Certain vehicles with a cracked (but not leaking) fuel pump flange were repaired with butyl tape only under a previous recall (please see Transport Canada Recall 2016-443 / Audi campaign 20W9). This is because replacement fuel pump flanges were not available at the time of repair (the butyl tape was used an interim repair). If the fuel pump flange is not replaced, a fuel leak could still occur. A fuel leak, in the presence of an ignition source, could lead to a fire causing injury and/or damage to property. Correction: Dealers will replace fuel pump flange and reapply the protective butyl tape.

2018635 · 113 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, could eventually degrade the propellant contained in the driver frontal airbag. This could cause the airbag to deploy with more force than normal. As a result, if the vehicle were involved in a collision that warrants airbag deployment, fragments could be propelled toward vehicle occupants, and the airbag assembly could be damaged, preventing proper function. These issues could increase the risk of injury. Correction: Dealers will replace the driver frontal airbag inflator. Note: Canadian climate results in the propellant degrading slowly. The recall is being conducted as a precaution to address future risk, and is expected to replace airbag inflators before their function would be affected. Additional Note: For the Audi A4, S4, A5 and S5 models, this campaign only affects the Cabriolet versions of these models. Also to Note: This recall supersedes the Audi brand vehicles subject to recall 2016-064 (Audi Recall 69N1) and 2016-065 (69N2). Audi brand vehicles completed under the previous 2016-064 and 2016-065 recalls require repair under this recall, as the previous recall remedy was an interim repair. Interim repair parts must be replaced with final repair parts.

2018059 · 26,340 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles, if the water drainage system of the panoramic sunroof becomes damaged or impaired (such as during a repair), water could enter the side head curtain airbag canister. Due to a foam that is touching the airbag inflator, moisture could cause corrosion on the airbag inflator over time. If this happens, the airbag canister could be weakened. This could cause the airbag canister to fracture without airbag deployment and allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. Correction: Dealers will inspect the vehicle for evidence of water ingress, examine the drainage system, disassemble the headliner and trim, remove foam and inspect the side head curtain airbag canister for relevant corrosion. In cases where light surface corrosion is found, a wax will be applied to the inflator. In cases of more than light surface corrosion, the inflator will be replaced after a robustness check.

2017003 · 36,349 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles, the fuel pump flange may develop fine cracks or fissures, which could result in a fuel leak. Leaking fuel, in the presence of an ignition source, could lead to a fire causing injury and/or damage to property. Correction: Dealers will apply a butyl protective film to the fuel pump flange. If cracks are present, the fuel pump flange will be replaced.

2016443 · 20,109 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles, the driver frontal airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Correction: Dealers will replace the front driver airbag inflator. Note: This campaign only affects the Audi A5 and Audi S5 Cabriolet models.

2016064 · 64,660 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer