Newest first. Many cover only part of a model year, so check your VIN with Chevrolet before booking a repair.
Transport Canada · listed for this model year
Issue: On certain vehicles, an unused wiring harness for a rear HVAC blower motor, located in the left B-pillar area, could become damaged if exposed to moisture or contaminants. If this happens, the wires could short circuit. Note: This recall only affects cutaway chassis incomplete vehicles. Safety Risk: A short circuit can create the risk of a fire. Corrective Actions: General Motors will notify owners by mail and instruct you to bring your vehicle to a dealership to seal the wiring for the rear HVAC blower motor at the left B-pillar.
2023210 · 25,587 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Certain vehicles may not comply with the requirements of Canada Motor Vehicle Safety Standard 201 - Occupant Protection. During a frontal impact below the airbag deployment threshold, if an unbelted front passenger's head were to impact the instrument panel where the passenger airbag is located, it could decelerate at a rate higher than what is allowable by the standard. This could increase the risk of injury. Correction: Dealers will install energy absorbing trim pieces on the passenger side of the instrument panel, and on 2012-2014 model year 1500 series vehicles, dealers will also replace the front passenger seat belt retractor.
2014083 · 25,710 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Certain vehicles were built with heating, ventilation, and air conditioning (HVAC) control knobs that may fracture and spin on the control shaft. If this happens, the driver may no longer be able to control the heating, cooling, and ventilation for the vehicle. This may affect the defrost system, decreasing driver visibility, and creating the risk of a crash causing property damage, personal injury or death. Correction: Dealers will replace all HVAC control knobs.
2010072 · 1,414 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
United States records (NHTSA) · 7
These are NHTSA campaigns for 2009 Chevrolet Express vehicles sold in the United States. They are not Canadian recalls: NHTSA's VIN lookup has no Canadian data, and a US campaign may have no Canadian counterpart, or one under a different number covering different vehicles. For a vehicle sold in Canada, go by the Transport Canada listing above and Chevrolet's Canadian VIN lookup.
General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.
18V267000 · 6,154 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
General Motors LLC (GM) is recalling certain model year 2009-2014 Chevrolet Express and GMC Savana vans manufactured January 27, 2009, through March 7, 2014 with a gross vehicle weight rating of 10,000 pounds and less and equipped with front passenger air bags. In the affected vehicles, during a frontal impact below the air bag deployment threshold, if an unbelted front passenger's head hits the instrument panel above where the passenger air bag is located, the panel may not sufficiently absorb the impact. As such, these vehicles fail to meet the requirements of Federal Motor Vehicle Safety Standard number 201, "Occupant Protection in Interior Impact."
In the event of a crash below the air bag deployment threshold, an unbelted front passenger seat occupant has an increased risk of injury.
GM will notify owners, and dealers will modify the passenger instrument panel free of charge. Notices to the owners of the heavy duty vans were mailed on April 28, 2014. The recall began on May 19, 2014. Chevrolet owners may call 1-800-630-2438. GMC owners may call 1-866-996-9463. GM's number for this recall is 14082.
14V117000 · 303,013 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
MAIN MOBILITY IS RECALLING CERTAIN CONVERSION VANS BUILT ON MODEL YEAR 2008-2010 CHEVROLET EXPRESS, 2009 GMC SAVANA, AND 2010 FORD TRANSIT CONNECT CHASSIS, AND FITTED WITH CERTAIN BRAUN WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE WHEELCHAIR LIFTS OUTER BARRIER MAY BECOME BENT OR MISALIGNED.
A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIRS OCCUPANT COULD FALL AND SUSTAIN INJURY.
MAIN MOBILITY IS WORKING WITH BRAUN TO NOTIFY OWNERS, AND BRAUN DEALERS WILL REPAIR THE VEHICLES, FREE OF CHARGE. MAIN MOBILITY HAS NOT PROVIDED A NOTIFICATION SCHEDULE. OWNERS MAY CONTACT MAIN MOBILITY AT 1-716-759-6811.
12V169000 · 34 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
MAIN MOBILITY IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 CONVERSION VANS BUILT ON CHEVROLET EXPRESS AND GMC SAVANA CHASSIS FROM OCTOBER 2007 THROUGH MAY 2010 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.
WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.
MAIN MOBILITY WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
10V205000 · 133 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES FOR FAILING TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD WIPING AND WASHING SYSTEMS." THESE VEHICLES WERE BUILT WITH HEATING, VENTILATION, AND AIR CONDITIONING (HVAC) CONTROL KNOBS THAT MAY FRACTURE AND SPIN ON THE CONTROL SHAFT. THE DRIVER MAY NO LONGER BE ABLE TO CONTROL THE HEATING, COOLING, AND VENTILATION FOR THE VEHICLE.
IF THIS CONDITION AFFECTS THE DEFROST SYSTEM WHEN IT IS REQUIRED, IT MAY DECREASE THE DRIVER'S VISIBILITY, AND COULD POSSIBLY RESULT IN A CRASH.
DEALERS WILL REPLACE ALL HVAC CONTROL KNOBS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 11, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
10V096000 · 9,137 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
09V272000 · 185 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
09V270000 · 185 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
2009 Chevrolet Express recall questions
Transport Canada lists 3 recalls for the 2009 Chevrolet Express model year. That counts campaigns naming this model year, not recalls on your vehicle: many cover only a VIN range or production window, and some only vehicles found on inspection. NHTSA lists 7 United States campaigns for the US-market model, shown separately; a US campaign may have no Canadian equivalent.
Enter your VIN in Chevrolet's Canadian recall lookup, or call a Chevrolet dealer with your VIN. In Canada the manufacturer is responsible for showing recall and repair status for each VIN, so its lookup is the authoritative answer. Cardog uses your VIN only to find the model year; the recalls shown here are listed for that model year and are not matched to your VIN.
Not necessarily. NHTSA campaigns cover vehicles sold in the United States, and NHTSA's VIN lookup has no Canadian data. When a defect also affects Canadian vehicles, the manufacturer files a separate notice with Transport Canada, often under a different number and sometimes covering a different set of vehicles. For a Canadian vehicle, go by the Transport Canada listing and Chevrolet's Canadian lookup.
Safety recall repairs are normally done at no charge by an authorized Chevrolet dealer. The manufacturer's notice for each campaign sets out the remedy and any conditions, so confirm with the dealer when you book.
Once Chevrolet's lookup or a dealer confirms a recall applies, book the repair with an authorized Chevrolet dealer and bring your VIN. If the manufacturer's notice says not to drive the vehicle or to park it outside, follow that instruction. Parts can take time, so book early.
Follow the manufacturer's notice for that recall. Most allow normal driving until the repair; some tell owners to stop driving or to park outside until it is fixed. Cardog does not grade recalls by severity: the manufacturer's notice and your dealer are the source.
Manufacturers must notify owners they have on record. If you bought the vehicle used or have moved, update your details with Chevrolet Canada so notices reach you, and check the manufacturer's lookup from time to time.
Related recall checks
Compare recall listings with alternatives to the 2009 Chevrolet Express.