Issue: This recall is for certain block heater kits installed on certain vehicles or sold as accessories at Toyota or Lexus dealerships. On certain vehicles, the engine block heater cable may not have enough heat protection and could be damaged by high temperatures. If this happens, the cable could short circuit while plugged in, and cause the wiring to overheat or melt. Note: This recall only affects the following block heater/cord part numbers: C014003034 PK5A408J09 PU14000904 C014003151 PK5A408J13 PU14000905 C014000885 PK5A489J11 PU14000907 C014000888 PK5A489J22 PU14000909 C014000907 PK5A410H00 PU14000911 C014100904 PU14000900 PU14000913 C014100907 PU14000901 PU14003571 C014100911 PU14000902 PK5A489J14 PK5A408J05 PU14000903 Safety Risk: Engine block heater wiring that overheats or melts could create the risk of a fire. Corrective Actions: Toyota recommends that you should stop using the engine block heater immediately. Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to disable the engine block heater. For some vehicles, the corrective actions for this recall are under development. For others, a new engine block heater cannot be installed, and the owner will receive a refund of the purchase price of the engine block heater.

2021723 · 55,683 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

Issue: On certain vehicles, the rear reflex reflectors may not have been manufactured correctly. As a result, the rear reflectors may reflect less light than what is required by Canadian regulations. Safety Risk: This small error does not affect vehicle safety. Corrective Actions: This is not a recall. The company has made changes to ensure that all new vehicles have fully compliant rear reflex reflectors.

2020577 · 18,206 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles, the electrical power cords of some dealer installed block heaters may have been improperly manufactured, causing the wires to contact each other, resulting in a short circuit. A short circuit could lead to a fire which would increase the risk of injury and/or damage to property. Correction: For vehicles where the subject block heater was approved for installation, the dealer will replace the block heater assembly with a new one of an improved design. For vehicles where the subject block heater was not approved for installation, dealers will remove the block heater assembly. In the interim, until the remedy can be performed, dealers will cut the plug end from the block heater cord to disable the block heater's operation.

2017363 · 39,189 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer

On certain vehicles, a lock nut that secures the right-hand side tie rod assembly to the steering gear assembly may not have been tightened properly during the assembly process. Over time, this could cause the lock nut to loosen which could cause the vehicle to drift left and right and eventually cause the tie rod to separate for the steering gear assembly, resulting in a loss of steering control. This situation could increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will inspect the right hand side tie rod lock nut. If the nut is found to be loose, Dealer will replace the lock nut, steering gear assembly and the tie rod assembly.

2017324 · 19 units in campaign · Transport Canada

Applies only if the manufacturer confirms your VIN · repair by an authorized dealer