Newest first. Many cover only part of a model year, so check your VIN with NHTSA or Ford before booking a repair.
NHTSA · listed for this model year
Phenix Enterprises, Inc. (Phenix) is recalling certain model year 2009 and 2011 trucks manufactured from July 22, 2008, through December 16, 2011, equipped with a Sure Power battery separator, part number 16511893 (model 1314). Suspect vehicles, in their as-built configuration, had a Sure Power battery separator installed on the inboard side of the curb side rail. These battery separators may overheat.
If the battery separator overheats it can result in smoke and possibly a fire.
Phenix will notify owners and replace the battery separator free of charge. Owners may contact Phenix at 1-800-736-9790.
12V562000 · 42 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
FORD IS RECALLING CERTAIN MODEL YEAR 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH CATERPILLAR C7 ENGINE. THE #5 AND #6 FUEL LINES MAY CRACK AT THE FASTENING POINT TO THE COMMON FUEL RAIL AND CAUSE A FUEL LEAK.
A FUEL LEAK, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN A VEHICLE FIRE.
FORD IS WORKING WITH CATERPILLAR TO NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY AUTHORIZED CATERPILLAR DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 8, 2010. OWNERS MAY CONTACT CATERPILLAR TOLL-FREE AT 1-800-447-4986 OR FORD AT 1-866-436-7332.
10V398000 · 3,469 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
FORD IS RECALLING MODEL YEARS 2009 F-650 AND F-750 TRUCKS. THE CHASSIS WIRE HARNESS MAY HAVE BEEN ASSEMBLED WITHOUT A CONNECTOR SEAL IF THIS SEAL IS MISSING, THE CONNECTOR TERMINALS MAY CORRODE AFFECTING THE PROPER ILLUMINATION OF THE VEHICLE'S REAR BRAKE LAMPS, TAIL LAMPS, TURN SIGNAL LAMPS OR TRAILER LAMPS (IF EQUIPPED.) ALSO, THE FUNCTION OF THE ANTI-LOCK BRAKE SYSTEM MAY BE AFFECTED.
INOPERATIVE LAMPS MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL INSPECT THE CONNECTOR AND REPAIR THE MAIN AND REAR CHASSIS WIRE HARNESS IF NECESSARY. A MISSING SEAL WILL BE REPLACED AND ELECTRICAL GREASE APPLIED TO PREVENT FUTURE CORROSION. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2009. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR THROUGH THE INTERNET AT WWW.FORDOWNER.COM.
09V476000 · 42 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
FORD IS RECALLING 2,811 MY 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH C7 OR C9 CATERPILLAR DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
FORD IS WORKING WITH CATERPILLAR (PLEASE SEE 08E042). CATERPILLAR WILL REPLACE THE FUEL PUMP PLUG FREE OF CHARGE. OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986, OR FORD AT 1-800-343-5338 (FLEET OWNERS) OR 1-866-906-9811 (MOTOR HOME OWNERS).
08V428000 · 2,811 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Canadian records (Transport Canada) · 4
These are Transport Canada campaigns for 2009 Ford F 650 vehicles sold in Canada. A Canadian campaign may have no US counterpart, or one under a different number covering different vehicles. For a vehicle sold in the United States, go by the NHTSA listing above and NHTSA's VIN lookup.
Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.
2019420 · 5,327 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Certain vehicles fail to conform to Canada Motor Vehicle Safety Standard 105 - Hydraulic and Electric Brake Systems. On subject vehicles, the parking brake telltale lamp does not illuminate when the key is in the "on" or "start" positions. Correction: Due to the inconsequential nature of this non-compliance, no action will be taken.
2012324 · 474 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks equipped with a Caterpillar C7 diesel engine, the number 5 and 6 fuel lines may crack at the fastening point to the common fuel rail, causing a high pressure fuel leak. Fuel leakage, in the presence of an ignition source, could result in a fire causing property damage and/or personal injury. Correction: Dealers will replace the affected fuel lines.
2010285 · 112 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks equipped with diesel engines, a fuel pump outlet check plug may crack and cause fuel to spray and leak from the fuel pump, which could create a fire hazard. Correction: Caterpillar dealers will replace the fuel pump plugs.
2008287 · 84 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
2009 Ford F 650 recall questions
NHTSA lists 4 recalls for the 2009 Ford F 650 model year. That counts campaigns naming this model year, not recalls on your vehicle: many cover only a VIN range or production window. Transport Canada lists 4 Canadian campaigns for the Canadian-market model, shown separately.
Enter your VIN in NHTSA's recall lookup or Ford's own, or call a Ford dealer with your VIN. Cardog uses your VIN only to find the model year; the recalls shown here are listed for that model year and are not matched to your VIN.
Not necessarily. Transport Canada campaigns cover vehicles sold in Canada. For a vehicle sold in the United States, go by the NHTSA listing and NHTSA's VIN lookup.
Safety recall repairs are normally done at no charge by an authorized Ford dealer. The manufacturer's notice for each campaign sets out the remedy and any conditions, so confirm with the dealer when you book.
Once Ford's lookup or a dealer confirms a recall applies, book the repair with an authorized Ford dealer and bring your VIN. If the manufacturer's notice says not to drive the vehicle or to park it outside, follow that instruction. Parts can take time, so book early.
Follow the manufacturer's notice for that recall. Most allow normal driving until the repair; some tell owners to stop driving or to park outside until it is fixed. Cardog does not grade recalls by severity: the manufacturer's notice and your dealer are the source.
Manufacturers must notify owners they have on record. If you bought the vehicle used or have moved, update your details with Ford so notices reach you, and check NHTSA's lookup from time to time.
Related recall checks
Compare recall listings with alternatives to the 2009 Ford F 650.