2005 Chevrolet Aveo
Safety Recalls & Notices
6 Active Recalls
Requires attention
Electrical
Summary
On certain vehicles, heat generated within the daytime running light (DRL) module could cause the module to melt, potentially resulting in a fire, which may result in injury and/or property damage. Correction: Dealers will inspect, and if necessary, replace the DRL module.
EXTERIOR LIGHTING:HEADLIGHTS
Summary
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Potential Consequence
If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy
GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
Lights And Instruments
Summary
On certain vehicles, the Daytime Running Lamp (DRL) module may fail, causing one or more of the following conditions: the DRLs may flicker but remain illuminated; the DRL indicator in the instrument panel may flash; the DRLs may remain illuminated after the vehicle is turned OFF; the DRLs may cease to function and the DRL indicator in the instrument panel will turn OFF. A loss of DRL illumination could render the vehicle less visible to other motorists and pedestrians during daylight hours, which could result in a crash causing property damage and/or personal injury. Correction: Dealers will replace the DRL module, if the above condition exists, for a period of up to 10 years or 240,000 km from first vehicle registration.
Engine
Summary
On certain vehicles, the engine throttle may stick in the open position due to throttle body icing in temperatures near or below -20 degrees Celsius. If the throttle sticks open while the vehicle is moving, a crash could occur without prior warning. The vehicle may experience this condition even if one or both of the previous two campaign services have been performed. See recall 2005235 (GM 05521) & 2006239 (GM 06515). Correction: Dealers will replace the PCV and throttle body systems.
Engine
Summary
On certain vehicles, the engine throttle may stick in the open position due to throttle body icing in temperatures near or below -20 degrees Celsius. If the throttle sticks open while the vehicle is moving, a crash could result without prior warning. Correction: Dealers will repair the PCV system update kit previously installed in recall 2005235 (GM 05521).
Other
Summary
Certain vehicles may experience throttle body icing in conditions where temperatures are near or below -20 degrees Celsius. Vehicle with this conditions could have the throttle stick open after a cold soak or they can experience a frozen throttle while driving. Correction: Dealers will install new parts that integrate with the coolant system to heat the PCV lines and avoid PCV freezing.
Generated by Cardog • December 11, 2025
2005 Chevrolet Aveo
Safety Recalls & Notices
6 Active Recalls
Requires attention
