Newest first. Many cover only part of a model year, so check your VIN with Volvo before booking a repair.
Transport Canada · listed for this model year
Issue: On certain vehicles, there could be a problem inside the high-voltage battery. As a result, the battery modules could overheat and short circuit. Note: This recall only affects certain plug-in hybrid (PHEV) models. Safety Risk: A short circuit in the high-voltage battery can create a fire risk, even while the vehicle is parked and turned off. Corrective Actions: To reduce the safety risk, Volvo advises not to charge your vehicle until the recall repairs have been completed. Volvo will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the high-voltage battery module(s). The dealer will also install an advanced diagnostic software that will monitor the high-voltage battery and warn you if it detects a problem. If you see this warning, you should contact a dealership to arrange replacement of the affected high-voltage battery module(s).
2025147 · 585 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Issue: On certain vehicles, the rods connecting the brake pedal to the hydraulic brake unit may not have been assembled properly. As a result, the rods could loosen, and you may experience a change in brake pedal feel. This can cause reduced braking. Safety Risk: Reduced braking can cause extended stopping distances and increase the risk of a crash. Corrective Actions: Volvo will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, tighten the brake pedal pushrod screw.
2024628 · 82 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Issue: On certain vehicles, a software problem could cause the top-view camera to display instead of the rearview camera image when you are reversing. Canadian regulations require the rearview image to display when reversing. Note: This recall only affects vehicles equipped with a 360-degree park assist camera. Safety Risk: A rearview camera image that does not display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Volvo will notify owners in writing and send a wireless over-the-air update to each vehicle. If the update cannot be completed successfully, or for vehicles without over-the-air (OTA) update capability, Volvo will instruct you to schedule an appointment to have the update performed by a dealer.
2022595 · 31,117 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Issue: On certain vehicles, the fuse for the low-pressure fuel pump may be too small. As a result, the fuse could blow and the engine could stall while driving. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Action: Volvo will contact owners by mail and instruct you to take your vehicle to a dealer to replace the 15 A fuse for the low-pressure fuel pump with a 20 A fuse.
2021345 · 8,506 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Issue: On certain vehicles, the nuts that attach the windshield wiper arms may not have been tightened properly. This could cause the wipers to slip and not clear the windshield properly. Safety Risk: Windshield wipers that do not work properly could affect a driver's visibility. This could increase the risk of a crash. Corrective Actions: Volvo will notify owners by mail and instruct you to take your vehicle to a dealer to tighten the nuts on the windshield wiper arms.
2020390 · 9,867 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Issue: On certain vehicles, the automatic emergency braking system (AEB) may not apply the brakes automatically when it detects a possible collision. In addition, the system may not warn of a potential crash with a non-moving vehicle or object. Note: The regular brake system and all other functions in the vehicle are not affected by this problem. Safety Risk: The AEB system may not provide driver warnings and apply the brakes automatically to help avoid a crash. Corrective Actions: Volvo will notify owners by mail and instruct you to take your vehicle to a dealer to update the vehicle software.
2020099 · 11,834 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
United States records (NHTSA) · 6
These are NHTSA campaigns for 2020 Volvo XC60 vehicles sold in the United States. They are not Canadian recalls: NHTSA's VIN lookup has no Canadian data, and a US campaign may have no Canadian counterpart, or one under a different number covering different vehicles. For a vehicle sold in Canada, go by the Transport Canada listing above and Volvo's Canadian VIN lookup.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
A short circuit in a high-voltage battery increases the risk of a fire.
Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
25V179000 · 7,483 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
23V001000 · 74 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.
Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.
Dealers will replace the hydraulic unit, free of charge. Owner notification letters were mailed October 22, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10120.
21V716000 · 9 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
21V414000 · 85,550 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
The risk of the front wiper arms nut fixation to loosen and not holding the arm in correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
20V503000 · 87,226 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
20V144000 · 121,605 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
2020 Volvo XC60 recall questions
Transport Canada lists 6 recalls for the 2020 Volvo XC60 model year. That counts campaigns naming this model year, not recalls on your vehicle: many cover only a VIN range or production window, and some only vehicles found on inspection. NHTSA lists 6 United States campaigns for the US-market model, shown separately; a US campaign may have no Canadian equivalent.
Enter your VIN in Volvo's Canadian recall lookup, or call a Volvo dealer with your VIN. In Canada the manufacturer is responsible for showing recall and repair status for each VIN, so its lookup is the authoritative answer. Cardog uses your VIN only to find the model year; the recalls shown here are listed for that model year and are not matched to your VIN.
Not necessarily. NHTSA campaigns cover vehicles sold in the United States, and NHTSA's VIN lookup has no Canadian data. When a defect also affects Canadian vehicles, the manufacturer files a separate notice with Transport Canada, often under a different number and sometimes covering a different set of vehicles. For a Canadian vehicle, go by the Transport Canada listing and Volvo's Canadian lookup.
Safety recall repairs are normally done at no charge by an authorized Volvo dealer. The manufacturer's notice for each campaign sets out the remedy and any conditions, so confirm with the dealer when you book.
Once Volvo's lookup or a dealer confirms a recall applies, book the repair with an authorized Volvo dealer and bring your VIN. If the manufacturer's notice says not to drive the vehicle or to park it outside, follow that instruction. Parts can take time, so book early.
Follow the manufacturer's notice for that recall. Most allow normal driving until the repair; some tell owners to stop driving or to park outside until it is fixed. Cardog does not grade recalls by severity: the manufacturer's notice and your dealer are the source.
Manufacturers must notify owners they have on record. If you bought the vehicle used or have moved, update your details with Volvo Canada so notices reach you, and check the manufacturer's lookup from time to time.
Related recall checks
Compare recall listings with alternatives to the 2020 Volvo XC60.