Newest first. Many cover only part of a model year, so check your VIN with Freightliner before booking a repair.
Transport Canada · listed for this model year
Issue: On certain trucks equipped with "Fleet Engineer" mud flaps, the bracket for the mud flaps may partially cover the rear reflective tape. Canadian regulations require that reflective tape must be visible on the rear of the truck. Safety Risk: Reflective tape that is covered may make the truck less visible to others and could create an increased risk of a crash. Corrective Actions: Daimler Trucks of North America (DTNA) will notify owners by mail and instruct you to take your truck to an authorized DTNA Service Facility to inspect the reflective tape. It will be moved as necessary to meet the regulations.
2020158 · 873 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, a combination of brake vibrations and corrosion could cause the tie-rod tube to fatigue and break. This may lead to a disconnect between the front wheels and reduce the ability to steer the vehicle, which could increase the risk of a crash causing injury and/or damage to property. Correction: Daimler Trucks of North America Service Facilities will replace brake linings, brake spiders and tie rods as necessary.
2018395 · 32 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles with air brakes, after several hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal. If the brake lights do not illuminate, following road users would be unaware of the intent of the driver to slow the vehicle, which could increase the risk of a crash causing injury and/or damage to property. Correction: Daimler Trucks North America authorized service facilities will repair the brake light pressure switch.
2017583 · 41,763 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, the specified front axle weight limit may be greater than the hub capacity. If the axle load exceeds the maximum weight capacity of the hub, there is an increased risk of hub fatigue, which could cause a complete separation of the wheel(s) and a loss of vehicle control, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will replace the incorrectly specified front axle hubs.
2016419 · 149 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles equipped with Bergstrom Parksmart HVAC units, there maybe be inadequate electrical contact within the connector at the top of the compressor. This could cause an increased resistance in the circuit resulting in localized heating, which would increase the risk of fire causing injury and/or damage to property. Correction: Dealers will remove the open style design connector cap and replace it with an improved closed design cap, and will also inspect the compressor connector terminal for any signs of heat discolouration and replace the harness if discolouration is found.
2016113 · 1,282 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, brake chamber diaphragm(s) may not be properly seated. This could lead to brake drag, causing brake overheating or unintended spring brake application. These issues could increase the risk of a crash causing injury and/or property damage. Correction: Dealers will affect repairs as necessary.
2014548 · 714 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles outfitted with 1100W, 1500W & 2000W Thermo King inverters, the inverter could fail. This would be apparent through a "popping" noise and/or an odor emanating from the unit, and could result in an electrical short, smoke, and/or fire, which could increase the risk of injury and/or damage to property. Correction: An authorized service facility will replace the inverter installed, or refund the full purchase price based on availability of replacement inverters.
2014424 · 9 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
United States records (NHTSA) · 18
These are NHTSA campaigns for 2015 Freightliner Cascadia vehicles sold in the United States. They are not Canadian recalls: NHTSA's VIN lookup has no Canadian data, and a US campaign may have no Canadian counterpart, or one under a different number covering different vehicles. For a vehicle sold in Canada, go by the Transport Canada listing above and Freightliner's Canadian VIN lookup.
Daimler Trucks North America LLC (DTNA) is recalling certain 2006-2020 Freightliner Columbia, 2006-2021 Freightliner Business Class M2, 2007-2020 Freightliner Coronado, 2014-2021 Freightliner 122 SD, 2007 Sterling A 9500, 2006 Freightliner Argosy, 2006-2007 Sterling AT9500, 2008-2021 Freightliner Cascadia, 2006-2008 Freightliner Classic, 2006-2011 Freightliner Century Class, 2006-2010 Freightliner FLD, and 2017 Western Star 5700 vehicles. The rear reflective tape may be partially covered by the mudflap hanger bracket, which may reduce the vehicle's visibility to other drivers on the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
The vehicle's rearward visibility may be reduced, increasing the risk of a crash.
DTNA will notify owners, and dealers will inspect and reposition the reflective tape to ensure that it is completely visible, as necessary, free of charge. The recall began May 29, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL848.
20V214000 · 63,175 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain 2004-2019 Freightliner 108SD, 114SD, 122SD, Cascadia, Columbia, Classic, FL80, FLD 120SD, Business Class M2, Western Star 4700, 4900, 6900, Sterling Acterra, L7500, LT7500, L8500, LT8500, L9500, and LT9500 vehicles. The vehicles may have an insufficient service brake air reservoir capacity. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."
An insufficient air reservoir volume may reduce brake effectiveness, increasing the risk of crash.
DTNA will notify owners, and dealers will add air reservoir capacity to the affected vehicles. Owner letters were mailed on November 29, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-815.
19V370000 · 741 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain 2013-2016 Freightliner Cascadia vehicles equipped with Hendrickson 5" drop axles. In certain front axle, brake lining, and brake spider combinations, braking may cause high vibrations, resulting in early failure of the tie-rod tube.
A tie-rod failure would cause a disconnect between the front wheels, resulting in a loss of steering ability, thereby increasing the risk of a crash.
DTNA will notify owners, and dealers will replace the stamped brake spiders and the tie-rod, free of charge. The recall began April 12, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-807.
19V093000 · 111 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America, LLC (DTNA) is recalling certain 2012-2015 Freightliner Cascadia, Coronado, Business Class M2, 114SD, and Western Star 4900 trucks. In certain front axle, brake lining, and brake spider combinations, braking may cause high vibrations, resulting in early failure of the tie-rod tube.
A tie-rod failure would cause a disconnect between the front wheels, resulting in a loss of steering ability, thereby increasing the risk of a crash.
DTNA will notify owners, and dealers will replace the brake linings, brake spider, and tie-rod, free of charge. The recall began March 22, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL782.
18V503000 · 1,256 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Freightliner Cascadia, Century Class, Columbia and Coronado trucks and Western Star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
DTNA will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on April 11, 2018. Owners may contact DTNA customer service at 1-800-547-0712, or contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.
17V810000 · 24,860 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America, LLC (DTNA) is recalling certain 2008-2018 Freightliner Cascadia, Western Star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.
DTNA will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on January 22, 2018. The recall began on May 9, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-756.
17V761000 · 438,255 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America, LLC. (DTNA) is recalling certain model year 2013-2017 Freightliner Cascadia vehicles manufactured September 24, 2012, to May 27, 2015 and equipped with compressed natural gas (CNG) engines. The affected vehicles have a Power Distribution Module (PDM) that is mounted near the CNG fuel tank. Due to its location, the PDM may be sprayed with water and contaminants from the road, possibly causing the PDM to short circuit.
If the PDM short circuits, there would be an increased risk of a fire, especially if the nearby CNG tank leaks.
DTNA will notify owners, and dealers will relocate the PDM, free of charge. An interim notice was mailed to owners on November 7, 2016. The recall began on March 3, 2017. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-721.
16V656000 · 1,039 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014-2017 Freightliner M2 Business Class, 108 SD, 114 SD, Cascadia, Coronado, Western Star 4700, 4800, and 5700 XE trucks manufactured March 15, 2013, to July 29, 2016 and equipped with Conmet aluminum non-high capacity hubs. These vehicles specify a front axle weight limit that may be greater than that of the hub capacity. As a result, the hub may fail and the wheel may separate from the axle.
If a wheel separates from the axle, there would be an increased risk of a crash.
DTNA will notify owners, and dealers will replace the front axle hubs, free of charge. The recall began during November 2016. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-718.
16V634000 · 156 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2015-2016 Freightliner Cascadia trucks manufactured from March 24, 2014, through November 9, 2015. The affected vehicles are equipped with Bergstrom Parksmart HVAC auxiliary units. On these units, there may be inadequate contact between the electrical connector on the compressor and electrical pins causing a high electrical resistance resulting in excessive heat.
The overheated connection can increase the risk of a fire.
DTNA will notify owners, and dealers will replace the connector caps. Additionally, dealers will replace the harnesses if there is evidence of heat discoloration. These repairs will be performed free of charge. The recall began on May 12, 2016. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's recall number for this campaign is FL-703.
16V143000 · 8,865 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2013-2015 Freightliner Cascadia vehicles manufactured March 27, 2015, to November 4, 2014, and powered by compressed natural gas (CNG). The affected vehicles have a tailpipe that allows hot exhaust to exit near the CNG tank pressure relief device (PRD).
Hot exhaust in close proximity to the PRD may cause the PDR to activate and CNG to be unexpectedly released from the tank. Discharge of CNG in the presence of an ignition source can increase the risk of a fire.
All the vehicles involved in this recall campaign have been repaired. The recall is began on March 13, 2015. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-695.
15V816000 · 17 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America, LLC (DTNA) is recalling certain model year 2015-2016 Freightliner Cascadia, Business Class M2, 108SD, 114SD, and Western Star 4700 trucks manufactured January 4, 2015, to April 24, 2015, and equipped with Eaton Fuller FR 10-speed manual transmissions. In the affected vehicles, when the transmission shift lever is moved from reverse to neutral, the reverse gear may stay engaged. When the transmission shift lever is moved from reverse to a forward gear position, the transmission may mechanically lock because both the reverse gear and forward gear are simultaneously engaged.
Even though the transmission has been shifted out of reverse into neutral, the vehicle may unexpectedly move backwards, increasing the risk of a crash.
DTNA will notify owners, and dealers will inspect and repair the affected transmissions if necessary, free of charge. The recall began on November 24, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-693.
15V617000 · 14 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2015 Freightliner Cascadia, Business Class M2, 108SD, 114SD, 122SD, Coronado, Western Star 4700, and Western Star 4900 trucks manufactured October 6, 2014, to February 16, 2015, and equipped with Haldex Life Seal brake chambers. The affected vehicles may experience brake drag due to an improperly seated diaphragm in the brake chamber.
While traveling at highway speeds, brake drag may cause loss of vehicle control, increasing the risk of a crash.
DTNA will notify owners, and dealers will replace the brake chambers, free of charge. Owners were mailed interim notices at the end of May 2015. The recall began on September 25, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL676.
15V185000 · 3,732 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014-2015 Freightliner Cascadia trucks manufactured November 19, 2013, to July 14, 2014, and equipped with certain model Side-Mount compressed natural gas (CNG) Fuel Systems, Part No. 23736011, manufactured August 1, 2013, to August 21, 2014 and Motion Industries T1700-06 flexible fuel hoses. The stainless steel braid hose reinforcement may corrode prematurely near the fitting crimp inside the slave tank enclosure.
If the corrosion progresses and goes undetected, the hose could begin to leak CNG, increasing the risk of a fire in the presence of an ignition source.
DTNA will notify owners and dealers will replace the defective hose, free of charge. The recall began on April 1, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-678.
15V105000 · 14 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (Daimler) is recalling certain model year 2014-2015 Freightliner 122SD, Argosy, and Cascadia trucks manufactured July 22, 2013, to October 13, 2014, equipped with Wabco Quick Release Valves with Double Check manufactured February 6, 2013, to April 19, 2014. The affected vehicles may have been produced with a defective valve seat installed.
Improper seating can result in the valves improperly adjusting air pressure levels, thereby reducing the braking performance of the vehicles and increasing the risk of a crash.
Daimler will notify owners, and dealers will inspect, and replace the valves, free of charge. The recall began on December 30, 2015. Owners may contact Daimler customer service at 1-800-745-8000. Daimler's number for this recall is FL-673.
14V717000 · 2,618 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks of North America LLC (DTNA) is recalling certain model year 2011-2015 Freightliner Cascadia and M2 trucks manufactured June 2, 2011 to October 23, 2014. The vehicles are not in compliance with the requirements of the Federal Motor Vehicle Safety Standards No. 303, "Fuel System Integrity Of Compressed Natural Gas Vehicles." Specifically, the tail pipe on these vehicles terminates under the compressed natural gas (CNG) tank and can overheat the fuel system.
Due to the area of its placement, the exhaust system forces heat around, and may overheat, the fuel system components, increasing the risk of a vehicle fire.
DTNA will notify owners, and dealers will extend the tailpipe beyond the cabinet, free of charge. The recall began Feburary 12, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-671.
14V680000 · 65 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014-2015 Freightliner Cascadia vehicles manufactured May 5, 2014, to August 18, 2014. The affected vehicles are equipped with certain 1100W, 1500W, or 2000W inverters sold as a standalone option with both the Thermo King TriPac EVOLUTION and TriPac-e Auxiliary Power Units ("APU"). The Thermo King inverters provide 120V AC household power to a tractor cabin. The inverters may spark or overheat, resulting in a potential fire.
An inverter fire may result in a vehicle fire.
DTNA will notify owners, and Thermo King will either replace the inverter free of charge or refund the full purchase price. The recall began on November 14, 2014. Owners may contact Thermo King customer service at 1-866-766-2708. Owners may also contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-668.
14V588000 · 259 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2015 Freightliner Cascadia, 122SD, and Business Class M2 trucks manufactured March 20, 2014, through April 10, 2014. Due to an axle manufacturing error, there may be weak spots in the beam of the affected axle assemblies.
The axle weak spots could cause the axle beam to bend or cause wheel separation, increasing the risk of a crash.
DTNA will notify owners, and dealers will inspect the axle beams for certain manufacturing dates, and replace the ones manufactured within a certain date range, free of charge. The recall began on August 22, 2014. Owners may contact DTNA customer service at 1-800-385-4357. DTNA's number for this recall is FL-662.
14V367000 · 192 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (Daimler) is recalling certain model year 2008-2015 Freightliner 114SD, Cascadia, M2 Business Class, Sterling LT8500, and Thomas Built Buses Saf-T-Liner HDX vehicles manufactured February 19, 2008, through February 11, 2014, and equipped with Cummins Westport Model ISL G and Cummins Westport Model ISX12 G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
The sensor malfunction could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.
Cummins and Cummins Westport will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Customers may contact Daimler at 1-800-385-4357 or Cummins Inc. at 1-800-343-7357. Daimler's number for this recall is FL-660.
14V080000 · 3,258 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
2015 Freightliner Cascadia recall questions
Transport Canada lists 7 recalls for the 2015 Freightliner Cascadia model year. That counts campaigns naming this model year, not recalls on your vehicle: many cover only a VIN range or production window, and some only vehicles found on inspection. NHTSA lists 18 United States campaigns for the US-market model, shown separately; a US campaign may have no Canadian equivalent.
Enter your VIN in Freightliner's Canadian recall lookup, or call a Freightliner dealer with your VIN. In Canada the manufacturer is responsible for showing recall and repair status for each VIN, so its lookup is the authoritative answer. Cardog uses your VIN only to find the model year; the recalls shown here are listed for that model year and are not matched to your VIN.
Not necessarily. NHTSA campaigns cover vehicles sold in the United States, and NHTSA's VIN lookup has no Canadian data. When a defect also affects Canadian vehicles, the manufacturer files a separate notice with Transport Canada, often under a different number and sometimes covering a different set of vehicles. For a Canadian vehicle, go by the Transport Canada listing and Freightliner's Canadian lookup.
Safety recall repairs are normally done at no charge by an authorized Freightliner dealer. The manufacturer's notice for each campaign sets out the remedy and any conditions, so confirm with the dealer when you book.
Once Freightliner's lookup or a dealer confirms a recall applies, book the repair with an authorized Freightliner dealer and bring your VIN. If the manufacturer's notice says not to drive the vehicle or to park it outside, follow that instruction. Parts can take time, so book early.
Follow the manufacturer's notice for that recall. Most allow normal driving until the repair; some tell owners to stop driving or to park outside until it is fixed. Cardog does not grade recalls by severity: the manufacturer's notice and your dealer are the source.
Manufacturers must notify owners they have on record. If you bought the vehicle used or have moved, update your details with Freightliner Canada so notices reach you, and check the manufacturer's lookup from time to time.
Related recall checks
Compare recall listings with alternatives to the 2015 Freightliner Cascadia.