2008 Chevrolet Express
Safety Recalls & Notices
14 Active Recalls
Requires attention
Electrical
Summary
Issue: On certain vehicles, an unused wiring harness for a rear HVAC blower motor, located in the left B-pillar area, could become damaged if exposed to moisture or contaminants. If this happens, the wires could short circuit. Note: This recall only affects cutaway chassis incomplete vehicles. Safety Risk: A short circuit can create the risk of a fire. Corrective Actions: General Motors will notify owners by mail and instruct you to bring your vehicle to a dealership to seal the wiring for the rear HVAC blower motor at the left B-pillar.
EQUIPMENT ADAPTIVE/MOBILITY
Summary
MAIN MOBILITY IS RECALLING CERTAIN CONVERSION VANS BUILT ON MODEL YEAR 2008-2010 CHEVROLET EXPRESS, 2009 GMC SAVANA, AND 2010 FORD TRANSIT CONNECT CHASSIS, AND FITTED WITH CERTAIN BRAUN WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE WHEELCHAIR LIFTS OUTER BARRIER MAY BECOME BENT OR MISALIGNED.
Potential Consequence
A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIRS OCCUPANT COULD FALL AND SUSTAIN INJURY.
Remedy
MAIN MOBILITY IS WORKING WITH BRAUN TO NOTIFY OWNERS, AND BRAUN DEALERS WILL REPAIR THE VEHICLES, FREE OF CHARGE. MAIN MOBILITY HAS NOT PROVIDED A NOTIFICATION SCHEDULE. OWNERS MAY CONTACT MAIN MOBILITY AT 1-716-759-6811.
EQUIPMENT ADAPTIVE/MOBILITY
Summary
MAIN MOBILITY IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 CONVERSION VANS BUILT ON CHEVROLET EXPRESS AND GMC SAVANA CHASSIS FROM OCTOBER 2007 THROUGH MAY 2010 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.
Potential Consequence
WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.
Remedy
MAIN MOBILITY WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
EQUIPMENT:APPLIANCE:AIR CONDITIONER
Summary
CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.
Potential Consequence
THIS DEFECT COULD RESULT IN A FIRE.
Remedy
CUES IS WORKING WITH CARRIER TO REMEDY THE AFFECTED VEHICLES. REPAIRS WILL BE MADE BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL BEGAN ON JANUARY 5, 2010. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR CUES AT 1-407-849-0190.
EQUIPMENT ADAPTIVE/MOBILITY
Summary
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Potential Consequence
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
EQUIPMENT ADAPTIVE/MOBILITY
Summary
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Potential Consequence
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
EQUIPMENT ADAPTIVE/MOBILITY
Summary
CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Potential Consequence
A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Remedy
CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
EQUIPMENT ADAPTIVE/MOBILITY
Summary
CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATION IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Potential Consequence
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy
CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
Powertrain
Summary
Certain All-Wheel Drive (AWD) vehicles may have been assembled with an incorrectly manufactured transfer case that could cause early failure of drive chain. If the chain breaks, shifting the transmission to "Park" may not keep the vehicle stationary. If the vehicle is parked on an incline or bumped, it may roll and strike a person , an object or vehicle without warning and cause personal injury. Correction: Dealers will inspect the transfer case code and, if necessary, replace the transfer case.
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
Summary
GM IS RECALLING 151 MY 2008 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES EQUIPPED WITH ALL WHEEL DRIVE (AWD). SOME OF THESE VEHICLES HAVE TRANSFER CASES THAT WERE MANUFACTURED WITH AN INCORRECT PART THAT CAN CAUSE EARLY FAILURE OF A DRIVE CHAIN. IF THE CHAIN BREAKS, SHIFTING THE TRANSMISSION TO PARK MAY NOT KEEP THE VEHICLE STATIONARY.
Potential Consequence
IF THE VEHICLE IS PARKED ON AN INCLINE OR BUMPED, IT MAY ROLL AND STRIKE A PERSON, OBJECT, OR ANOTHER VEHICLE WITHOUT WARNING, AND CAUSE PERSONAL INJURY.
Remedy
DEALERS WILL INSPECT THE TRANSFER CASE DATE CODE AND, IF NECESSARY, REPLACE THE TRANSFER CASE. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Powertrain
Summary
On certain Cutaway vans, the transmission may self-engage into first gear while the vehicle is traveling at highway speeds, thereby causing transmission damage to certain gears. Should this occur at speeds beyond 130 km/h, the engine may shut down (and be able to be restarted with limited operating capability). However, in some cases, the transmission will no longer function in any gear. This could cause the vehicle to lose propulsion which, in conjunction with traffic and road conditions, and the driver's reactions, could increase the risk of a crash. Correction: Dealers will reprogram the Transmission Control Module (TCM) and the Engine Control Module (ECM).
FUEL SYSTEM, GASOLINE:STORAGE
Summary
GM IS RECALLING 567 MY 2008 CHEVROLET EXPRESS AND GMC SAVANA CUTAWAY VEHICLES WITH A 139" WHEEL BASE. THE FRAME RAIL ON THE DRIVER'S SIDE MAY BE WIDER THAN SPECIFICATION.
Potential Consequence
IF THE FRAME RAIL IS WIDER THAN SPECIFICATION, OVER TIME IT MAY CONTACT THE FUEL TANK HOUSING, RESULTING IN A POSSIBLE FUEL LEAK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy
DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE FRAME RAIL AND FUEL TANK HOUSING AND WILL REWORK THE FRAME RAIL IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JULY 30, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-966-9463, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
POWER TRAIN:AUTOMATIC TRANSMISSION
Summary
GM IS RECALLING 2,481 MY 2008 CHEVROLET EXPRESS AND GMC SAVANA G-CUTAWAY FLEET VAN EQUIPPED WITH A 6.0L (RPO LY6) V8 ENGINE, 4L80E (RPO MT1) TRANSMISSION, 4.10 (RPO GT5) AXLE AND 75 MPH GOVERNOR (RPO 9D7). THESE VEHICLES HAVE A CONDITION IN WHICH THE TRANSMISSION MAY BE DAMAGED DUE TO FIRST GEAR ENGAGEMENT AT HIGHWAY SPEEDS AND THEN DOES NOT TRANSMIT POWER WITH D4 OR R SELECTED. THIS MAY BE PRECEDED BY ENGINE SHUTDOWN IF THE VEHICLE EXCEEDS 81 MILES PER HOUR IN CERTAIN CONDITIONS.
Potential Consequence
THE VEHICLE MAY BE STRANDED ON OR NEAR A HIGHWAY, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPROGRAM THE TRANSMISSION AND ENGINE CONTROL MODULES FREE OF CHARGE. THE RECALL BEGAN ON OR ABOUT JULY 30, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Structure
Summary
On certain cutaway vehicle with a 139" wheelbase, the frame rail on the driver's side may be wider than specification. As such, it may contact the fuel tank housing and, over time, cause a fuel leak. Fuel leakage, in the presence of an ignition source, could result in a vehicle fire, causing property damage, personal injury, or death. Correction: Dealers will inspect the clearance between the frame rail and the fuel tank housing. If clearance is not sufficient, dealers will rework the frame rail.
Generated by Cardog • December 11, 2025
2008 Chevrolet Express
Safety Recalls & Notices
14 Active Recalls
Requires attention
