Ford
Mustang

The contact owns a 2005 Ford Mustang. The contact stated that while her husband was attempting to fuel the vehicle, the fuel tank was unable to be fully fueled. The contact stated that either the nozzle would shut off prematurely or gasoline would be prevented from flowing into the fuel tank. There was no warning light illuminated. The contact stated that the failure was intermittent, but by late 2024, the fuel tank could no longer be filled, and the vehicle was placed in storage. The vehicle was taken to a local dealer prior to being placed in storage, and the contact was informed that the fuel tank needed to be replaced. The contact was made aware of Technical Service Bulletin Number: 05-15012; however, the vehicle was not covered under warranty. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 32,000.

The contact owns a 2005 Ford Mustang. The contact stated that the check engine warning light was illuminated. While driving at approximately 25-35 MPH for approximately two miles, the engine started overheating. The oil pan gasket was leaking. The contact stated that the failure was related to NHTSA Campaign Number: 16V779000 (Engine and Engine Cooling). There were several hoses that were split. The vehicle was taken to an independent mechanic who determined that the radiator and engine were cracked, and the pistons were loose. There was air in the oil. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 123,000.

I have experienced two engine failures in my 2005 Ford Mustang due to timing chain issues, specifically the failure of the timing chain cassette, guides, and tensioners in the 4.0L SOHC V6 engine. The first failure happened suddenly with no warning, resulting in severe bottom-end damage, including rod knock. The timing chain cassette ends tend to snap off, sending debris through the engine and damaging lifters, camshafts, and other critical components. The second failure was preceded by an audible “death rattle,” a known symptom of timing chain guide and tensioner failure. Despite this, my vehicle never displayed a check engine light or oil pressure warning before either failure. Unlike later Mustangs with an oil pressure gauge, mine only has a warning light, which never activated.This issue poses a major safety risk, especially at highway speeds. My first engine failure occurred with no prior symptoms, which could have led to an accident had I been merging or overtaking. A failing timing chain can cause misfires, loss of power, or sudden engine shutdown, endangering the driver and others on the road. Independent mechanics have confirmed this issue, and Ford service centers recognize it as a common problem with the 4.0L SOHC V6 engine. Ford has quoted $3,000–$4,000 for timing chain service, making repairs nearly as expensive as engine replacement. These engines rely on multiple chains and hydraulic tensioners that wear out over time, causing slack in the timing chain, jumped timing, and catastrophic damage, typically after 100,000 miles. Despite this, there are no clear warning systems to alert drivers before failure occurs. While timing chains are considered serviceable components, the high failure rate of the timing chain guides and tensioners in these engines, combined with excessive repair costs, indicates a design flaw. I have spent around $4,500 addressing this issue, yet the risk of recurrence remains.

The contact owns a 2005 Ford Mustang. The contact stated that during inclement weather, water was entering the cabin of the vehicle through the passenger’s side glove box. The contact stated that due to the failure, mold had developed throughout the vehicle on the carpet, doors, and interior seats. The contact's husband also discovered that water had entered the computer module after inspecting the vehicle and the module was removed. The contact stated that the vehicle was inoperable after several repairs and several battery replacements. The vehicle was not repaired. The contact called the dealer and was referred to the manufacturer for assistance. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 87,000.

Ford did issue a recall for several issues for my car, including but not limited to, problems when filling gas tank with evaporative purge system as well as cavitation of the fuel pump in high heat conditions, the doors not closing all the way or handles remaining open( not flush with rest of door) when door is shut, driver's side door trim/bezel around power window switch making buzzing sounds when stereo is in use, as well as ticking sounds coming from motor during operation and various creaks and sounds from front suspension when cornering and going over uneven terrain, and the transmission, the 5r55s, has the known hard shift into gear caused by bad servo. I have reached out to the dealers in my area regarding these issues and even though my car is the correct model and year for the service recall bulletins and has the exact issues described there in, I am told that the vin on my car is not covered even though it is clearly suffering from equipment that exhibits all the same problems listed in the recall. I feel the responsibility to perform and pay for these repairs should fall on the manufacturer, not i, the customer.

The contact owns a 2005 Ford Mustang. The contact stated while driving 65 MPH on a rainy night, the headlights started flickering. The contact stated that upon exiting the freeway, while driving 30 MPH, the headlights completely turned off and the hazard lights were inoperable. The contact drove to the nearest gas station and turned off the vehicle. The contact stated that upon attempting to restart the vehicle, the vehicle failed to restart. The vehicle was towed to the residence. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 170,000.

I purchased this car from Trent Family Auto on May 2, 2024. On September 11, 2024 the engine failed. While working on replacing the engine I found an open recall. This is safety related and was never mentioned to me by the dealership. So aside from selling me a bad "as is" they sold me an unsafe vehicle. A vehicle my family has ridden in several times since the purchase. In regard to the recall when I reached out to them about the engine replacement cost they stated recalls can only be taken care of by manufacturing dealerships. Shouldn't they have some ownership to inform customer buying an unsafe vehicle there is an open recall? Thank your for checking into this matter.

Took the 2005 Mustang GT in several years ago to have one airbag replaced. Dealer (Autonation Torrance, California) stated parts were not available for the other side. One of the airbags has never been replaced. I now read there is a "Do Not Drive" recall for vehicles of this year and model in "Zone A".