1996 Windstar

On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. Correction: Dealers will install a new switch or fused wiring harness. Note: This is an expansion of recall 2005028 (05S28) for vehicles not previously included in the campaign.

2009292 · 492,877 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

09V399000 · 4,500,000 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain Windstars the crossover brake line above the catalytic converter may contact the dash panel insulator. The salt and water absorbed by the insulator may promote corrosion. Exhaust heat can also accelerate the corrosion process which may ultimately lead to a leak in the brake line. These vehicles were originally sold or currently registered in the provinces of Ontario, Quebec, New Brunswick, Nova Scotia, PEI, and Newfoundland and Labrador. Correction: Dealers will reposition or replace the line as needed.

2002066 · 43,426 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

ON CERTAIN MINIVANS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. DURING ASSEMBLY, SOME BRAKE LINES WERE INSTALLED IN A TWISTED POSITION, CAUSING CONTACT WITH THE DASH PANEL INSULATOR ABOVE THE CATALYTIC CONVERTER. THIS CONTACT COULD ABRADE THE BRAKE LINE CORROSION PROTECTION, CONSEQUENTLY, SALT OR WATER ABSORBED IN THE DASH PANEL INSULATOR WOULD PROMOTE CORROSION. THIS CORROSION COULD ULTIMATELY LEAD TO A LEAK IN THE BRAKE LINE.

02V101000 · 250,283 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1998 FORD WINDSTAR MINIVANS. THE FRONT COIL SPRINGS COULD POTENTIALLY FRACTURE DUE TO CORROSION. NOTE: THE 1997-1998 WINDSTAR MINI VANS ARE ALSO COVERED BY NHTSA SAFETY RECALL 01V-199/FORD RECALL 01S19. THE MINI VANS COVERED BY THE SAFETY RECALL WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA.

01I007000 · 948,492 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.

00V168000 · 20,637 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

Certain vehicles do not comply with the requirements of CMVSS 105 - Hydraulic Brake Systems. The brake fluid warning statement embossed on the side of the brake fluid reservoir is not clearly visible by direct view. Correction: Warning labels, along with installation instructions and wipe materials will be sent to owners. Labels will be installed on the front of the reservoir where they will be entirely visible by direct view.

1999126 · 166,223 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

VEHICLE DESCRIPTION: MINIVANS. THE BRAKE FLUID MASTER CYLINDER IS RECESSED AND ORIENTED IN THE ENGINE COMPARTMENT SO THAT THE BRAKE FLUID WARNING STATEMENT EMBOSSED ON BOTH THE TOP OF THE FILLER CAP AND THE SIDE OF THE RESERVOIR BODY ARE NOT ENTIRELY VISIBLE BY DIRECT VIEW. THESE VEHICLES MAY NOT FULLY COMPLY WITH REQUIREMENTS OF FMVSS NO. 135, "PASSENGER CAR BRAKE SYSTEMS."

99V147000 · 789,723 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

THESE VEHICLES MAY HAVE HAD INCORRECT SERVICE REPLACEMENT BRAKE ROTORS INSTALLED WHICH WILL CAUSE AN IMPROPER WHEEL TO HUB ABUTMENT CONDITION TO OCCUR. WITH AN INCORRECT ROTOR INSTALLED, THE DRIVER MAY EXPERIENCE WHEEL SHUDDER ON BRAKING OR SHIMMY AT HIGHWAY SPEEDS. IF THE VEHICLE IS NOT SERVICED THIS CONDITION COULD EVENTUALLY CAUSE THE WHEEL STUDS TO BREAK. CORRECTION: FRONT ROTORS AND BRAKE PADS WILL BE REPLACED ON AFFECTED VEHICLES.

1998157 · 282 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

UNDER CERTAIN CONDITIONS THE BOND BETWEEN THE INNER AND OUTER HOOD PANELS CAN BEGIN TO SEPARATE. HIGHWAY DRIVING CAN CAUSE AIR TO ENTER BETWEEN THE INNER AND OUTER PANELS WHICH CAN FORCE THE OUTER PANEL UPWARD, AND COULD RESULT IN TOTAL SEPARATION OF THE OUTER HOOD PANEL. THIS CAN RESULT IN A ROAD HAZARD AND A POSSIBLE CRASH WITHOUT PRIOR WARNING. CORRECTION: VEHICLES WILL BE INSPECTED AND THOSE WITH EVIDENCE OF BOND SEPARATION WILL HAVE THE HOOD REPLACED. WHERE THERE IS NO EVIDENCE OF BOND SEPARATION, ADDITIONAL ADHESIVE WILL BE APPLIED BETWEEN THE INNER AND OUTER HOOD PANELS.

1997183 · 62,645 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS. TEARING OF THE BOND BETWEEN THE INNER AND OUTER HOOD PANELS DURING MINOR FRONT END COLLISIONS CAN RESULT IN A GAP AT THE LEADING EDGE OF THE HOOD. AIR FORCED BETWEEN THE INNER AND OUTER PANELS CAN PRODUCE ENOUGH PRESSURE TO FORCE THE OUTER PANEL UPWARD.

97V180000 · 769,000 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

THE PARK PAWL ABUTMENT BRACKET HAS A SHARP EDGE WHICH MAY CAUSE THE PARKING PAWL TO HANG UP AND NOT ENGAGE THE PARK GEAR. THIS MAY CAUSE THE VEHICLE TO MOVE EVEN THOUGH THE GEAR SHIFT INDICATOR SHOWS THAT THE VEHICLE IS IN PARK. AS A RESULT, UNINTENDED AND UNEXPECTED VEHICLE MOVEMENT COULD OCCUR WITH THE POSSIBILITY OF PERSONAL INJURY AND PROPERTY DAMAGE. CORRECTION: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PARK PAWL ABUTMENT BRACKET ON AFFECTED VEHICLES.

1996135 · 2,391 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

THE PARK PAWL ABUTMENT BRACKET HAS A SHARP EDGE WHICH CAN CAUSE THE PARKING PAWL TO HANG UP AND NOT ENGAGE THE PARK GEAR. THIS WOULD ALLOW THE VEHICLE TO MOVE EVEN THOUGH THE GEAR SHIFT INDICATOR SHOWS THAT THE VEHICLE IS IN PARK.

96V166000 · 40,000 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 207 - ANCHORAGE OF SEATS. THE FASTENERS SECURING THE DRIVER SEATS TO THE FLOOR PANS MAY NOT HAVE BEEN TORQUED TO SPECIFICATION. CORRECTION: DRIVER'S SEAT TO FLOOR RETAINING NUTS WILL BE TIGHTENED TO CORRECT TORQUE.

1996118 · 23 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

THE FOUR FASTENERS SECURING THE DRIVER'S SEAT TO THE FLOORPAN WERE NOT TORQUED TO PROPER SPECIFICATIONS.

96V114000 · 200 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

NOTE: VEHICLES EQUIPPED WITH FORD AX4S AUTOMATIC TRANSAXLES. THE PARK PAWL SHAFT MAY HAVE BEEN IMPROPERLY POSITIONED DURING TRANSMISSION ASSEMBLY. THIS COULD RESULT IN THE PARK PAWL NOT ENGAGING WHEN THE TRANSMISSION SELECTOR IS PLACED IN THE PARK POSITION. THIS COULD ALLOW THE VEHICLE TO ROLL AS IF IN NEUTRAL IF THE VEHICLE OPERATOR DOES NOT APPLY THE PARKING BRAKE. CORRECTION: VEHICLES WILL BE INSPECTED AND IF NECESSARY THE PARK PAWL SHAFT ROLL PIN AND PARK PAWL SHAFT WILL BE REPLACED.

1996084 · 6,307 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

THE PARK PAWL SHAFT WAS IMPROPERLY POSITIONED WHEN THE ROLL PIN THAT RETAINS IT WAS INSTALLED DURING TRANSMISSION ASSEMBLY. IF THE SHAFT WAS NOT PROPERLY POSITIONED, THE ROLL PIN MAY NOT HAVE LINED UP WITH THE GROOVE IN THE SHAFT AND HAVE BEEN CRUSHED AT ASSEMBLY. ALSO, A BURR COULD HAVE BEEN RAISED ON THE SHAFT.

96V086000 · 100,000 units in campaign · NHTSA

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer