2003 Bmw Z4
Safety Recalls & Notices
5 Active Recalls
Requires attention
AIR BAGS
Summary
ON CERTAIN PASSENGER VEHICLES, INCOMPATIBLE ELECTRONIC AIR BAG SYSTEM PROCESSORS MAY HAVE BEEN INSTALLED.
Potential Consequence
IN THE EVENT OF A CRASH, AIR BAG DEPLOYMENT MAY NOT OCCUR, INCREASING THE RISK OF INJURIES TO THE DRIVER AND/OR FRONT PASSENGER.
Remedy
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE AIR BAG SYSTEM PROCESSORS. THE RECALL BEGAN JUNE 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary
ON CERTAIN PASSENGER VEHICLES, UNDER CERTAIN ENVIRONMENTAL CONDITIONS, A VAPOR LOCK IN THE FUEL PUMP COULD OCCUR CAUSING THE ENGINE TO STALL. IF THIS WERE TO HAPPEN, THE ENGINE WOULD NOT BE ABLE TO BE RESTARTED FOR APPROXIMATELY 15 TO 20 MINUTES.
Potential Consequence
IF STALLING WERE TO OCCUR, THE DRIVER WOULD BE UNABLE TO MAINTAIN VEHICLE SPEED OR ACCELERATE, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSTALL A RESISTOR IN THE ELECTRICAL LINE POWERING THE FUEL PUMP IN ORDER TO PREVENT AN OCCURRENCE OF VAPOR LOCK. THE RECALL BEGAN MAY 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Fuel System
Summary
Certain vehicles contain a defect involving the electric fuel pump. Under certain environmental conditions, for example, driving during high outside temperatures in combination with high altitudes (over 5,000ft.), vapor lock in the fuel pump could occur. This could cause the engine to stall. If this were to happen, the engine could be unable to be restarted for approximately 15 to 20 minutes. Correction: Dealer will install a resistor in the electrical line leading to the fuel pump. This will reduce the power output of the fuel pump and preclude an occurrence of vapor lock.
TIRES
Summary
ON CERTAIN VEHICLES EQUIPPED WITH 18" TIRES, IT IS POSSIBLE THAT THE TIRE HAS BEEN DAMAGED DURING THE MOUNTING PROCESS TO THE RIM.
Potential Consequence
CONSEQUENTLY, A LOSS OF TIRE PRESSURE, OR A TIRE FAILURE, COULD OCCUR. DEPENDING ON TRAFFIC CONDITIONS AND THE DRIVER'S REACTIONS, THIS COULD LEAD TO A CRASH.
Remedy
DEALERS WILL UNSEAT THE TIRE FROM ITS RIM, INSPECT FOR ANY DAMAGE, AND THEN RESEAT THE TIRE TO ITS RIM. IF INSPECTION REVEALS THAT A FRONT TIRE HAS INCURRED DAMAGE DURING THE MOUNTING PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 14, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Summary
ON CERTAIN PASSENGER VEHICLES, THE CONNECTION OF THE SAFETY BELT BUCKLE TO THE STEEL ROPE OF THE TENSIONER DOES NOT MEET BMW SPECIFICATIONS. IN SEVERE FRONTAL CRASHES, THIS CONNECTION CAN DETACH.
Potential Consequence
IF THE CONNECTION DETACHES, THE PROTECTION PROVIDED BY THE SAFETY BELT IS LIKELY TO BE IMPAIRED, AND SERIOUS INJURIES TO THE DRIVER AND/OR FRONT PASSENGER COULD OCCUR THAT MIGHT OTHERWISE BE MITIGATED.
Remedy
DEALERS WILL INSPECT BOTH FRONT SAFETY BELT TENSIONER AND BUCKLE ASSEMBLIES, AND IF NECESSARY, REPLACE THESE PARTS. OWNER NOTIFICATION BEGAN MARCH 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Generated by Cardog • December 13, 2025
2003 Bmw Z4
Safety Recalls & Notices
5 Active Recalls
Requires attention
