Fiat
500x

While driving, the vehicle suddenly shut off completely in the middle of the road, forcing me to come to a full stop and make several attempts before it restarted. During the incident, all electrical power was lost—I was unable to use hazard lights or blinkers, and I’m unsure if the brake lights worked when pressing the pedal. This created an extreme safety risk to both myself and other drivers. About a month earlier, the same issue occurred and the dealership diagnosed it as a “battery, fuse, array” problem, replacing the battery. The same issue has now returned, and the dealership has identified it as a MultiAir actuator failure. The vehicle is a Fiat 500X equipped with the 2.4L Tigershark engine, which has known problems with the MultiAir system. The car has only around 60,000 miles and is currently at an authorized Chrysler/Fiat dealership, available for inspection upon request. The problem has been confirmed by the dealer, no warning lights appeared before the failure, and a technical case has been opened with Fiat/Stellantis corporate.

The contact owns a 2016 Fiat 500X. The contact stated that while driving at various speeds, the vehicle stalled. The contact stated that the fuel gauge indicator failed to function as intended. The check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with DTC: P0456 and P0452. The evaporative emission system pressure sensor/switch had failed. Additionally, a leak was detected in the evaporative emission control system (EVAP). The dealer replaced unknown parts on the vehicle. The contact stated that the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed that the fuel filler neck was fractured. The vehicle was repaired three more times after the first failure. The contact stated that on a separate occasion, while driving at an undisclosed speed, the vehicle jerked while driving in second gear and occasionally in third gear. The vehicle was not diagnosed or repaired after the most recent failure. The manufacturer was not made aware of the failure. The failure mileage was 145,297.

I am writing to you in regard to my 2016 FIAT 500X about multiple concerns. 1. There has been an open recall on the Emissions system since 2022. I immediately followed up and was put on a waitlist as I was told that the parts were on back order. I was told I was 27 on the waitlist. I followed up every 3-6 months for an update on getting the recall repaired but was told they have no update on the parts. It is now 2025 and my registration and inspection are expired. I was informed by FIAT service mechanic that the open recall should not impact my inspection. Upon bringing it in for inspection, I needed to get the thermostat replaced, which was one of the first recalls that was rectified upon purchasing the car in 2017. My car failed inspection. I followed up with FIAT corporate and was assigned a case manager who followed up as well unable to rectify the situation. Now my car is unsafe to drive, I have gotten a ticket for expired inspection . I told the officer that there is an open recall and that I am at the mercy of FIAT. Secondly since I purchased the car I have brought it back multiple times, expressing concern that the car lags when you press the gas. If I am merging on the the highway and I am going 30mph the RPM will struggle to go over 3 in order for the car to accelerate and then it falls to 1-2 RPM. Attached are numerous photos of my constant communication of presenting issues. The entire electrical system will turn on and off on its own. Error I have gotten speeding tickets always when trying to switch lanes or am preparing for the exist because I have to compensate for the lag otherwise I will get smashed by another car. When driving 25-40 mph the engine will make a humming sound as if it is stuck in a gear. So my options are 50+ or 25 or less. Living in NY this is very difficult. I have even advocated that I believe my car is apart of the 2016 transmission recall on my particular make and model. My car is unsafe to drive and I need some guidance

Oil level dropped way below minimum. The current consumption is 1000miles every quarter

The car consumes a lot of oil. After 4000 miles I was under 3.5 qt and the oil pressure light would go off

Radio unit failed due to internal short which prevents the blind spot alert, parking sensors and backup camera to no longer function. Fiat no longer manufacturers the replacement part (P/N: 6RV00LXHAA) and states vehicle is not repairable. Car is less than 10 years old and has 25k miles but can no longer be safely operated due to the failed safety systems. Other than this issue car is essentially like new and could provide another decade of use but instead must be added to the overflowing landfills creating yet more pollution. Vehicle manufacturers should be held accountable for such egregious behavior.

The contact owns a 2016 Fiat 500X. The contact stated while driving 30-35 MPH, several messages stating that the 4-WD system and the drive mode selector system were not available were displayed. The vehicle was taken to the dealer, where a computer software update was performed, per the manufacturer's recommendation; however, the failure persisted. The contact stated that the failure recurred upon starting the vehicle. The vehicle was taken back to the dealer, where the cause of the failure could not be determined. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no further assistance was provided. The failure mileage was approximately 73,000.

While driving, the vehicle will randomly shift to Neutral with a message appearing about shifting gears. When this happens I cannot accelerate or brake, and cannot shift gears. The only way to get the car to operate properly again is to turn the engine off and back on. Suddenly losing the ability to drive the car while on the road like this is definitely a safety risk, to me and other drivers. This has happened on three separate occasions for me. I took it to a dealership that was unable to diagnose it as they could not replicate the issue themselves during a test drive. It appears to be the same issue that is described in recall S55. However, even though my car is listed in the recall, I was told my specific VIN is not included. The dealership says there is nothing they can do.