2005 Chrysler Pt Cruiser
Safety Recalls & Notices
7 Active Recalls
Requires attention
Other
Summary
Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.
EXTERIOR LIGHTING
Summary
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Potential Consequence
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
SUSPENSION
Summary
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
Potential Consequence
THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy
FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.
Other
Summary
On certain vehicles, the rear quarter glass attaching fasteners may pull through their mounts and allow the glass to separate from the vehicle. If the glass separates while driving, it could strike another vehicle and cause a crash. Correction: Dealers will replace the rear quarter glass.
VISIBILITY:GLASS, SIDE/REAR
Summary
ON CERTAIN PASSENGER VEHICLES, THE REAR QUARTER GLASS ATTACHING FASTENERS MAY PULL THROUGH THEIR MOUNTS AND ALLOW THE GLASS TO SEPARATE FROM THE VEHICLE.
Potential Consequence
IF THE GLASS SEPARATES WHILE DRIVING, IT COULD STRIKE ANOTHER VEHICLE OR INJURE A PEDESTRIAN.
Remedy
DEALERS WILL REPLACE THE REAR QUARTER GLASS. THE RECALL BEGAN ON APRIL 30, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
Summary
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKING SYSTEM (ABS), 2.4L HIGH OUTPUT TURBOCHARGED ENGINE, AND 5-SPEED MANUAL TRANSAXLE, MAY EXHIBIT INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE TRANSAXLE HOUSING.
Potential Consequence
CONTACT BETWEEN THE BRAKE TUBE AND THE TRANSAXLE HOUSING OVER AN EXTENDED PERIOD OF TIME MAY EVENTUALLY LEAD TO PERFORATION OF THE BRAKE TUBE, WHICH COULD LEAD TO A LOSS OF BRAKING FORCE IN THE LEFT FRONT/RIGHT REAR CIRCUIT OF VEHICLE.
Remedy
DEALERS WILL INSTALL REVISED BRAKE TUBES. THE RECALL BEGAN OCTOBER 25, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Summary
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Potential Consequence
POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy
DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Generated by Cardog • December 16, 2025
2005 Chrysler Pt Cruiser
Safety Recalls & Notices
7 Active Recalls
Requires attention
