Sourced from both NHTSA (US) and Transport Canada. 3 of these are critical and require prompt attention. All recall repairs are free at an authorized BMW dealer — bring your VIN to confirm which apply to your vehicle.
Issue: Under certain conditions, the windshield wiping system may not meet certain requirements of Canadian regulations. Safety Risk: This small error does not affect safety. Corrective Actions: This is not a recall. BMW has made changes to ensure that all new vehicles meet Canadian regulations.
2026285 · 25,552 units · Transport Canada
Free repair at an authorized dealer
Critical safety notice — contact your dealer immediately.
Issue: On certain vehicles, water could leak into the starter relay and cause it to corrode. If this happens, the relay could short circuit and the starter could overheat. Safety Risk: A short circuit and/or a starter that overheats can create a fire risk, even while the vehicle is parked and turned off. Corrective Actions: To reduce the safety risk, BMW advises that you should park your vehicle outdoors and away from other vehicles or structures until the recall repairs have been completed. BMW will notify owners by mail and advise you to take your vehicle to a dealership to replace the engine starter.
2025499 · 17,761 units · Transport Canada
Free repair at an authorized dealer
BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
A short circuit in the starter relay may increase the risk of a fire.
Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 14, 2025.
25V636000 · 199,674 units · NHTSA
Free repair at an authorized dealer
Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". Canadian regulations require the information to be listed on the label in both English and French. Safety Risk: This error does not affect vehicle safety. Corrective Actions: This is not a recall. The company has corrected the tire and loading information label for all new vehicles.
2024544 · 587,250 units · Transport Canada
Free repair at an authorized dealer
BMW of North America, LLC (BMW) is recalling certain 2020 M340i, M340i xDrive, 540i, 540i xDrive, X3 M40i, 2020-2021 X4 M40i, 745Le xDrive, 2019-2021 Z4 M40i, and 2020-2021 Toyota Supra vehicles. During engine start, the engine management software may cause loss of braking assist. Full mechanical braking (without assist) remains available.
Loss of braking assist can increase the risk of a crash.
Dealers will update the engine management software, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact BMW customer service at 1-800-525-7417.
21V598000 · 50,024 units · NHTSA
Free repair at an authorized dealer
Issue: On certain vehicles, the headlight adjustment plugs were not properly installed when the vehicle was assembled. As a result, the headlights may be adjusted horizontally. Canadian regulations do not allow for horizontal headlight adjustment unless the vehicle is equipped with a built-in aiming device. Safety Risk: Headlights that are not properly adjusted could cause reduced visibility or glare for oncoming drivers, and could increase the risk of a crash. Corrective Actions: BMW will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the headlights. If an incorrect adjustment plug is found, it will be replaced with the correct plug.
2020395 · 347 units · Transport Canada
Free repair at an authorized dealer
BMW of North America, LLC (BMW) is recalling certain 2019-2020 Z4 sDrive30i, Z4 M40i and 2020 Toyota Supra vehicles. The headlamps are able to be adjusted horizontally. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices and Associated Equipment."
Should the headlamps be adjusted horizontally, there could be increased glare and reduced visibility for oncoming drivers, or reduced visibility for the vehicle operator, thereby increasing the risk of a crash.
BMW will notify owners, and dealers will inspect the headlamp vertical and horizontal adjustment plugs, correcting them as necessary, free of charge. The recall began December 23, 2020. BMW owners may contact BMW customer service at 1-800-525-7417 or Toyota owners may contact Toyota customer service at 1-888-270-9371.
20V516000 · 4,265 units · NHTSA
Free repair at an authorized dealer
The steering track rods may be damaged when exposed to high temperatures and vibrational loads. If the steering track rods are damaged or break, the vehicle will have limited steering ability and may not steer as expected.
Limited steering ability increases the risk of an accident with injury or death of the vehicle occupants and other road users.
BMW Australia will contact all known owners. Consumers may contact an authorised BMW Service centre, or call the BMW Group Customer Interaction Centre on 1800 813 299 to arrange inspection and repair. Consumers can also contact BMW Australia via the BMW Australia website: https://www.bmw.com.au For further information, consumers can go to the BMW Australia website, and using either their vehicle's VIN or chassis number, check to see if their vehicle has an outstanding technical action, or an outstanding safety recall via https://www.bmw.com.au/en/topics/offers-and-services/recalls.html
REC-000128 · 1,269 units · NHTSA
Free repair at an authorized dealer
Critical safety notice — contact your dealer immediately.
Issue: On certain vehicles, high temperatures and excessive vibration could cause damage to the steering tie rods. If this happens, the tie rods could break. This could result in a loss of steering control. Safety Risk: A loss of steering control could create a risk of a crash. Corrective Actions: BMW will notify owners by mail and instruct you take your vehicle to a dealer to replace the steering tie rods.
2020267 · 1,018 units · Transport Canada
Free repair at an authorized dealer
BMW of North America, LLC (BMW) is recalling certain 2019 Z4 sDrive30i, 2019-2020 330i xDrive, M340i and M340i xDrive, 2020 X3M and X4M, and Toyota Supra vehicles. In certain driving conditions, such as high temperatures and rough road surfaces, a steering gear tie rod may become damaged, possibly resulting in a fractured tie rod.
A damaged or fractured tie rod may affect vehicle handling and control, increasing the risk of a crash.
BMW and Toyota will notify owners, and dealers will replace the steering gear tie rods, free of charge. The recall began August 14, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
20V355000 · 2,779 units · NHTSA
Free repair at an authorized dealer
BMW of North America, LLC (BMW) is recalling certain 2019-2020 330i, 330i xDrive, and 2019 Z4 vehicles. The needle roller bearings of the counterbalance shafts may have been improperly installed, potentially causing the counterbalance shaft to loosen.
If the counterbalance shaft loosens, severe engine damage could occur, increasing the risk of a crash.
BMW will notify owners, and dealers will replace the engine, free of charge. The recall began December 13, 2019. Owners may contact BMW customer service at 1-800-525-7417.
19V732000 · 217 units · NHTSA
Free repair at an authorized dealer
Issue: On certain vehicles, the rearview camera does not return to the default settings when it turns on. This could make the rearview image difficult to see if a driver had previously adjusted the camera display brightness at or near the lowest setting, and contrast at or near the highest setting. Canadian regulations require that the rearview display returns to the default view each time the camera is turned on. Safety Risk: Reduced rear visibility could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct them to take their vehicle to a dealer to update the software for the rearview camera. Drivers are recommended not to adjust the display brightness at or near the lowest setting, and contrast at or near the highest setting, until this recall is completed.
2019480 · 14,323 units · Transport Canada
Free repair at an authorized dealer
BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
The lack of an image in the back-up camera display increases the risk of a crash.
BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.
19V684000 · 257,473 units · NHTSA
Free repair at an authorized dealer
Critical safety notice — contact your dealer immediately.
Issue: On certain vehicles, the accelerator pedal may interfere with a wiring harness. This could cause the accelerator pedal to get stuck. Safety Risk: A stuck accelerator pedal would lead to unintended acceleration of the vehicle, increasing the risk of a crash. Corrective Actions: Dealers will inspect the accelerator pedal module wiring harness. The wiring harness will be moved and secured if necessary. All vehicles will be repaired prior to sale.
2019069 · 9 units · Transport Canada
Free repair at an authorized dealer
2019 BMW Z4 recall questions
The 2019 BMW Z4 has 14 known safety recalls. 3 are classified as critical and may require immediate attention. We recommend checking with your dealer using your specific VIN for the most accurate information.
Yes, all manufacturer safety recalls for the BMW Z4 are repaired completely free of charge at any authorized BMW dealership. This includes parts, labor, and any related expenses regardless of your vehicle's current mileage or whether you're the original owner.
The best way to check is to enter your 17-character Vehicle Identification Number (VIN) in our search tool above. You can also contact any authorized BMW dealer directly with your VIN. Some recalls only affect vehicles manufactured during specific date ranges or with certain equipment configurations.
Contact your nearest authorized BMW dealership to schedule a repair appointment. For critical recalls marked "Do Not Drive," park your vehicle safely and arrange for service immediately. Bring your recall notice or VIN to the appointment. Parts availability may vary, so schedule early.
It depends on the specific recall. Your vehicle has 3 critical recalls that may advise against driving until repaired. Always read the recall details carefully. For critical safety issues, park the vehicle and contact your dealer immediately.
Safety recalls for the 2019 BMW Z4 remain open indefinitely - there is no expiration date. Even if your vehicle is many years old or has high mileage, authorized BMW dealers must perform the recall repair free of charge whenever you bring it in.
Recall repairs must be performed at an authorized BMW dealership. Any BMW dealer in the US or Canada can perform the repair, regardless of where you purchased the vehicle. Contact your preferred dealer to schedule an appointment.
Manufacturers are required to notify registered owners by mail when new recalls are issued. However, if you've moved or bought the vehicle used, you may not receive notices. We recommend checking periodically using your VIN and registering with NHTSA for recall alerts.
Related recall checks
Compare recall history with competitors and alternatives to the 2019 BMW Z4.