2008 Volvo S80
Safety Recalls & Notices
13 Active Recalls
Requires attention
Seats And Restraints
Summary
Issue: On certain vehicles, the flexible steel cable that attaches the seat belt to the outside of the front seats may weaken over time. As a result, the seat belt could detach. Safety Risk: A seat belt that detaches in a crash could create an increased risk of injury. Corrective Action: Volvo will notify owners by mail and instruct you to take your vehicle to a dealer to replace the front-outboard seat belt anchors.
SEAT BELTS:FRONT
Summary
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
Potential Consequence
An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy
Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
Summary
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Potential Consequence
AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy
VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Accessories
Summary
On certain vehicles, there is a possibility of overheating issues of batteries in the Garmin nüvi® 760 when certain batteries manufactured within a limited date code range are used in certain Garmin nüvi® 760 models with a specific printed circuit board (PCB) design. The interaction of these factors can, in some circumstances, increase the possibility of overheating, which may lead to a fire. Correction: Dealers will direct customers who have an affected unit to the Garmin Web site, which explains how to verify if their units are involved and includes procedures to follow for product exchange.
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
Summary
VOLVO IS RECALLING CERTAIN MODEL YEAR 2007-2010 S80 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE AND LOADING INFORMATION LABEL AND A PAGE IN THE OWNER'S MANUAL CONTAIN INCORRECT MAXIMUM PERMISSIBLE INFLATION PRESSURE AND THE TIRE PRESSURE MONITORING SYSTEM (TPMS) SOFTWARE HAS AN INCORRECT TRIGGER LEVEL.
Potential Consequence
THESE VEHICLES DO NOT MEET THE REQUIRED SAFETY STANDARDS.
Remedy
DEALERS WILL UPDATE THE VEHICLES WITH A NEW TIRE AND LOADING INFORMATION LABEL, OWNER'S MANUAL LABEL AND TPMS SOFTWARE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 27, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR CUSTOMERCARE@VOLVOFORLIFE.COM .
Fuel System
Summary
On certain vehicles, the software within the Central Electronic Module (CEM) may not send a signal to the fuel Pump Electronic Module (PEM). This missing signal to the PEM inhibits the start of the fuel pump. The driver may be able to start the engine in spite of the fuel pump not being activated due to residual pressure in the fuel system. In some cases, the driver may be able to drive the vehicle a short distance at idle. However, the engine will eventually stall. Engine stalling would result in lost propulsion which, in conjunction with traffic and road conditions, and the driver's reactions, could increase the risk of a crash. Correction: Dealers will upgrade the CEM software.
ELECTRICAL SYSTEM:SOFTWARE
Summary
VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE FUEL PUMP. THE DRIVER MAY BE ABLE TO START THE ENGINE IN SPITE OF THE FUEL PUMP NOT BEING ACTIVATED DUE TO RESIDUAL PRESSURE IN THE FUEL SYSTEM. IN SOME CASES, THE DRIVER MAY BE ABLE TO DRIVE THE VEHICLE A SHORT DISTANCE AT IDLE BUT THEN THE ENGINE MAY STALL.
Potential Consequence
IF THE VEHICLE STALLS IN CERTAIN CONDITIONS, A CRASH COULD OCCUR.
Remedy
DEALERS WILL DOWNLOAD SOFTWARE TO THE VEHICLES' CEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2009. VEHICLES IN DEALER'S INVENTORY WILL BE REPAIRED PRIOR TO DELIVERY. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Summary
VOLVO IS RECALLING 17,614 MY 2008-2009 S80, V70, AND XC70 VEHICLES. THE ENGINE COOLING FAN MAY STOP WORKING DUE TO A SOFTWARE PROGRAMMING ERROR IN THE FAN CONTROL MODULE (FCM). DEPENDING ON DRIVING CONDITIONS, THE CUSTOMER MAY EXPERIENCE REDUCED AIR CONDITIONING PERFORMANCE, AND/OR RAPID INCREASE IN ENGINE COOLANT TEMPERATURE.
Potential Consequence
THIS SITUATION MAY RESULT IN LOSS OF COOLING SYSTEM FUNCTION AND ENGINE FAILURE. THE DRIVER MAY NOT HAVE SUFFICIENT TIME TO REACT TO THE WARNING LIGHT(S) OR THE TEXT MESSAGE IN THE INSTRUMENT PANEL, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE FAN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552.
Engine
Summary
On certain vehicles, the engine cooling fan may stop working due to a software programming error in the Fan Control Module (FCM). Depending on conditions, the driver may experience reduced air conditioning performance and/or rapid increase in engine coolant temperature. This could result in a loss of cooling system function and engine break down. The driver may not have sufficient time to react to the warning light(s) or the text message in the instrument panel, increasing the risk of a crash causing personal injury or death. Correction: Dealers will replace the Fan Control Module.
ELECTRICAL SYSTEM:SOFTWARE
Summary
VOLVO IS RECALLING 12,303 MY 2007-2008 S80 AND V70 VEHICLES. THE DIAGNOSTIC SOFTWARE IN THE CENTRAL ELECTRONIC MODULE (CEM) MAY CAUSE A MALFUNCTION OF THE WINDSHIELD WIPER FUNCTIONALITY. IF THIS CONDITION OCCURS, THE WINDSHIELD WIPERS MAY NOT OPERATE WHEN ACTIVATED; OR IN CERTAIN CASES THE WINDSHIELD WIPERS MAY ACTIVATE WHEN NOT SWITCHED ON.
Potential Consequence
OPERATING A MOTOR VEHICLE DURING INCLEMENT WEATHER CONDITIONS WITHOUT FUNCTIONING WINDSHIELD WIPERS CAN INCREASE THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT THE CEM AND UPGRADE THE SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON MAY 15, 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552, OR CUSTOMERCARE@VOLVOFORLIFE.COM.
Electrical
Summary
On certain vehicles, the diagnostic software in the Central Electronic Module (CEM) may cause a malfunction of the windshield wiper functionality. If this occurs, the windshield wipers may not operate when activated; or in certain cases the windshield wipers may activate when not switched on. Should this occur during a rainy/snowy day, it could increase the risk of a crash, causing property damage, personal injury or death. Correction: Dealers will install updated CEM software.
ENGINE AND ENGINE COOLING:ENGINE
Summary
VOLVO IS RECALLING 102 MY 2008 XC90 AND S80 VEHICLES EQUIPPED WITH V8 ENGINES. THESE VEHICLES MAY HAVE BEEN BUILT WITH INCORRECT BOLTS TO THE ENGINE MOUNT.
Potential Consequence
THE ALUMINUM BRACKET FOR THE ENGINE MOUNT COULD BREAK DUE TO LACK OF ADEQUATE CLAMPING FORCE. THIS COULD CAUSE THE ENGINE TO COME IN CONTACT WITH THE SUB-FRAME, ULTIMATELY RESULTING IN A REDUCED ENGINE TORQUE OR STALLING OF THE ENGINE WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT THE ENGINE MOUNT BOLTS FOR SPECIFIC MARKINGS. IF ANY OF THE BOLTS CONTAIN THE INCORRECT MARKINGS, THE BRACKET AND BOLTS WILL BE REPLACED. ALL OWNERS HAVE BEEN CONTACTED AND ARRANGEMENTS HAVE BEEN MADE TO REPAIR THESE VEHICLES.
Engine
Summary
Certain vehicles may have been inadvertently assembled with incorrect engine mount bolts. The longer bolts do not provide adequate clamping force to the bracket. In the worst case, the aluminium bracket for the engine mount will break, allowing the engine to contact the sub frame, ultimately resulting in reduced engine torque or stalling. Engine stalling would result in lost propulsion which, in conjunction with traffic and road conditions, and the driver's reactions, could increase the risk of a crash. Correction: Dealers will inspect the engine mount bolts for specific markings and, if required, replace the bracket and bolts.
Generated by Cardog • December 12, 2025
2008 Volvo S80
Safety Recalls & Notices
13 Active Recalls
Requires attention
