Campaigns on record across the Ford F-800 (1979–1998), from Transport Canada and, tagged NHTSA, the United States. Pick a model year for the Canadian listing, and check your VIN with Ford to confirm which apply.
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.
FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
07E064000 · 34,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1979 ford f800 recalls
AUTOMATIC FRONT WHEEL BEARING ADJUSTING NUTS MAY BE SUSCEPTIBLE TO DAMAGE DURING INSTALLATION OR REMOVAL DUE TO INCORRECT TOOLS OR INCORRECT TORQUE. ALSO, SOME OF THE NUTS MAY HAVE BEEN DAMAGED DURING VEHICLE ASSEMBLY. THIS CAN RESULT IN THE NUT HAVING THE POTENTIAL TO ROTATE FREELY AND LOOSE TORQUE. IN TURN THIS CONDITION COULD RESULT IN FRONT WHEEL SEPARATION. CORRECTION: FRONT WHEEL BEARING ADJUSTING NUTS WILL BE REPLACED WITH CASTLE NUTS AND COTTER PINS.
1998045 · 30 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1998 ford f 800 recalls
VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS AND CHASSIS-CABS. AN AUTOMATIC LOCKING FRONT WHEEL BEARING ADJUSTING NUT WAS DAMAGED DURING INSTALLATION OR REMOVAL BY INCORRECT TOOLS OR AN INCORRECT TORQUE SPECIFICATION WAS USED.
THIS CONDITION CAN CAUSE THE NUT TO ROTATE FREELY AND LOSE TORQUE. IT COULD ROTATE UNTIL IT IS NO LONGER CONNECTED TO THE FRONT SPINDLE AND ALLOW THE FRONT WHEEL TO SEPARATE FROM THE VEHICLE.
DEALERS WILL REPLACE THE FRONT WHEEL BEARING ADJUSTING NUTS WITH CASTLE NUTS AND COTTER PINS.
98V041000 · 1,600 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1998 ford f800 recalls
VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS AND SCHOOL BUS CHASSIS-COWLS EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE WELDS THAT ATTACH THE KEY TO THE TOP OF THE STEERING COLUMN MOUNTED AUTOMATIC TRANSMISSION SHIFT LINKAGE MAY NOT ADEQUATELY RETAIN THE KEY, ALLOWING THE TRANSMISSION TO BE IN A GEAR OTHER THAN THAT INDICATED ON THE "PRNDL", OR IN SOME CASES, "RNDL."
THE DOMESTIC SPECIAL ORDER (DSO) PARK BRAKE MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION, OR IN THE VEHICLE MOVING IN AN UNINTENDED DIRECTION WHEN THE ACCELERATOR IS PRESSED. IN SOME VEHICLES THE DSO PARKING BRAKE MECHANISM ALSO MAY NOT BE PROPERLY ADJUSTED, WHICH CAN RESULT IN THE PARK BRAKE NOT ENGAGING WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
DEALERS WILL REPLACE THE STEERING COLUMN SHIFT TUBE AND, IF SO EQUIPPED, TO HAVE THE DSO PARK BRAKE LINKAGE ADJUSTED.
97V091000 · 2,400 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1998 ford f800 recalls
NOTE: VEHICLES BUILT WITH LIQUID PETROLEUM GAS (LPG) ENGINES. NO 1992 VEHICLES WERE PRODUCED WITH LPG ENGINES. THESE VEHICLES DO NOT COMPLY WITH CMVSS 301.1 - LPG FUEL SYSTEM INTEGRITY. VEHICLES MAY HAVE BEEN BUILT WITH LPG FUEL HOSES INTENDED FOR U.S. VEHICLES, RATHER THAN THE TYPE III HOSES THAT ARE SPECIFIED BY THE CANADIAN STANDARD. BOTH THE ENGINE TO BULKHEAD HOSES AND BULKHEAD TO TANK HOSES MAY BE AFFECTED. CORRECTION: VEHICLES WILL BE INSPECTED AND TYPE III HOSES WILL BE INSTALLED AS REQUIRED.
1995214 · 237 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1995 ford f 800 recalls
THE HAND THROTTLE CABLE CAN WEAR THE BRASS SWIVEL BLOCK ON THE GOVERNOR LEVER THROUGH WHICH IT PASSES.
THIS WEAR CAN RESULT IN THE GOVERNOR JAMMING IN THEDAMAGED SWIVEL AND COULD PREVENT THE GOVERNOR LEVER FROM RETURNING TO THE IDLE POSITION.
DEALERS WILL INSTALL A REVISED GOVERNOR LEVER WITH A STAINLESS STEEL SWIVEL. ALSO LETTERS WILL BE SENT TO VEHICLE OWNERS THAT HAVE THE SAME VEHICLES BUT DO NOT HAVE A FORD INSTALLED HAND THROTTLE ADVISING THEM THAT THEY MAY REQUIRE SERVICE IF THEY HAVE HAD AN AFTER MARKET HAND THROTTLE INSTALLED.
95V143000 · 29,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1995 ford f800 recalls
AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVERPRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM THE MOUNTING BASE.
IF THE AIR DRYER SEPARATES FROM THE BASE, THE CARTRIDGE CAN SEPARATE SUFFICIENTLY ENOUGH TO CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.
DEALERS WILL EQUIP AIR SYSTEMS WITH A PRESSURE RELIEF VALVE TO BE LOCATED BETWEEN THE COMPRESSOR AND THE AIR DRYER. THIS PRESSURE RELIEF VALVE IS INTENDED TO VENT IF EXCESSIVE PRESSURE DEVELOPS IN THE AIR DRYER.
95E003008 · 3,500 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1995 ford f800 recalls
A CONNECTOR IN THE WIRING WHERE THE TILT HOOD MOUNTED LAMPS ATTACH TO THE VEHICLE WIRING HARNESS WAS BUILT WITHOUT SEALING PLUGS. MOISTURE, ROAD SALT OR OTHER CONTAMINANTS CAN ENTER THE CONNECTION RESULTING IN CROSSED CIRCUITS, SHORTS OR CORROSION OF THE WIRING OF THE CONNECTOR.
THE HEADLAMPS OR OTHER FRONT-END LIGHTING SYSTEMS CAN MALFUNCTION AS A RESULT OF THIS CONDITION INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
DEALERS WILL INSPECT THE CONNECTOR AND INSTALL SEALING PLUGS IN THE OPEN CAVITIES. IF THE INSPECTION REVEALS CORROSION, A NEW CONNECTOR WILL BE INSTALLED.
95V092000 · 13,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1995 ford f800 recalls
THESE VEHICLES DID NOT COMPLY WITH C.M.V.S.S. 105 - HYDRAULIC BRAKE SYSTEMS. VEHICLES WERE BUILT WITHOUT ABS INDICATOR LAMPS. CORRECTION: ABS INDICATOR LAMPS AND CIRCUITRY WERE INSTALLED ON AFFECTED VEHICLES.
1995025 · 2 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1995 ford f 800 recalls
NOTE: VEHICLES WITH LOW PROFILE OPTION AND 6000 OR 7000 LBS. RATED FRONT AXLES. THE DRAGLINK ON THESE VEHICLES MAY CONTACT THE FRONT AXLE I-BEAM UNDER CERTAIN EXTREME CONDITIONS RESULTING IN STEERING CONTROL INTERFERENCE. THIS DRAGLINK WAS NOT DESIGNED TO BE INSTALLED ON LOW PROFILE VEHICLES. CORRECTION: CORRECT DRAGLINK WILL BE INSTALLED ON AFFECTED VEHICLES.
1995016 · 34 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1995 ford f 800 recalls
1–10 of 28