE COMPARTMENT FIRE. CORRECTION: FUEL HOSE WHICH ATTACHES TO THE FUEL RAIL WILL BE REPLACED AND NEW SPRING TYPE HOSE CLAMPS WILL BE INSTALLED.
Structure
Summary
CORROSION DUE TO ROAD SALT MAY PREVENT THE HOOD LATCH AND THE SAFETY CATCH FROM WORKING PROPERLY. THIS COULD RESULT IN HOOD FLY-UP WHILE THE VEHICLE IS IN MOTION RESULTING IN OBSCURED DRIVER VISION AND A POSSIBLE CRASH. CORRECTION: OWNERS OF AFFECTED VEHICLES WILL BE ADVISED BY MAIL REGARDING THE NECESSITY FOR PERIODIC LUBRICATION OF THE ENGINE HOOD LATCH MECHANISM. DEALERS WILL BE ADVISED TO LUBRICATE THE ENGINE HOOD MECHANISM WHENEVER AN AFFECTED VEHICLE IS BEING SERVICED.
VEHICLE SPEED CONTROL
Summary
THE VENTURI TUBE LOCATED IN THE THROTTLE VALVE HOUSING CAN BECOME LOOSE AND FALL AGAINST THE THROTTLE PLATE.
Potential Consequence
THE VENTURI TUBE CAN PARTIALLY BLOCK THE THROTTLE PLATEAND PREVENT IT FROM RETURNING TO ITS FULL IDLE POSITION, RESULTING IN UNWANTEDENGINE SPEED WHEN THE VEHICLE IS PLACED IN A FORWARD OR REVERSE GEAR.
Remedy
REPLACE THE PRESS-FIT VENTURI TUBE WITH A THREAD TYPE TUBE.
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary
THE FUEL HOSE ATTACHED TO THE FUEL DISTRIBUTION RAIL ON THE ENGINE MAY SHRINK BEYOND THE CLAMP FORCE OF THE FUEL HOSE CLAMPS, ALLOWING FUEL TO LEAK.
Potential Consequence
FUEL LEAKAGE IN THE ENGINE COMPARTMENT CAN CAUSE AN UNDERHOOD FIRE IF THE FUEL COMES IN CONTACT WITH A SOURCE OF IGNITION.
Remedy
REPLACE THE FUEL HOSE ATTACHED TO THE FUEL RAIL AND INSTALL A NEW SPRING TYPE SELF-TIGHTENING CLAMP.
Generated by Cardog • December 16, 2025
1992 Volkswagen Jetta
Safety Recalls & Notices
7 Active Recalls
Requires attention
