1997 Bmw 5 Series
Safety Recalls & Notices
4 Active Recalls
Requires attention
STEERING:LINKAGES:ROD:RELAY:CONNECTING
Summary
ZF Group North America Operations (ZF) is recalling certain Lemförder Steering Center Rods sold as aftermarket parts for 1996-2004 BMW 5-Series (E39) vehicles. The steering center rods may have an insufficient ball pin pull force that may allow the rods to detach from the steering knuckle.
Potential Consequence
If the steering rod detaches from the steerable wheel knuckle, it can cause sudden loss of steering control, increasing the risk of a crash.
Remedy
ZF has notified the parts distributors, instructing them to inform the end customer. ZF will reimburse them for the affected parts. The recall began August 28, 2019.
EXTERIOR LIGHTING:HEADLIGHTS
Summary
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Potential Consequence
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
SUSPENSION:FRONT
Summary
ON CERTAIN PASSENGER VEHICLES, DUE TO LONG EXPOSURES TO CERTAIN ENVIRONMENTAL AND OPERATING CONDITIONS, THE MATERIAL STRUCTURE OF THE FRONT SPRING STRUT PLATE COULD BE AFFECTED. IN SOME CASES, THE STRUT PLATE COULD BEGIN TO CRACK, AND EVENTUALLY IT COULD BREAK. IF THIS OCCURRED, THE PLATE COULD CONTACT THE TIRE.
Potential Consequence
THIS COULD LEAD TO A SUDDEN LOSS OF TIRE PRESSURE OR TIRE FAILURE.
Remedy
DEALERS WILL INSTALL A RETAINING CLIP TO THE UNDERSIDE OF THE FRONT SPRING STRUT PLATES. THE RECALL BEGAN MAY 17, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Suspension
Summary
On certain vehicles, the front spring strut plate could develop cracks. Over time, the crack may propagate. In extreme cases, the strut plate could break and contact the tire. This could lead to a sudden loss of tire pressure or tire failure. Correction: Dealer will install a retaining clip to the underside of the front spring strut plates.
Generated by Cardog • December 16, 2025
1997 Bmw 5 Series
Safety Recalls & Notices
4 Active Recalls
Requires attention
