1992 Volkswagen Corrado
Safety Recalls & Notices
5 Active Recalls
Requires attention
Heater And Defroster
Summary
On certain vehicles, excessive temperature and cooling system pressure could result in coolant leakage in the system including leakage from the heat exchanger. Leakage of coolant from the heat exchanger could cause injury to the feet of the driver, steam up the interior of the vehicle and temporarily impair the driver's vision. Correction: Dealer will conduct a functional check of the cooling system and install a pressure throttle which will result in reduced coolant pressure in the heat exchanger.
ENGINE AND ENGINE COOLING:COOLING SYSTEM
Summary
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH VR6 ENGINES. A COOLANT SYSTEM COMPONENT SUCH AS THE THERMO SWITCH, RADIATOR FAN, OR WATER PUMP, CAN MALFUNCTION CAUSING THE COOLANT TEMPERATURE AND COOLANT SYSTEM PRESSURE TO INCREASE SIGNIFICANTLY. OVER TIME, EXCESSIVE PRESSURE CAN CAUSE LEAKAGE OF COOLANT FROMTHE SYSTEM, INCLUDING LEAKAGE FROM THE HEAT EXCHANGER.
Potential Consequence
LEAKAGE OF HOT COOLANT FROM THE HEAT EXCHANGER CAN CAUSE INJURY TO THE FEET OF THE DRIVER OR STEAM UP THE INTERIOR OF THE VEHICLE TEMPORARILY IMPAIRING THE DRIVER'S VISION.
Remedy
DEALERS WILL INSTALL IN THE COOLANT INLET HOSE TO THE HEATER CORE, A PRESSURE REDUCER WITH A 5MM DIAMETER SECURED BY A SPRING TENSIONED HOSE CLAMP. ALSO A NEW RELAY THAT WILL CHANGE THE OPERATION OF THE SECONDARY ELECTRICAL COOLANT PUMP WILL BE INSTALLED. DEALERS WILL ALSO PERFORM A FUNCTIONAL CHECK OF THE COOLING SYSTEM TO MAKE SURE THAT ALL COOLING SYSTEM COMPONENTS OPERATE PROPERLY.
Fuel System
Summary
THE FUEL HOSE ATTACHED TO THE FUEL DISTRIBUTION RAIL, LOCATED IN THE ENGINE COMPARTMENT, MAY NOT BE ADEQUATELY CLAMPED. THIS COULD LEAD TO FUEL SEEPAGE AT THE HOSE CONNECTION. ESCAPING FUEL COULD COME INTO CONTACT WITH HOT ENGINE COMPONENTS AND POSSIBLY CAUSE AN ENGINE COMPARTMENT FIRE. CORRECTION: FUEL HOSE ATTACHED TO THE FUEL RAIL WILL BE REPLACED AND EXISTING HOSE CLAMPS WILL BE REPLACED WITH A NEW SPRING TYPE HOSE CLAMP.
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
Summary
AN ENGINE COMPARTMENT ELECTRICAL WIRING HARNESS MAY HAVE BEEN ROUTED TOO CLOSE TO A SHEET METAL EDGE. THE WIRING CAN BECOME DAMAGED DURING NORMAL VEHICLE OPERATION DUE TO CHAFING, RESULTING IN AN ELECTRICAL SHORT.
Potential Consequence
IF A SHORT OCCURS, EITHER THE ENGINE COULD STALL ORTHE RADIATOR FAN COULD STOP OPERATING CAUSING THE ENGINE TO OVERHEAT. EITHERCONDITION COULD RESULT IN A VEHICLE ACCIDENT.
Remedy
REROUTE AND SECURE VARIOUS WIRING HARNESSES INSIDE THE ENGINE COMPARTMENT.
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary
THE FUEL HOSE ATTACHED TO THE FUEL DISTRIBUTION RAIL ON THE ENGINE MAY SHRINK BEYOND THE CLAMP FORCE OF THE FUEL HOSE CLAMPS, ALLOWING FUEL TO LEAK.
Potential Consequence
FUEL LEAKAGE IN THE ENGINE COMPARTMENT CAN CAUSE AN UNDERHOOD FIRE IF THE FUEL COMES IN CONTACT WITH A SOURCE OF IGNITION.
Remedy
REPLACE THE FUEL HOSE ATTACHED TO THE FUEL RAIL AND INSTALL A NEW SPRING TYPE SELF-TIGHTENING CLAMP.
Generated by Cardog • December 16, 2025
1992 Volkswagen Corrado
Safety Recalls & Notices
5 Active Recalls
Requires attention
