2016 Audi Q5
Safety Recalls & Notices
We found 11 safety recalls for the 2016 Audi Q5. Recalls are sourced from both NHTSA (US) and Transport Canada databases. Contact your authorized Audi dealer to schedule free repairs.
Summary
On certain vehicles equipped with a 2.0L TFSI engine, the electric coolant pump could experience a short circuit and/or overheat. A short circuit or overheating of the pump could increase the risk of a fire causing injury and/or damage to property. Correction: Dealers will unplug the electric coolant pump and update the coolant pump software to mitigate the risk of fire as an interim measure. When parts become available, dealers will replace the electric coolant pump, and install an updated coolant pump software.
Summary
On certain vehicles, the contacts within the electrical connector of the auxiliary heater could corrode. This could cause the auxiliary heater to fail and/or cause the wires to overheat and melt. If the wires were to melt, it could lead to an open circuit and/or overheating, which could increase the risk of a fire causing injury and/or damage to property. Correction: Dealers will replace the auxiliary heater and update vehicle software as necessary.
Summary
On certain vehicles, the fuel pump flange may develop fine cracks or fissures, which could result in a fuel leak. Leaking fuel, in the presence of an ignition source, could lead to a fire causing injury and/or damage to property. Correction: Dealers will apply a butyl protective film to the fuel pump flange. If cracks are present, the fuel pump flange will be replaced. Note: This is an expansion of recall 2016-443.
Summary
On certain vehicles, if the water drainage system of the panoramic sunroof becomes damaged or impaired (such as during a repair), water could enter the side head curtain airbag canister. Due to a foam that is touching the airbag inflator, moisture could cause corrosion on the airbag inflator over time. If this happens, the airbag canister could be weakened. This could cause the airbag canister to fracture without airbag deployment and allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. Correction: Dealers will inspect the vehicle for evidence of water ingress, examine the drainage system, disassemble the headliner and trim, remove foam and inspect the side head curtain airbag canister for relevant corrosion. In cases where light surface corrosion is found, a wax will be applied to the inflator. In cases of more than light surface corrosion, the inflator will be replaced after a robustness check.
Summary
On certain vehicles equipped with a 2.0L TFSI engine, the coolant pump could become blocked by debris from the cooling system. This could lead to the pump overheating and could increase the risk of a fire causing injury and/or damage to property. Correction: Dealers will update vehicle software which deactivates the power supply to the coolant pump if the pump becomes blocked with debris. The driver will be notified of the blocked coolant pump through the illumination of the Electronic Power Control (EPC) lamp.
Summary
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2017 Audi A5 Cabriolet, A5 Sedan and Audi Q5 vehicles, 2012-2015 Audi A6 vehicles and 2013-2016 Audi A4 Sedan and A4 allroad vehicles. These vehicles, equipped with 2.0l Turbo FSI engines, have an electric coolant pump that can either become blocked with debris from the cooling system causing it to overheat or can short-circuit from moisture within the pump.
Potential Consequence
A blocked pump or a short-circuited pump can increase the risk of a fire.
Remedy
Audi will notify owners, and dealers will replace the pumps, free of charge. The recall began September 14, 2018. Owners may contact Audi customer service at 1-800-253-2834. Audi's number's for this recall is 19N3/19N4. Note: This recall is in additional to the coolant pump software update applied as a remedy under recall 17V002.
Summary
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2016 Audi A5 Coupe, A5 Cabriolet, A4 Sedan, A4 Allroad and Q5 vehicles. Contact corrosion within the electrical connector for the auxiliary heater may cause the heater wires to overheat or melt.
Potential Consequence
The melted wires can increase the risk of a fire.
Remedy
Audi will notify owners, and dealers will replace the auxiliary heater and, as necessary, update the software, free of charge. The Recall began November 27, 2017. Owners may contact Audi customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 80C5 and 80C6.
Summary
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2013-2017 Audi Q5 and 2013-2017 Audi Q7 vehicles. These gasoline-powered vehicles have a fuel pump flange that may crack, allowing fuel to leak.
Potential Consequence
A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy
Audi will notify owners, and dealers will replace the fuel pump flange if cracks are present. Flanges that do not have cracks will have a protective film applied. These repairs will be performed free of charge. The recall began July 3, 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20Z8. Note: This recall is an expansion of recall 16V-660.
Summary
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2017 Audi A5, A5 Cabriolet and Q5 vehicles, 2013-2016 Audi Allroad and Audi A4 vehicles and 2012-2015 Audi A6 vehicles. These vehicles, equipped with 2.0l Turbo FSI engines, have an electric coolant pump that can be blocked with debris from the cooling system, resulting in the pump overheating.
Potential Consequence
If the coolant pump overheats, it can increase the risk of a fire.
Remedy
Audi will notify owners, and dealers will update the software so that the power supply to the coolant pump is deactivated if the pump becomes blocked with debris, free of charge. The recall is expected to begin February 20, 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 19M1.
Summary
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2011-2017 Audi Q5 vehicles. The sunroof drainage system may allow water to soak into the foam surrounding the side head air bag inflator canister resulting in the corrosion of the canister. If this happens, the corrosion can weaken the canister and the inflator could fracture without air bag deployment, propelling fragments into the passenger compartment, striking and causing serious injury to vehicle occupants.
Potential Consequence
An inflator rupture may result in metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy
Audi will notify owners, and dealers will inspect the inflator and either coat it or replace it, as necessary, after removing the surrounding foam, free of charge. The recall is expected to began March 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69P1.
11 Active Recalls
Requires attention
2016 Audi Q5 Recall FAQs
Common questions about recalls for this vehicle
Related Recall Checks
Compare recall history with competitors and alternatives to the 2016 Audi Q5.