2011 Ford F-550
Safety Recalls & Notices
We found 8 safety recalls for the 2011 Ford F-550. Recalls are sourced from both NHTSA (US) and Transport Canada databases. Contact your authorized Ford dealer to schedule free repairs.
Summary
Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.
Summary
Certain ambulance or fire package vehicles with 6.7L diesel engines may experience a "stop safety now" warning message and 5 audible chimes if an Exhaust Gas Temperature (EGT) sensor fault is detected. Engine torque would be gradually reduced by 70 percent over a period of 45 seconds to a power-reduced level that is maintained. During this time, there would be no effect on steering, braking, lighting, electrical, or restraint systems, allowing the operator to maneuver the vehicle to a safe location. Such an occurrence could also result in an engine shut down and subsequent inability to quickly restart the vehicle. If this condition were to occur when an ambulance or fire engine vehicle was transporting a patient or providing medical assistance, it could delay medical treatment and increase the risk of injury to the patient. Correction: Dealers will reprogram the Powertrain Control Module with updated software.
Summary
Certain ambulance package vehicles with 6.7L diesel engines may experience a "stop safety now" warning message and 5 audible chimes while the vehicles gradually loses power, eventually resulting in the engine stalling when speed falls below 5 km/h. If this were to occur while the ambulance is transporting a patient, engine shutdown with no ability to restart could interfere with patient care and increase the risk of injury to the patient. Correction: Dealers will replace the exhaust gas temperature (EGT) sensor located downstream of the diesel particulate filter (DPF).
Summary
All Wheel Drive Equipment Mfg., Inc. (All Wheel) is recalling one model year 2011 Ford F-550 truck with a 6.8L gasoline engine manufactured May 14, 2010, to May 28, 2010. The affected vehicle is equipped with a PTO Assembly Pressure Switch, part number FR67, used with power take off (PTO) assemblies for Ford F-550 chassis. The PTO switch may leak oil onto the thermal blanket.
Potential Consequence
The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy
All Wheel has notified the owner and will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. Owners may contact All Wheel customer service at 1-800-311-4778.
Summary
PJ's Truck Bodies & Equipment Co., (PJ's) is recalling certain 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis modified by PJ's and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Potential Consequence
The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy
PJ's has notified owners and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on August 28, 2014. Owners may contact PJ's customer service at 1-866-475-8782.
Summary
J.C. Madigan, Inc. (J.C. Madigan) is recalling one model year 2011 Ford F-550, and one model year 2013 Ford F-450 chassis with a 6.8L gasoline engine dump trucks equipped with certain PTO Assembly Pressure Switches, part number 30T37594, manufactured June 2009 through June 2013, used in power take off (PTO) assemblies. The switch may begin leaking oil.
Potential Consequence
The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy
J.C. Madigan will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began in September 2014. Owners may contact J.C. Madigan customer service at 1-978-847-2900.
Summary
Almared, Inc., dba A-1 Alternative Fuel Systems, is recalling certain model year 2011-2012 Ford F-550 transit buses manufactured May 2011 through April 2013, altered to operate on compressed natural gas (CNG). In the affected vehicles, the brackets securing the passenger side CNG fuel tank may break.
Potential Consequence
If the brackets break, the CNG tank may separate from the vehicle frame increasing the risk of a crash or possible fire.
Remedy
Almared, Inc. has notified owners and all affected vehicles have been remedied, free of charge. Owners may contact Almared at 1-559-485-4427.
Summary
Ford Motor Company (Ford) is recalling certain model year 2011-2012 F-350/450/550 Ambulance Package vehicles manufactured February 22, 2010, through October 19, 2012 and equipped with a 6.7L diesel engine. Due to an exhaust sensor problem, the vehicles may experience loss of power followed by an engine stall.
Potential Consequence
An unexpected engine stall increases the risk of a crash. Additionally, if this were to occur when the ambulance is transporting a patient, there is an increased risk of injury to the patient.
Remedy
Ford will notify owners, and dealers will replace the exhaust gas temperature sensor, free of charge. The recall began on November 25, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332. Ford's recall campaign number is 13S10.
8 Active Recalls
Requires attention
2011 Ford F-550 Recall FAQs
Common questions about recalls for this vehicle
Related Recall Checks
Compare recall history with competitors and alternatives to the 2011 Ford F-550.