Bmw
X5

On September 2, 2025, my 2025 BMW X5 xDrive50e was involved in a head-on collision with another vehicle. Despite the severity of the impact, the following safety systems failed to deploy: Front airbags Driver seatbelt pretensioner BMW Assist / automatic emergency notification Witnesses reported that my vehicle briefly went airborne before landing with the rear wheels up on a curb. I suffered neck injuries, and my vehicle sustained significant frontal damage. BMW later downloaded the Event Data Recorder (EDR) and confirmed: A frontal non-deployment event Three fault codes in the airbag control module (ACSM) post-crash The crash algorithm activated and reset ΔV reached approx. 12.4 mph longitudinal Forward Collision Mitigation system issued an acute warning 0.5 seconds before impact BMW states the “impulse was not sufficient” to trigger restraint deployment BMW has refused to provide: The deployment thresholds (ΔV criteria) for airbags or pre-tensioners Any engineering explanation for why restraint systems did not activate Any technical rationale for the ACSM fault codes Any escalation beyond Customer Relations All I have been given is an unsigned summary letter and the raw EDR file. BMW Customer Relations stated that engineering is “not customer-facing” and that no additional information will be provided. This leaves serious concerns that: The restraint systems did not function properly in a real-world impact. BMW is refusing to disclose the engineering basis for its conclusions. Consumers may be at risk if this is a repeatable failure mode. I am requesting NHTSA review this incident as a potential defect in the airbag, pretensioner, and/or crash-sensing system in the 2025 BMW X5. I can provide the EDR report, photos, BMW’s letter, and full correspondence upon request. VIN: [XXX] Mileage: 10,700 Crash Date: 09/02/2025 BMW Case #: XXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

drivetrain lights came on out of no where. i was coming to a red light and when car stopped the light on dash came on and message came on for drivetrain malfunction. Car was turned off and on and message went away. Car was brought to dealer and they were able to diagnose saying 3 injector problem and need to replace cylinder head. Was told this a problem with the new V8 engines. can be dangerous if driving and message is gone and continue driving.

The contact owns a 2025 BMW X5. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and the vehicle failed to brake smoothly. No warning lights were illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure; however, the contact was informed that parts were not available. The contact received notification of NHTSA Campaign Number: 24V104000 (Electronic Stability Control (ESC), Service Brakes, Hydraulic); however, the parts were not yet available. The contact stated that the parts had not been available since 2024, when the recall was initiated. The manufacturer was not made aware of the failure. The failure mileage was unknown.

See attached document for complaint.

While driving my 2025 BMW X5 xDrive50e, a “Power Supply Malfunction – Stop Vehicle Immediately” warning appeared on the dashboard, advising me to pull over and call roadside assistance. The vehicle had previously been repaired for the same issue at Braman BMW in Miami, but the malfunction recurred the next day after getting it back. Prior to this, the car was out of service for 103 days following an accident due to BMW’s inability to supply a backordered acceleration sensor. The repair was completed in August 2025. The repeated “Power Supply Malfunction” messages raise concerns about the reliability of the electrical and hybrid power systems and potential loss of power while driving. The issue has been confirmed and documented by Braman BMW. The component remains under BMW inspection.

The rear cross traffic alert on this vehicle either does not work at all or, when it does work, it is ineffective in warning the driver. I brought the vehicle into my BMW dealer and they told me that it is operating as intended. In most cases, when backing out of a parking space or my driveway, I get no warning at all. In some cases, I did get some faint warning that was not obvious enough to actually get my attention. Many times, when I was backing up, I almost was hit by a passing car because I expected to get a warning and did not. There is a very large number of complaints about this problem on the internet. Unfortunately, I did not see these complaints before buying the vehicle. Had I known that this safety feature was ineffective in what it was designed to do, I would not have bought the vehicle. I am actually considering selling vehicle after only 7 months of ownership and taking a loss as a result of this problem. If there is a loss to be taken, it should be by BMW not me as the consumer. I believe that BMW has committed fraud with respect to rear cross traffic alert. They falsely represent that the vehicle has rear cross traffic alert which is a material fact known by them to be false. Buyers, to their own detriment, rely on this false representation in deciding to buy the vehicle. The buyer is not getting an important safety feature that they paid for and the absence of the safety feature puts them at risk of a collision.

NHTSA issued a recall (#24v-104) in Feb of 2024. As yet (1 1/2 years later), no remedy is available. How long must I be at risk of a motor vehicle accident before a solution is available?

While driving this new 2025 BMW X5 M60i vehicle with only 6200 miles, all of a sudden battery failure indicator came on in the middle of traffic, followed by drivetrain failure / malfunction indicator came on. BMW roadside assistance was contacted, and advised me to have vehicle stopped and pulled over immediately and towed. Situation was dangerous as the traffic was flowing at 40 mph. Vehicle Eventually totally lost power. It was towed to local BMW dealership where it was purchased from. The dealership service department was able to reproduce the issue, confirmed that it was a cracked transmission casing, resulting in fluid leak, causing electrical failure and leading to mechanical failure. BMW head office was contacted By the dealership service department and new transmission was requested. Please refer to pages 3 and 4 of the service report attached for details. This is a brand-new vehicle, bought directly from dealership 5 months ago, and had been driven with caution and care. No prior indicators were ever noticed. My safety and safety of nearby vehicles was compromised due to the fact that power was suddenly lost and engine failure unexpectedly occured at such low mileage in fastr flowing traffic. It is incomprehensible that a brand-new vehicle such as this would all of a sudden develop a serious malfunction without prior warning, and have a cracked / broken transmission casing which was found to be leaking fluids. It seems it was defective to begin with.