Mercury · 1990–2009
Sable Recalls
39 known recalls affecting the Mercury Sable (1990–2009). Enter your VIN to check if your specific vehicle is affected, or browse by model year below.
Mercury Sable Recalls
Summary
On certain vehicles, the front coil springs may fracture when operated in high corrosion areas (where salt is used on the roadways in winter). The potential for corrosion causing a spring to fracture increases with the number of kilometres and years in service on the vehicle. A fractured spring could move past the spring seat and contact a front tire causing a rupture resulting in a rapid air loss. Correction: For vehicles sold in or are currently registered in the provinces of Ontario, Quebec, New Brunswick, Prince Edward Island, Nova Scotia, Newfoundland and Labrador, dealers will install protective spring shields as specified in recall campaign 04S17. In addition, Ford will notify nationwide all 1999 to 2001 Taurus and Sable owners of a Customer Satisfaction Program 04M04 in which Ford will provide additional repair coverage for replacement of fractured front coil springs for a period of 10 years from the original date of sale of the vehicle, or up to 240 000 kilometres, whichever occurs first.
Summary
Certain Taurus and Sable vehicles with 3.0 liter and 3.8 liter engines and 1995 model year Mustang vehicles with 3.8 liter and 5.0 liter engines. The engine cooling fan motor bearings, can result in increased motor torque and higher than normal motor current with accompanying high motor temperatures. Overheating of the cooling fan motor due to excessive current can result in smoke and odors. This condition can cause smoke or flames from the fan and/or shroud, the fan electrical wiring, or the fan motor resulting in a vehicle fire. Correction: dealers will install an electrical jumper harness containing an automatic resetting circuit breaker to protect the fan motor low speed circuitry from overheating.
Summary
On certain vehicles, the seat belt retractor in certain seating positions may have a pin shaft in the switchable ELR/ALR(emergency locking retractor/automatic locking retractor) mechanism that is incorrectly formed. In some circumstances, the switching mechanism could become non-functional, which could prevent the seat belt webbing from being extracted from the retractor. Correction: Affected vehicles will be inspected and suspect lap and shoulder belt assemblies will be replaced.
Summary
On certain vehicles located in Manitoba, Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador, the lower sub frame mount plate nut may corrode and fail due to exposure to road salt. This could result in loss of structural integrity of the subframe mount attachment. Detachment of the body mounts at the rear corners of the sub frame which supports the engine and transmission, allows the rear corners of the sub frame to drop. Should both rear corners drop, steering control would be adversely affected. Correction: Dealers will install subframe rear mount bolts, reinforcement plate and plate nuts.
Summary
THE DASH INSULATOR RETAINER MAY NOT HAVE BEEN FULLY ENGAGED. THE RETAINER MAY DISENGAGE, AND IN SOME CASES IT COULD BECOME LODGED ABOVE THE ACCELERATOR PEDAL PIVOT. THIS COULD PREVENT THE ENGINE FROM FULLY RETURNING TO IDLE. CORRECTION: VEHICLES WILL BE INSPECTED FOR PROPER INSTALLATION OF THE DASH INSULATOR RETAINER AND RE-INSTALL IF REQUIRED.
Summary
THESE VEHICLES MAY HAVE A FRONT SEAT BELT BUCKLE ATTACHING STUD THAT MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATING MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD. IF THE STUD IS CRACKED, THERE IS THE POTENTIAL FOR LESS THAN THE INTENDED LEVEL OF OCCUPANT RESTRAINT IN THE EVENT OF A VEHICLE CRASH. CORRECTION: SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY WILL BE REPLACED ON AFFECTED VEHICLES.
Summary
NOTE: VEHICLES SOLD OR CURRENTLY REGISTERED IN ONTARIO, QUEBEC, AND THE ATLANTIC PROVINCES. THE FRONT COIL SPRINGS MAY FRACTURE AS A RESULT OF CORROSION IN COMBINATION WITH SMALL TRANSVERSE CRACKS IN THE SPRINGS. THERE IS A POTENTIAL FOR TIRE DEFLATION FROM INTERACTION OF A BROKEN FRONT COIL SPRING AND THE TIRE. THIS COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH WITHOUT PRIOR WARNING. CORRECTION: A SPRING CATCHER BRACKET WILL BE INSTALLED WHICH WILL PREVENT A FRACTURED SPRING FROM CONTACTING A TIRE.
Summary
VEHICLES THAT WERE SERVICED FOR A STALL CONDITION BETWEEN AUGUST 1, 1997 AND DECEMBER 1, 1997 MAY HAVE RECEIVED AND INCORRECT FUEL TANK. THE INCORRECT TANK CONTAINS AN ADDITIONAL VENT HOLE WHICH PROVIDES THE POTENTIAL FOR A FUEL LEAK. CORRECTION: VEHICLES WILL BE INSPECTED AND FUEL TANK WILL BE REPLACED WITH THE CORRECT TANK IF NECESSARY.
Summary
THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 108 - LIGHTING SYSTEM AND RETROREFLECTIVE DEVICES. THE HEADLIGHT AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. CORRECTION: REVISED OWNER GUIDES WILL BE MAILED TO OWNERS.
Summary
THE HEADLIGHTS MAY FLASH INTERMITTENTLY AS A RESULT OF THE HEADLIGHT SWITCH CIRCUIT BREAKER OPENING DUE TO OVERHEATING. EXTENDED CYCLING OF THE CIRCUIT BREAKER COULD RESULT IN LONGER AND MORE FREQUENT LIGHT OUTAGES. LOSS OF HEADLIGHTS DURING VEHICLE OPERATION COULD POTENTIALLY AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY. CORRECTION: DEALERS WILL INSTALL A HEADLIGHT SWITCH INCORPORATING A REVISED DESIGN CIRCUIT BREAKER AND, IF REQUIRED, A WIRING HARNESS CONNECTOR AND WIRING WILL BE INSTALLED.
Showing 1-10 of 39 recalls
Related Recall Checks
Check recalls for specific Mercury Sable model years