1994 Mercury Sable
Safety Recalls & Notices
We found 10 safety recalls for the 1994 Mercury Sable. Recalls are sourced from both NHTSA (US) and Transport Canada databases. Contact your authorized Mercury dealer to schedule free repairs.
Summary
On certain vehicles located in Manitoba, Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador, the lower sub frame mount plate nut may corrode and fail due to exposure to road salt. This could result in loss of structural integrity of the subframe mount attachment. Detachment of the body mounts at the rear corners of the sub frame which supports the engine and transmission, allows the rear corners of the sub frame to drop. Should both rear corners drop, steering control would be adversely affected. Correction: Dealers will install subframe rear mount bolts, reinforcement plate and plate nuts.
Summary
THE HEADLIGHTS MAY FLASH INTERMITTENTLY AS A RESULT OF THE HEADLIGHT SWITCH CIRCUIT BREAKER OPENING DUE TO OVERHEATING. EXTENDED CYCLING OF THE CIRCUIT BREAKER COULD RESULT IN LONGER AND MORE FREQUENT LIGHT OUTAGES. LOSS OF HEADLIGHTS DURING VEHICLE OPERATION COULD POTENTIALLY AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY. CORRECTION: DEALERS WILL INSTALL A HEADLIGHT SWITCH INCORPORATING A REVISED DESIGN CIRCUIT BREAKER AND, IF REQUIRED, A WIRING HARNESS CONNECTOR AND WIRING WILL BE INSTALLED.
Summary
VEHICLES WITH 3.8 LITRE ENGINES THAT WERE INVOLVED IN SAFETY RECALL 95S22 (95-202) WERE MODIFIED WITH A MAXI-FUSE THAT DOES NOT PROVIDE THE INTENDED LEVEL OF PROTECTION FOR THE ENGINE COOLING FAN ELECTRICAL SYSTEM. ALSO, BECAUSE A SIMILAR MAXI-FUSE CIRCUIT WAS USED ON CERTAIN 1994-95 TAURUS/SABLE VEHICLES WITH 3.8 LITRE ENGINES, THESE VEHICLES WILL BE INCLUDED IN THIS RECALL. CORRECTION: A FUSED WIRING HARNESS THAT PROVIDES THE REQUIRED LEVEL OF PROTECTION WILL BE INSTALLED ON AFFECTED VEHICLES.
Summary
DIRECT WATER SPRAY OR LONG TERM WET DRIVING CONDITIONS MAY CAUSE WATER TO ACCUMULATE IN THE SPEED CONTROL CABLE CONDUIT. UNDER COLD CONDITIONS THIS WATER COULD FREEZE AND PREVENT THE THROTTLE FROM RETURNING TO THE CLOSED POSITION WHEN THE SPEED CONTROL IS DISENGAGED. THIS COULD ADVERSELY AFFECT DRIVER CONTROL AND CREATE THE POTENTIAL FOR A VEHICLE CRASH. CORRECTION: MOISTURE WILL BE REMOVED FROM THE CABLE CONDUIT AND A BOOT WILL BE ADDED TO THE SPEED CONTROL CABLE TO PREVENT WATER ENTRY.
Summary
NOTE: 1992-94 TEMPO/TOPAZ WITH 3.0 LITRE ENGINES; 1994-95 TAURUS/SABLE (EXCEPT SHO) WITH 3.0 LITRE ENGINES; 1992-93 TAURUS/SABLE WITH 3.8 LITRE ENGINES; 1992-94 LINCOLN CONTINENTAL. THE ENGINE COOLING FAN MAY BECOME FROZEN IN PLACE BY SNOW, ICE OR SLUSH. IF THIS OCCURS AND THE COOLING FAN IS ACTIVATED, EITHER AUTOMATICALLY TO REDUCE COOLANT TEMPERATURE OR WHEN THE DEFROSTER IS TURNED ON, THE COOLING FAN WILL NOT ROTATE AND CAN OVERHEAT. THIS CAN DAMAGE THE FAN MOTOR, FAN, FAN WIRING AND SHROUD WITH THE POTENTIAL FOR SMOKE OR A FIRE TO RESULT. CORRECTION: IN SOME CASES, THE FUSE FOR THE COOLING FAN CIRCUIT WILL BE REPLACED WITH A SMALLER FUSE. IN OTHER CASES, A JUMPER HARNESS WITH DEDICATED CIRCUIT PROTECTION FOR THE COOLING FAN WILL BE INSTALLED.
Summary
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Potential Consequence
IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Summary
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Potential Consequence
LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
Summary
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Potential Consequence
DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy
DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Summary
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Potential Consequence
THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy
DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
Summary
THE ARC WELDS ON THE SWAY BAR BRACKET, WHERE IT ATTACHES TO THE STRUT RESERVE TUBE, DID NOT FUSE PROPERLY.
Potential Consequence
OVER TIME, A PORTION OF THE BRACKET CAN TEAR AWAY FROM THE STRUT, FALLING INTO AND PUNCTURING THE TIRE OR CAUSING DAMAGE TO THE WHEEL, WHICH COULD RESULT IN AN ACCIDENT.
Remedy
MONROE DEALERS WILL REPLACE THE STRUT FREE OF CHARGE.
10 Active Recalls
Requires attention
1994 Mercury Sable Recall FAQs
Common questions about recalls for this vehicle
Related Recall Checks
Browse recall information for the latest model year vehicles.