1998 Gmc Sonoma
Safety Recalls & Notices
7 Active Recalls
Requires attention
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Summary
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Potential Consequence
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Electrical
Summary
Certain vehicles: Light duty trucks. passenger vehicles and sport utility vehicles. Certain vehicles do not comply with the requirements of C.M.V.S.S. NO. 118, "POWER-OPERATED WINDOW, PARTITION & ROOF PANEL SYSTEMS." When the hazard flasher switch is used to turn the hazard flashers on or off, the retained accessory power (RAP) feature can be activated without a key in the ignition. Correction: There is no detrimental effect on vehicle safety so no corrective action is necessary.
EXTERIOR LIGHTING
Summary
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE DAYTIME RUNNING LIGHTS BUILT WITH A CANDELA VALUE GREATER THAN 3,000 CANNOT BE MOUNTED HIGHER THAN 864MM ABOVE THE ROAD SURFACE.
Potential Consequence
THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy
DEALERS WILL INSTALL A REVISED WIRING HARNESS THAT CHANGES THE DRL'S FROM HIGH BEAM TO LOW BEAM DRL'S, AND INSTALL NEW LONG-LIFE LOW BEAM BULBS.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Summary
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. A FATIGUE FRACTURE OF THE REAR AXLE RIGHT-HAND BRAKE PIPE CAN OCCUR CAUSING A SLOW BRAKE FLUID LEAK RESULTING IN A SOFT BRAKE PEDAL. IF THE BRAKE PIPE BREAKS, THE DRIVER WOULD EXPERIENCE A SUDDEN DROP IN THE BRAKE PEDAL, THE INSTRUMENT PANEL BRAKE LIGHT WOULD ILLUMINATE, AND THERE WOULD BE A LOSS OF REAR BRAKE PERFORMANCE.
Potential Consequence
PARTIAL LOSS OF BRAKING AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED COULD RESULT IN A VEHICLE CRASH.
Remedy
DEALERS WILL INSPECT AND REPLACE THE BRAKE PIPE.
Brakes
Summary
Certain vehicles may exhibit a fatigue fracture of the rear axle, right-hand brake pipe. Should the pipe crack a slow brake fluid leak would result causing a soft pedal and an eventual decrease in rear braking capability. Should the pipe break there would be a sudden drop in the brake pedal and a loss of rear brake performance. Correction: A brake pipe bracket will be installed on affected vehicles.
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
Summary
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE VEHICLES. AN ENGINE ELECTRICAL WIRING-HARNESS CLIP CAN MELT AND DRIP ONTO THE EXHAUST MANIFOLD.
Potential Consequence
THE CLIP MATERIAL ON THE EXHAUST MANIFOLD CAN IGNITE AND SUBSEQUENTLY IGNITE OTHER COMBUSTIBLE COMPONENTS RESULTING IN A VEHICLE FIRE.
Remedy
DEALERS ARE CONTACTING OWNERS BY TELEPHONE TO HAVE THEIR VEHICLES TOWED TO THE DEALER AND ALTERNATE TRANSPORTATION PROVIDED TO THEM UNTIL THE DEALER CAN REROUTE THE ELECTRICAL WIRING-HARNESS.
Engine
Summary
On certain vehicles, the engine wiring harness clip could melt and drip onto the exhaust manifold. The clip material on the exhaust manifold could ignite and subsequently ignite other combustible components in the immediate vicinity resulting in a vehicle fire without prior warning. Correction: Electrical wiring harness will be rerouted.
Generated by Cardog • December 16, 2025
1998 Gmc Sonoma
Safety Recalls & Notices
7 Active Recalls
Requires attention
