Newest first. Many cover only part of a model year, so check your VIN with NHTSA or Volvo before booking a repair.
NHTSA · listed for this model year
ON CERTAIN HEAVY-DUTY CLASS 8 VEHICLES, THE BODY BUILDER WIRING OPTION WAS MIS-WIRED IN SUCH A WAY THAT THE AUTO NEUTRAL WITH SERVICE BRAKE STATUS OPTION MAY ALLOW THE TRANSMISSION TO GO INTO FORWARD GEAR WITHOUT THE DRIVER'S FOOT PRESSING DOWN ON THE BRAKE PEDAL FIRST.
UNINTENDED MOVEMENT OF THE VEHICLE COULD PUT PERSONS IN DANGER INSIDE AND OUTSIDE THE VEHICLE.
VOLVO TRUCKS WILL NOTIFY ITS CUSTOMERS AND INSTALL AN ADDITIONAL AIR OPERATED STOP LIGHT SWITCH AND THE NECESSARY WIRING CHANGES. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AT 1-800-528-6586.
03V308000 · 3,426 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS WESTPORT B GAS PLUS OR C GAS PLUS 6 CYLINDER ENGINES, THE ELECTRONIC CONTROL MODULE CALIBRATION MAY NOT CORRECTLY DETECT A THROTTLE PLATE ACTUATOR FAILURE THAT COULD RESULT IN AN UNCOMMANDED OPEN THROTTLE CONDITION.
IF THIS EVENT OCCURS, THE VEHICLE OPERATOR WILL NOT HAVE CONTROL OF THE ENGINE SPEED WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ELECTRONIC CONTROL MODULE CALIBRATION FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CUMMINS CUSTOMER ASSISTANCE CENTER AT 1-800-343-7357 OR VOLVO TRUCK AT 1-800-528-6586.
03V183000 · 120 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS, THE FORWARD AND/OR REAR DRIVE AXLE UPPER AXLE SEAT CAN BREAK ALLOWING THE AXLE TO SHIFT OUT OF ALIGNMENT.
THIS COULD RESULT IN A LOSS OF AXLE STABILITY INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE UPPER AXLE SEAT FOR A CERTAIN DATE CODE THAT IS STAMPED ON THE PART, AND THOSE AXLES WILL BE REPLACED. OWNER NOTIFICATION BEGAN MARCH 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
02V036000 · 215 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Canadian records (Transport Canada) · 3
These are Transport Canada campaigns for 2001 Volvo Wxll vehicles sold in Canada. A Canadian campaign may have no US counterpart, or one under a different number covering different vehicles. For a vehicle sold in the United States, go by the NHTSA listing above and NHTSA's VIN lookup.
On certain vehicles, the body builder wiring option was mis-wired in such a way that the Auto Neutral with Service Brake Status option may allow the transmission to go into forward gear without the drivers foot pressing down on the brake pedal first. Correction: Dealer will install an additional air operated stop light switch and perform the necessary wiring changes.
2003222 · 221 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain heavy duty class 8 trucks the forward and/or rear drive axle upper axle seat can break allowing the axle to shift out of alignment. This could result in a loss of axle stability increasing the risk of a crash. Correction: Dealers will replace the upper axle seats.
2002062 · 16 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Certain heavy duty class 8 vehicles equipped with electronic throttle control/accelerator pedals supplied by Williams's controls industries. The weld attaching the clevis to the plate has insufficient penetration and could allow the clevis to separate from the plate. If the clevis separated from the plate while the vehicle was in use, the vehicle would return to idle, increasing the risk of a crash. Correction: Dealers will replace these pedals.
2002020 · 9 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
2001 Volvo Wxll recall questions
NHTSA lists 3 recalls for the 2001 Volvo Wxll model year. That counts campaigns naming this model year, not recalls on your vehicle: many cover only a VIN range or production window. Transport Canada lists 3 Canadian campaigns for the Canadian-market model, shown separately.
Enter your VIN in NHTSA's recall lookup or Volvo's own, or call a Volvo dealer with your VIN. Cardog uses your VIN only to find the model year; the recalls shown here are listed for that model year and are not matched to your VIN.
Not necessarily. Transport Canada campaigns cover vehicles sold in Canada. For a vehicle sold in the United States, go by the NHTSA listing and NHTSA's VIN lookup.
Safety recall repairs are normally done at no charge by an authorized Volvo dealer. The manufacturer's notice for each campaign sets out the remedy and any conditions, so confirm with the dealer when you book.
Once Volvo's lookup or a dealer confirms a recall applies, book the repair with an authorized Volvo dealer and bring your VIN. If the manufacturer's notice says not to drive the vehicle or to park it outside, follow that instruction. Parts can take time, so book early.
Follow the manufacturer's notice for that recall. Most allow normal driving until the repair; some tell owners to stop driving or to park outside until it is fixed. Cardog does not grade recalls by severity: the manufacturer's notice and your dealer are the source.
Manufacturers must notify owners they have on record. If you bought the vehicle used or have moved, update your details with Volvo so notices reach you, and check NHTSA's lookup from time to time.
Related recall checks
Compare recall listings with alternatives to the 2001 Volvo Wxll.