2005 Volkswagen Touareg
Safety Recalls & Notices
We found 4 safety recalls for the 2005 Volkswagen Touareg. Recalls are sourced from both NHTSA (US) and Transport Canada databases. Contact your authorized Volkswagen dealer to schedule free repairs.
Summary
On certain vehicles, the fuel pump flange may develop fine cracks or fissures, which could result in a fuel leak. Leaking fuel, in the presence of an ignition source, could lead to a fire causing injury and/or damage to property. Correction: Dealers will inspect for cracks and replace the fuel filter flange if cracks are found. If no cracks are detected, a protective cover will be applied to the filter flange to prevent oxidization and future formation of cracks.
Summary
Certain vehicles do not comply with the requirements of CMVSS 120. The tire pressure label, located on the driver's side B-pillar, does not indicate the vehicle GVWR and GAWR or the recommended wheel rim size. The tire size, rim size and inflation pressure information was also not given on the compliance certification label. However, the combination of the tire information label and the certification label adjacent to each other on the driver side B-pillar provides the GAWR, GVWR, tire size and inflation pressure information. Correction: Since this does not pose any safety risk, no corrective action is required.
Summary
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2004-2007 Touareg vehicles. These gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak.
Potential Consequence
A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy
Volkswagen will notify owners, and dealers will inspect the fuel filter flange for cracks, replacing the flange if cracks are found. If no cracks are found, a protective cover will be installed onto the filter flange. These repairs will be performed free of charge. The recall began March 9, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20Ai.
Summary
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.
Potential Consequence
WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED, INCREASING THE RISK OF INJURIES OR DEATH.
Remedy
DEALERS WILL PERMANENTLY INSTALL A 'CLIP' IN EACH OF THE TWO REAR OUTBOARD SEAT BELTS. THE CLIPS WILL PREVENT UNWANTED DEACTIVATION OF THE ALR MODE WITH CHILD SEAT INSTALLATIONS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS SHOULD CONTACT VW AT 1-800-822-8987.
4 Active Recalls
Requires attention
2005 Volkswagen Touareg Recall FAQs
Common questions about recalls for this vehicle
Related Recall Checks
Compare recall history with competitors and alternatives to the 2005 Volkswagen Touareg.