Campaigns on record across the Isuzu Npr (1989–2024), from Transport Canada and, tagged NHTSA, the United States. Pick a model year for the Canadian listing, and check your VIN with Isuzu to confirm which apply.
Issue: On certain trucks, the seal on the fuse holders for the ignition coil packs may be too small. As a result, water could leak into the fuses and cause them to corrode or fail. If this happens, the engine may not start or it could lose power suddenly while driving. Note: This problem only affects trucks with a gasoline engine. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: Isuzu will notify owners by mail and advise you to take your truck to a dealership to replace the engine ignition coil pack fuse holders.
2023444 · 659 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2024 isuzu npr recalls
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2015-2017 Isuzu NPR, Reach, 2016-2020 Isuzu NPR XD, NPR HD, NQR, 2016-2021 Isuzu NRR, 2017-2020 Chevrolet 4500XD, 4500HD, 5500HD, and 2020 Chevrolet 5500XD vehicles. The U-bolt nuts for the rear axle may not have been properly tightened and may loosen, causing the axle to misalign.
The misalignment may cause the propeller shaft to separate, causing a loss of power to the rear wheels and a stall, increasing the risk of a crash.
Isuzu will notify owners, and dealers will inspect and, if needed, replace and tighten the rear axle U-bolt nuts, free of charge. The recall began on April 23, 2021. Owners may contact Isuzu customer service at 1-866-441-9638. Isuzu's number for this recall is V2103.
21V194000 · 258 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2017 isuzu npr recalls
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2019 NPR GAS, 2019 NPRHD GAS and 2019 Chevrolet 4500 vehicles. The brake line clips for the rear driver side brake line may have been incorrectly installed, potentially allowing the brake line to contact a grounding bolt, potentially causing a loss of the rear driver side brakes.
If the rear driver side brake fails, the vehicle may experience reduced braking, increasing the risk of a crash.
Isuzu will notify owners, and dealers inspect and replace brake line assembly or reposition the brake line into the proper position, as necessary, free of charge. The recall began May 15, 2020. Owners may contact Isuzu customer service at 1-866-441-9638. Isuzu's number for this recall is V2002.
20V193000 · 157 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2019 isuzu npr recalls
Issue: On certain vehicles, the seat belts may be assembled incorrectly. As a result, the seat belts may not properly lock-up in certain types of crashes. Safety Risk: A seat belt that does not work properly could increase the risk of injury in a crash. Corrective Actions: Isuzu will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the seat belt assemblies. They will be replaced as necessary.
2020012 · 101 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2019 isuzu npr gas recalls
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2020 Isuzu NPR HD, NPR XD, NQR and NRR and Chevrolet 4500HD, 4500XD, 5500HD and 5500XD and 2019 Isuzu NPR HD GAS, NPR GAS and Chevrolet 4500 and Chevrolet 3500 vehicles equipped with a dual mode belt locking mechanism seat belt assembly. Due to a manufacturing issue, the seat belt webbing locking mechanism may not properly restrain the occupant as intended.
In the event of a crash, if the occupant is not properly restrained, there is an increased risk of injury.
Isuzu will notify owners, and dealers will inspect and replace the seat belt assembly, as necessary, free of charge. The recall began February 20, 2020. Owners may contact Isuzu customer service at 1-866-441-9638 or Chevrolet customer service at 1-800-222-1020. Isuzu's number for this recall is V2001.
20V025000 · 1,138 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2019 isuzu npr recalls
Diesel Modification Center LLC. (Diesel Modification Center) is recalling certain 2018-2019 Isuzu NQR ,NRR, and NPR vehicles modified to be equipped with dual steering. The keystock may become dislodged from the steering cross shaft and cause unexpected loss of right hand steering.
Unexpected loss of steering increases the risk of a crash.
Diesel Modification Center will notify owners, and dealers will verify the keystock is in place or replace it, as necessary. In addition, the set screw will be retorqued and a stamp will be drifted in the keyed slot to ensure the keystock stays in the correct position, free of charge. The recall began November 11, 2019. Owners may contact Diesel Modification Center customer service at 1-256-457-1726.
19V663000 · 136 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2019 isuzu npr recalls
Unicell Body Company Inc. (Unicell) is recalling certain 2017-2019 Chevrolet Express and GMC Savanna, 2018-2019 Hino 155, Ford Econoline and Transit and Isuzu NPR, and 2018 Ram ProMaster-based vehicles equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The affected monitors may revert back to the factory default settings which may cause the camera image to be reversed.
The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
Unicell will work with ASA Electronics to notify owners and offer a remedy, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics customer service 1-800-384-4400 or Unicell at 1-716-853-8628.
19V428000 · 325 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2019 isuzu npr recalls
On certain vehicles equipped with diesel engines, the brake switch retaining tab may not have been fully secured into the steel brake pedal assembly bracket, and could allow for the switch and retainer to detach from the bracket. If this were to occur, it could cause the brake lights to illuminate whether the brake pedal is depressed or not, and restrict the ability to move the shifter out of Park. Additionally, the accelerator pedal input would also be disabled, which would result in a loss of motive power. These conditions could increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will inspect the retainer to ensure that it is properly seated and will repair as necessary.
2018183 · 10 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2018 isuzu npr recalls
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2018 Isuzu NPR and 2019 Isuzu NPR-HD and NPR-XD vehicles. These vehicles have a brake switch and nylon retainer that may not have been properly secured into the steel brake pedal assembly bracket.
If the brake switch and nylon retainer are not properly secured, the switch can detach from the bracket causing the brake lights to illuminate whether or not brake pedal is depressed, the shift interlock will not operate and the accelerator pedal input will be disabled resulting in the inability to accelerate. These conditions can increase the risk of a crash.
Isuzu has notified owners, and dealers will inspect the seating of the retainer, and re-seat the retainer clip or replace the retainer clip, if necessary, free of charge. The recall began on April 24, 2018. Owners may contact Isuzu customer service at 1-866-441-9638. Isuzu's number for this recall is V1801.
18V235000 · 80 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2018 isuzu npr recalls
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2011-2017 Isuzu NPR, 2008 NPR HD and NPR-HD Gas, 2011-2018 NPR HD and NRR, 2015-2018 NPR XD, 2012-2018 NQR, 2012-2017 NPR Gas and NPR-HD Gas, 2016-2017 Chevrolet Low Cab Forward 3500 HD, 3500 and 4500 and 2017-2018 Chevrolet Low Cab Forward 4500 HD, 4500 XD, 5500 HD and 5500 XD vehicles, equipped with certain Walter Kidde Plastic-Handle Fire Extinguishers, models FC10 and FC110. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable.
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Isuzu will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall is expected to begin in December 2017. Owners may contact Isuzu customer service at 1-866-441-9638 or Walter Kidde customer service at 1-855-262-3540 or they may also visit www.kidde.com and click on "Product Safety Recall" to order replacement fire extinguishers free of charge. Isuzu's number for this recall is V1705. Note: This recall includes fire extinguishers provided as a remedy for previous Isuzu recall 15V778.
17V726000 · 69,138 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2017 isuzu npr recalls
1–10 of 32