Audi
Sq5

The contact owns a 2021 Audi SQ5. The contact stated that the vehicle was taken for routine service at the dealer, and the contact was informed that the coolant pump was starting to fail. The contact was advised that the mechanic found coolant running through the vac lines. The contact was informed that continuing to drive the vehicle with a failing coolant pump could cause engine damage. The contact had the coolant pump replaced. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 18V229000 (Engine and Engine Cooling); however, neither the VIN nor the model year was included. The failure mileage was approximately 39,000.

Component/System: Engine and Cooling — Water Pump / Coolant System Vehicle: 2021 Audi SQ5 Engine Code: CWGD Mileage at Failure: 71,000 Date of Incident: 8/6/2025 Audi Denver I’m reporting a known defect affecting my 2021 Audi SQ5 with engine code CWGD. The engine experienced an internal coolant leak from the water pump housing, which is a known issue previously acknowledged by Audi in TSB #19Q5 2022 01, covering earlier 3.0T engines (DEWA/DEWC). Although my engine (CWGD) is not listed in the bulletin, the failure is identical in nature: the plastic thermostat/water pump housing fails internally, leading to coolant loss and potential engine overheating. This issue is widespread among Audi 3.0T engines, including CWGD, and poses a risk of engine failure and overheating. Audi has extended the warranty for earlier engine variants but refuses to cover mine, even though the defect and consequences are the same. This inconsistent coverage leaves owners like me exposed to high repair costs for a clearly known design flaw. I am requesting that NHTSA investigate whether Audi’s CWGD engines should also fall under the scope of the extended warranty or safety defect coverage already applied to DEWA/DEWC engine variants. Audi’s selective VIN or engine code exclusions appear arbitrary and may allow known safety-related failures to go unaddressed. Documentation available: dealer inspection report confirming internal water pump leak, warranty denial letter, and TSB copy.

MMI not connecting Control module for emergency call module

Comfort Module J393 failed that is tied to all electronics warnings in car. brake warnings, light warning, security warnings, etc. Car was unable to be started as a result. If these electronics failed during driving, its very dangerous and could force crashing of vehicle. According to Dealership, failed module was submerged (ie water flooeded). This is a self contained electronics module that is not exposed to elements. The car was parked in driveway. it rained lightly over the weekend. Then this occurred. the damage and replacement cost was over $10K in damage. Audi dealership stated replacing rear water drain may be kinked or damaged causing water to leak where module located. Its not normal for self contained electronics modules to have this problem.

The contact owns a 2021 Audi SQ5. The contact stated that while the gear shifter was shifted into reverse, the rear-view camera displayed a blank screen. As a result, the contact stated that he bumped into another vehicle. The vehicle was taken to the dealer where it was diagnosed that the Back Over Prevention system failed, and the infotainment unit software needed to be replaced. The vehicle was repaired. The contact then stated that he then received notification of the NHTSA Campaign Number: 22V742000 (Back Over Prevention). The manufacturer was notified of the failure and the contact was informed that the recall was previously repaired. The failure mileage was approximately 10,715.

I’ve had a Safety System Malfunction light on for sometime now. Dealership replaced a seat belt part, air bag control module, and still the light won’t go away. The car is currently with the dealership.

The Lighting system is SUB-PAR because You NHTSA has been dragging your feet on approving the ADB Matrix Headlights and allowing AUDI to update the software and enable the system. This is a Safety issue as we cannot realize the full capability of visibility when driving on the highway! NHTSA, please get your ACT together and approve the ADB Headlights!

The pre-sense and/or automatic emergency braking function comes on unnecessarily at least once a week. It will occur when I am driving on the highway and the car thinks there is something in front of me and then the seatbelt will tighten out of nowhere. This is a significant safety risk as it is terrifying and is not being triggered for any legitimate reason. It is so abrupt when it happens that it makes me jump while driving. The worst thing that has happened is yesterday I was going down a ramp toward a parking garage. Out of no where for no legitimate reason while on the beginning of the decline of the ramp, the car automatically applied the e-brake very violently. I was whiplashed forward, felt my neck crack, and then hit my head on the visor quite hard. Today, I have a bruise on my forehead and am not sure whether I had a mild concussion from the incident. It was more violent than when I have been rear-ended in the past. There were no walls, cars, people, ceiling, or objects anywhere near the car to cause this to happen. The pre-sense is a defect and a significant safety risk that can and has caused injury to me.