Newest first. Many cover only part of a model year, so check your VIN with NHTSA or Dodge before booking a repair.
NHTSA · listed for this model year
DUE TO IMPROPER MATERIAL CONSTRUCTION THE HYDRO-BOOST FLUID RETURN HOSE MAY NOT BE CAPABLE OF WITHSTANDING THE TEMPERATURES AND/OR PRESSURES EXPERIENCED WITH THE HYDRO-BOOST SYSTEM. ALSO, THE HYDRO-BOOST FLUID HIGH PRESSURE HOSE ASSEMBLY MAY HAVE BEEN MISLOCATED, ALLOWING THE ASSEMBLY TO CONTACT THE FRAME SIDE RAIL. ABRASION RESULTING FROM CONTINUED CONTACT ALONG WITH IMPROPER MATERIAL CONSTRUCTION MAY CAUSE PRESSURE HOSE FAILURE. EITHER OF THESE CONDITIONS MAY CAUSE HYDRO-BOOST FLUID LEAKAGE, RESULTING IN THE LOSS OF POWER ASSIST FOR THE STEERING AND BRAKING SYSTEMS. COMPLETE LOSS OF STEERING OR BRAKING WILL NOT OCCUR SINCE BOTH SYSTEMS WOULD REVERT TO MANUAL OPERATION.
THE DEALER WILL INSTALL A HYDRO-BOOST FLUID RETURN HOSE CONSTRUCTED FORM THE PROPER MATERIAL, POSITIONING THE HOSE ASSEMBLY TO ENSURE ADEQUATE CLEARANCE BETWEEN IT AND THE FRAME SIDE RAIL.
78V188000 · 1,400 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
IMPROPER ROUTING OF THE "HYDROBOOST" HYDRAULIC SYSTEM HIGH PRESSURE HOSE ASSEMBLY COULD ALLOW A TUBULAR SECTION TO CONTACT THE FRAME SIDE RAIL. ABRASION FROM THE CONTACT COULD RESULT, CAUSING A LEAK IN THE HOSE ASSEMBLY.
THE DEALER WILL REROUTE "HYDROBOOST" HIGH PRESSURE HOSE ASSEMBLIES AND ANY DAMAGED HOSES WILL BE REPLACED.
78V141000 · 1,400 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
AN INTERMEDIATE STEERING SHAFT CONTAINING A MISMATCHED POT COUPLING ASSEMBLY MAY HAVE BEEN INSTALLED ON THE INVOLVED VEHICLES. THIS COUPLING MAY HAVE AN OVERSIZED SERRATION DIAMETER. AN OVERSIZED SERRATION COULD PREVENT THE COUPLING FROM ADEQUATELY TIGHTENING ONTO THE GEAR OR SHAFT SPLINES.
THE DEALER WILL INSPECT AND, IF NECESSARY, INSTALL A REPLACEMENT SHAFT COUPLING.
78V038000 · 9,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DEALER WILL INSPECT THE FUEL TANK VENT SYSTEMS FOR BLOCKAGE AND CORRECT, IF NECESSARY. FUEL TANKS WILL BE INSPECTED FOR CRACKING OF THE FRONT PANEL AND REPLACED, IF NECESSARY.
78V036000 · 20,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
THE FUEL TUBES (FUEL TANK TO PUMP) ON THE INVOLVED VEHICLES MAY BE ROUTED SUCH THAT TUBE TO UNDERBODY REINFORCEMENT FLANGE INTERFERENCE MAY RESULT DURING VEHICLE OPERATION. TUBE ABRASION CAUSED BY SUCH INTERFERENCE MAY RESULT IN FUEL LEAKAGE.
DEALER WILL REROUTE THE FUEL TUBE OR INSTALL A NEW FUEL TUBE, IF DAMAGED, WITHOUT CHARGE TO OWNER.
77V212000 · 24,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Canadian records (Transport Canada) · 5
These are Transport Canada campaigns for 1978 Dodge D100 vehicles sold in Canada. A Canadian campaign may have no US counterpart, or one under a different number covering different vehicles. For a vehicle sold in the United States, go by the NHTSA listing above and NHTSA's VIN lookup.
On certain vehicles, the "hydroboost" hydraulic system high pressure hose assembly may be improperly routed and can contact the frame side rail resulting in a leak in the hose assembly. This could result in a loss of power assist to the steering and braking systems.
1978042 · 224 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Certain vehicles were built without the choke heater electrical harness installed. Without the harness, the choke heater circuit will be inoperative allowing the vehicles to exceed the hydrocarbon and carbon monoxide emission levels specified in CMVSS 1103.
1977194 · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Certain vehicles equipped with dual fuel tanks, may have been built with an incorrect secondary evaporative control system cannister that would allow the vehicle to seceed CMVSS 105 - evaporative emissions.
1977176 · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, the in-cab fuel tank vent could become blocked leading to excessive internal pressure and cracking of the tank. The cracked fuel tank could allow gasoline and gasoline vapour into the cab creating a fire hazard.
1977169 · 3,416 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, the tilt-type steering column may have been misassembled by the supplier such that the master serrations for steering wheel indexing are mislocated by 180 degrees. A plant rework involving tie rod adjustment may have resulted in insufficient tie rod end thread engagement to ensure structural adequacy.
1977080 · 74 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
1978 Dodge D100 recall questions
NHTSA lists 5 recalls for the 1978 Dodge D100 model year. That counts campaigns naming this model year, not recalls on your vehicle: many cover only a VIN range or production window. Transport Canada lists 5 Canadian campaigns for the Canadian-market model, shown separately.
Enter your VIN in NHTSA's recall lookup or Dodge's own, or call a Dodge dealer with your VIN. Cardog uses your VIN only to find the model year; the recalls shown here are listed for that model year and are not matched to your VIN.
Not necessarily. Transport Canada campaigns cover vehicles sold in Canada. For a vehicle sold in the United States, go by the NHTSA listing and NHTSA's VIN lookup.
Safety recall repairs are normally done at no charge by an authorized Dodge dealer. The manufacturer's notice for each campaign sets out the remedy and any conditions, so confirm with the dealer when you book.
Once Dodge's lookup or a dealer confirms a recall applies, book the repair with an authorized Dodge dealer and bring your VIN. If the manufacturer's notice says not to drive the vehicle or to park it outside, follow that instruction. Parts can take time, so book early.
Follow the manufacturer's notice for that recall. Most allow normal driving until the repair; some tell owners to stop driving or to park outside until it is fixed. Cardog does not grade recalls by severity: the manufacturer's notice and your dealer are the source.
Manufacturers must notify owners they have on record. If you bought the vehicle used or have moved, update your details with Dodge so notices reach you, and check NHTSA's lookup from time to time.
Related recall checks
Recall listings for the latest model year vehicles.