Newest first. Many cover only part of a model year, so check your VIN with Freightliner before booking a repair.
Transport Canada · listed for this model year
Issue: On certain trucks equipped with "Fleet Engineer" mud flaps, the bracket for the mud flaps may partially cover the rear reflective tape. Canadian regulations require that reflective tape must be visible on the rear of the truck. Safety Risk: Reflective tape that is covered may make the truck less visible to others and could create an increased risk of a crash. Corrective Actions: Daimler Trucks of North America (DTNA) will notify owners by mail and instruct you to take your truck to an authorized DTNA Service Facility to inspect the reflective tape. It will be moved as necessary to meet the regulations.
2020158 · 873 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles with air brakes, after several hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal. If the brake lights do not illuminate, following road users would be unaware of the intent of the driver to slow the vehicle, which could increase the risk of a crash causing injury and/or damage to property. Correction: Daimler Trucks North America authorized service facilities will repair the brake light pressure switch.
2017583 · 41,763 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles water intrusion could occur, and corrode and damage inside of the Signal-detect and Activation Module (SAM) Chassis. This corrosion could cause electrical shorts or intermittent operation of trailer tail lamps, trailer stop lamps, trailer side marker lamps and trailer lighting. Failure of the stop lamps to illuminate when the brakes are applied may result in following road users being unaware of the driver's intentions, increasing the risk of a crash causing property damage and/or personal injury. Also, under certain conditions, an electrical short in the Chassis SAM could also cause melting in the SAM or other electrical components, which could result in a vehicle fire. Correction: Dealers will inspect the Signal-detect and Activation Module (SAM) Chassis for evidence of corrosion and proper drip loop wire routing, and SAM Chassis damaged by corrosion will be replaced. A drip shield will be mounted inside the cab over the SAM chassis if not previously installed.
2015113 · 4,165 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, the air tank mounting brackets may crack, which could allow the tank to detach from the vehicle. An air tank separating from the vehicle could strike another vehicle, a stationary object, or a bystander. As well, loss of an air tank would cause a loss of service brakes, which could increase stopping distances, possibly causing a crash. These issues could result in property damage and/or personal injury. Correction: Dealers will replace the air tank mounting brackets.
2012281 · 147 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks equipped with a Detroit Diesel DD13, DD15 or DD16 engine, the support system for the high pressure fuel line (between the fuel pump and the fuel delivery rail) may be damaged during a service repair procedure. Incorrect torque applied to the dampener "P" clip fasteners may damage the fasteners, which could allow the clips to loosen. This could result in a cracked fuel line and a diesel fuel leak. Diesel fuel leakage may ignite on a hot engine surface and cause a fire. As well, diesel fuel spilt on the roadway could endanger other road users by making the roadway unexpectedly slippery. These issues could result in property damage and/or personal injury. Correction: Dealers will replace the high pressure fuel line and install a more robust fuel line support system.
2012080 · 11,923 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles equipped with an MBE4000 (EPA07) engine, the intake air grid heater may short circuit and fail. This could result in a vehicle fire causing property damage and/or personal injury. Correction: Dealers will install an additional external relay to prevent battery connection to the grid heater when the vehicle is not running and when grid heater control signal is absent.
2011411 · 1,412 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks equipped with a rack & pinion steering system, the lower pinion bearing may corrode and fail. As a result, the vehicle may require additional steering input while driving in a straight line. This could also cause a loss of steering power assist. These issues could ultimately result in property damage and/or personal injury. Correction: Dealers will inspect the rack and pinion gear assembly. If it passes the inspection, new bellows will be installed and grease added to the bottom pinion bearing. A steering gear that fails the inspection will be replaced.
2011367 · 1,457 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, specific operating conditions (such as tight, successive, highly banked curves in opposite directions), could trigger unintended Electronic Stability Control (ESC) system intervention. As a result, the ESC may unnecessarily apply one of the front brakes in order to correct the perceived oversteer condition. This may cause the vehicle to deviate from the intended path, thereby increasing the risk of a crash causing property damage and/or personal injury. Correction: Dealers will replace the ESC module.
2011346 · 1,027 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks equipped with a DD15 or DD16 engine, the bolt attaching a rubber isolator to a support bracket may become loose, back out, and contact the starter cable. This could cause an electrical short, which could result in a fire causing property damage and/or personal injury. Correction: Dealers will install a new bolt and isolator, and apply thread-locking fluid to the fastener.
2011236 · 5,924 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles equipped with a DD13 and DD15 engines, over time, the barrel of the Bosch high pressure fuel pump element may develop a crack due to hydrogen induced stress corrosion, which could result in a diesel fuel leak. Diesel fuel spilt on the roadway could endanger other road users by making the roadway unexpectedly slippery. Correction: Dealers will replace the high pressure fuel pump element with a more robust version.
2010250 · 1,008 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, should the fuel filter become restricted, the low pressure fuel flange may develop a crack resulting in a fuel leak. Fuel leakage, in the presence of an ignition source, could result in a fire causing property damage, personal injury or death. Correction: Dealers will replace the low pressure fuel flange with a more robust component.
2010144 · 3,194 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, the "LifeGuard RollTek" Advanced Occupant Protection System, designed to provide additional protection to vehicle occupants in the event of a vehicle rollover, may not have been properly installed, which could reduce its effectiveness. Reduced effectiveness of the Advanced Occupant Protection System may increase the risk of injury or death in the event of a vehicle rollover. Correction: Dealers will inspect and, if necessary, install additional retainers.
2010076 · 50 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, the engine grid heater may fail, which could result in a vehicle fire causing property damage, personal injury or death. Correction: Dealers will reprogram the engine control logic to provide cold weather starting without the need of a grid heater. Wiring to the grid heater will be removed.
2009294 · 1,802 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, the fasteners on the high pressure fuel pump may not have received adequate tightening torque - 23Nm instead of the required 43Nm. This could allow the O-ring between the pump housing and barrel to protrude and leak. Diesel fuel leakage may ignite on a hot engine surface and cause a fire, which could result in property damage, personal injury or death. As well, diesel fuel spilt on the roadway could endanger other road users. Correction: Dealers will inspect and, if necessary, either replace the fuel pump or tighten its fasteners .
2009288 · 339 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, the plastic low-pressure fuel line may fatigue crack and leak. Diesel fuel leakage may ignite on a hot engine surface and cause a fire, which could result in property damage, personal injury or death. As well, diesel fuel spilt on the roadway could endanger other road users. Correction: Dealers will replace the plastic low-pressure fuel line with a steel low-pressure line.
2009287 · 3,080 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, the left inner tie rod end may loosen and eventually separate from the steering rack. Tie rod failure could result in a loss of steering control and a crash, causing personal injury or death. Correction: Dealers will remove and inspect the left inner tie rod. Damaged steering racks will be replaced.
2009259 · 1,117 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, the Chassis and Cab Signal-detect and Activation Modules (SAMs) may suffer water intrusion, which could cause an electrical short or intermittent operation of tail lamps, stop lamps, side marker lamps and trailer lighting. Also, in some cases, the starter motor may activate without turning the ignition key. Failure or intermittent operation of certain lamps may result in the following road users being unaware of the driver's intentions, as well as reducing vehicle conspicuity during hours of darkness. Unintended activation of the starter in a vehicle equipped with a manual transmission may cause it to move. Both problems could result in a vehicle crash causing personal injury or death. An electrical short in the Cab SAM or Chassis SAM may cause and electrical short which could result in a vehicle fire. Correction: Dealers will inspect and, if required, replace the SAMs, and affect modifications to control possible sources of water intrusion.
2009009 · 1,161 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
United States records (NHTSA) · 24
These are NHTSA campaigns for 2009 Freightliner Cascadia vehicles sold in the United States. They are not Canadian recalls: NHTSA's VIN lookup has no Canadian data, and a US campaign may have no Canadian counterpart, or one under a different number covering different vehicles. For a vehicle sold in Canada, go by the Transport Canada listing above and Freightliner's Canadian VIN lookup.
Daimler Trucks North America LLC (DTNA) is recalling certain 2006-2020 Freightliner Columbia, 2006-2021 Freightliner Business Class M2, 2007-2020 Freightliner Coronado, 2014-2021 Freightliner 122 SD, 2007 Sterling A 9500, 2006 Freightliner Argosy, 2006-2007 Sterling AT9500, 2008-2021 Freightliner Cascadia, 2006-2008 Freightliner Classic, 2006-2011 Freightliner Century Class, 2006-2010 Freightliner FLD, and 2017 Western Star 5700 vehicles. The rear reflective tape may be partially covered by the mudflap hanger bracket, which may reduce the vehicle's visibility to other drivers on the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
The vehicle's rearward visibility may be reduced, increasing the risk of a crash.
DTNA will notify owners, and dealers will inspect and reposition the reflective tape to ensure that it is completely visible, as necessary, free of charge. The recall began May 29, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL848.
20V214000 · 63,175 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Freightliner Cascadia, Century Class, Columbia and Coronado trucks and Western Star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
DTNA will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on April 11, 2018. Owners may contact DTNA customer service at 1-800-547-0712, or contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.
17V810000 · 24,860 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America, LLC (DTNA) is recalling certain 2008-2018 Freightliner Cascadia, Western Star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.
DTNA will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on January 22, 2018. The recall began on May 9, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-756.
17V761000 · 438,255 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2007-2011 Freightliner Cascadia trucks manufactured March 26, 2007, to August 31, 2010. Water may leak into the Signal-detection and Activation Module (SAM) Chassis causing corrosion which may result in electrical shorts or possible intermittent operation of trailer lights.
Intermittent operation of the trailer lights may prevent other drivers from knowing that the truck is slowing or stopping, increasing the risk of a vehicle crash. Additionally, an electrical short in the SAM chassis may result in a a fire.
DTNA will notify owners, and dealers will inspect the SAM chassis for corrosion, replacing it as necessary. Any vehicle that does not have a drip shield mounted in the cab over the SAM chassis will receive one. These repairs will be performed free of charge. An interim letter was sent to owners on May 4, 2015. The recall began on October 8, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-679.
15V127000 · 45,036 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (Daimler) is recalling certain model year 2008-2015 Freightliner 114SD, Cascadia, M2 Business Class, Sterling LT8500, and Thomas Built Buses Saf-T-Liner HDX vehicles manufactured February 19, 2008, through February 11, 2014, and equipped with Cummins Westport Model ISL G and Cummins Westport Model ISX12 G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
The sensor malfunction could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.
Cummins and Cummins Westport will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Customers may contact Daimler at 1-800-385-4357 or Cummins Inc. at 1-800-343-7357. Daimler's number for this recall is FL-660.
14V080000 · 3,258 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America (DTNA) is recalling certain model year 2009-2012 Freightliner, Sterling, and Western Star vehicles manufactured from July 7, 2008, through December 15, 2011, and equipped with perpendicular air tank mounting brackets. The air tank mounting brackets may develop cracks which can lead to the air tank brackets separating from the frame rail. The air tanks may also separate from the vehicle.
Air tanks that become separated from a moving vehicle may create a road debris hazard, increasing the risk of a crash.
DTNA will notify owners, and dealers will replace the air mounting brackets, free of charge. The recall began on December 24, 2012. Owners may contact Daimler Trucks North America toll free at 1-800-547-0712.
12V405000 · 1,663 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006-2013 FREIGHTLINER, STERLING, AND WESTERN STAR VEHICLES, EQUIPPED WITH DETROIT DIESEL EPA07 AND EPA10, DD13 AND DD15/16 ENGINES, MANUFACTURED FROM JANUARY 20, 2006, THROUGH FEBRUARY 20, 2012. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.
A FUEL LEAK COULD CREATE A ROAD HAZARD, INCREASING THE RISK OF A CRASH. ALSO A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
DTNA WILL NOTIFY OWNERS, AND WHERE NECESSARY, THE HIGH PRESSURE FUEL LINE SUPPORT SYSTEM WILL BE REPLACED BY DTNA AUTHORIZED SERVICE FACILITIES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
12V074000 · 103,437 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2005-2011 FREIGHTLINER CASCADIA, COLUMBIA, CENTURY, CORONADO, AND CLASSIC XL TRUCKS MANUFACTURED FROM NOVEMBER 1, 2004, THROUGH JUNE 15, 2010 FOR THE RACK AND PINION STEERING SYSTEM. THE LOWER PINION BEARING MAY CORRODE AND FAIL. A FAILED BEARING MAY LEAD TO DAMAGE OF THE SPOOL VALVE SEALS. A DAMAGE SPOOL VALVE SEAL MAY ALLOW HYDRAULIC FLUID TO FLOW TO THE RIGHT OR LEFT TURN PORT INSTEAD OF FLOWING TO THE RETURN PORT.
THE STEERING COULD UNEXPECTEDLY TURN LEFT OR RIGHT, MAKING THE VEHICLE MORE DIFFICULT TO CONTROL AND INCREASING THE RISK OF A CRASH.
DAIMLER TRUCKS WILL INSPECT THE LOWER BEARING FOR CORROSION. IF CORROSION IS FOUND, THE RACK AND PINION SYSTEM WILL BE REPLACED. IF NO CORROSION IS FOUND, ON THE BEARING, THE BEARING WILL BE PACKED WITH GREASE AND THE RUBBER BELLOWS WILL BE REPLACED WITH SEALANT ADDED BETWEEN THE BELLOWS AND THE RACK HOUSING. AN INTERIM LETTER WAS MAILED IN DECEMBER 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
11V514000 · 9,689 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006-2012 FREIGHTLINER BUSINESS CLASS M2, CASCADIA, CENTURY, COLUMBIA, CORONADO AND STERLING A-LINE VEHICLES BUILT WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) SYSTEM MANUFACTURED FROM SEPTEMBER 15, 2005 THROUGH SEPTEMBER 1, 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.
IF THE DRIVER IS SLOW TO REACT DURING THIS ESC INTERVENTION, THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL INCREASING THE RISK OF A CRASH.
DAIMLER TRUCKS WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE ESC MODULE WITH THE APPROPRIATE SOFTWARE VERSION AS NECESSARY, FREE OF CHARGE. AN INTERIM OWNER NOTIFICATION WILL BE MAILED ON OR ABOUT NOVEMBER 21, 2011. THE DATE FOR AVAILABILITY OF THE FINAL REMEDY IS SUBJECT TO VALIDATION TESTING AND PARTS AVAILABILITY. THE SAFETY RECALL BEGAN ON MARCH 28, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
11V465000 · 4,444 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DTNA IS RECALLING CERTAIN MODEL YEAR 2008-2012 FREIGHTLINER; CASCADIA, CENTURY CLASS, COLUMBIA, AND CORONADO, CERTAIN MODEL YEAR 2008-2009 STERLING; A-LINE AND L-LINE AND CERTAIN MODEL YEAR 2009-2012 WESTERN STAR CONSTELLATION VEHICLES, MANUFACTURED FROM JANUARY 14, 2008, THROUGH JUNE 15, 2011, BUILT WITH DETROIT DIESEL 15 OR 16 ENGINES. THE BOLT ATTACHING A RUBBER ISOLATOR TO A SUPPORT BRACKET MAY BECOME LOOSE AND BACK OUT, POTENTIALLY CONTACTING AN UN-FUSED STARTER CABLE AND CREATING A SHORT CIRCUIT.
A SHORT CIRCUIT BETWEEN AN UN-FUSED BATTERY CABLE AND CHASSIS GROUND COULD RESULT IN A VEHICLE FIRE.
DEALERS WILL INSTALL A NEW BOLT AND ISOLATOR AND REPAIR THE RECREATIONAL VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 21, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
11V330000 · 48,170 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 FREIGHTLINER CASCADIA, CENTURY, COLUMBIA, CORONADO, M2, AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM FEBRUARY 19, 2009, THROUGH JULY 9, 2010, EQUIPPED WITH SPECIFIC DD13 AND DD15 ENGINES ASSEMBLED WITH A BOSCH HIGH PRESSURE FUEL PUMP ELEMENT WHICH MAY DEVELOP A CRACK DUE TO HYDROGEN INDUCED STRESS CORROSION. THE CRACK MAY RESULT IN A DIESEL FUEL LEAK.
IF A DIESEL FUEL LEAK CONTINUES UNDETECTED, FUEL MAY SPILL ONTO THE ROADWAY INCREASING THE RISK OF A CRASH.
DAIMLER TRUCKS WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES, FREE OF CHARGE. THIS RECALL IS AN EXPANSION OF A PREVIOUS RECALL (SEE RECALL CAMPAIGN 10V-339). THE SAFETY RECALL BEGAN ON MAY 18, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
11V287000 · 268 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 FREIGHTLINER, CASCADIA, CENTURY, COLUMBIA FLD, AND M2, STERLING 9500, AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM MARCH 20, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE4000 EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.
A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
DTNA WILL NOTIFY OWNERS OF THE RECALL DURING MARCH 2011. ANOTHER NOTIFICATION WILL BE ISSUED ONCE THE REMEDY IS RELEASED. DTNA EXPECTS THE REMEDY TO BE AVAILABLE BY DECEMBER 1, 2011. REPAIRS WILL BE PERFORMED BY DTNA DEALERS FREE OF CHARGE. OWNERS MAY CONTACT DTNA TOLL-FREE AT 1-800-547-0712. THIS RECALL IS ASSCOCIATED WITH A PREVIOUS RECALL, CAMPAIGN NUMBER 10V-341.
11V146000 · 2,073 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 FREIGHTLINER, FCCC, STERLING, AND WESTERN STAR HEAVY TRUCKS MANUFACTURED FROM SEPTEMBER 5, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.
A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 29, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
10V341000 · 5,743 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 FREIGHTLINER CASCADIA, CENTURY, COLUMBIA, CORONADO, M2, AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM FEBRUARY 19, 2009 THROUGH JULY 9, 2010, EQUIPPED WITH SPECIFIC DD13 AND DD15 ENGINES ASSEMBLED WITH A BOSCH HIGH PRESSURE FUEL PUMP ELEMENT WHICH MAY DEVELOP A CRACK DUE TO HYDROGEN INDUCED STRESS CORROSION. OVER TIME THE BARREL OF THE BOSCH HIGH PRESSURE FUEL PUMP ELEMENT USED ON SPECIFIC DD13/DD15 ENGINES MAY DEVELOP A CRACK DUE TO HYDROGEN INDUCED STRESS CORROSION RESULTING IN A DIESEL FUEL LEAK.
IF A DIESEL FUEL LEAK CONTINUES UNDETECTED, FUEL MAY SPILL ONTO THE ROADWAY POTENTIALLY RESULTING IN A CRASH.
DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 28, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
10V339000 · 13,410 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FREIGHTLINER COLUMBIA, CASCADIA, CORONADO, CENTURY, M2, STERLING 9500, AND WESTERN STAR 4900 VEHICLES EQUIPPED WITH DD 13 AND DD15/DD16 ENGINES AND MANUFACTURED FROM JANUARY 1, 2007 THROUGH APRIL 5, 2010. SHOULD THE FUEL FILTER BECOME RESTRICTED, THE LOW PRESSURE FUEL FLANGE MAY DEVELOP A CRACK RESULTING IN A FUEL LEAK.
FUEL LEAKING ONTO THE ROADWAY MAY RESULT IN VEHICLE CRASH.
THE LOW PRESSURE FUEL FLANGE WILL BE REPLACED WITH A MORE ROBUST COMPONENT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 17, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
10V189000 · 30,704 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2008 THROUGH 2010 CASCADIA EQUIPPED WITH LIFEGUARD ROLLTEK ADVANCED OCCUPANT PROTECTION SYSTEM. THE LIFEGUARD ROLLTEK IS DESIGNED TO PROVIDE ADDITIONAL PROTECTION TO VEHICLE OCCUPANTS IN THE EVENT OF A ROLLOVER ACCIDENT AND IT MAY NOT HAVE BEEN PROPERLY INSTALLED.
REDUCED EFFECTIVENESS OF THE ADVANCED OCCUPANT PROTECTION SYSTEM MAY INCREASE THE RISK OF INJURY.
DEALERS WILL INSPECT AND INSTALL AN ADDITIONAL RETAINERS TO ENSURE THE SYSTEM REMAINS FULLY FUNCTIONAL. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 4, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
10V102000 · 490 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING MODEL YEAR 2009-2010 FREIGHTLINER, AND STERLING VEHICLES EQUIPPED DETROIT DIESEL DD13 EPA07 ENGINES WHICH WERE MANUFACTURED WITH GRID HEATERS. INCREASED INTERNAL GRID HEATER RESISTANCE CAUSED BY IMPROPERLY TIGHTENED SCREWS MAY MELT THE SOLDER ON THE GRID HEATER CIRCUIT BOARD LEADING TO A SHORT CIRCUIT.
A SHORT CIRCUIT COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
DETROIT DIESEL WILL REPAIR VEHICLES FREE OF CHARGE. THE ENGINE CONTROL LOGIC WILL BE REPROGRAMMED TO PROVIDE COLD WEATHER STARTING WITHOUT THE NEED OF A GRID HEATER. WIRING TO THE GRID HEATER WILL BE REMOVED. THE SAFETY RECALLBEGAN ON DECEMBER 18, 2009. OWNERS MAY CONTACT DETROIT DIESEL AT 1-313-592-5800 OR DAIMLER TRUCKS AT 1-800-547-0712.
09V428000 · 1,726 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING MODEL YEAR 2007-2010 FREIGHTLINER, STERLING AND WESTERN STAR VEHICLES EQUIPPED WITH DETROIT DIESEL DD15 EPA07 ENGINES WHICH WERE MANUFACTURED WITH GRID HEATERS. INCREASED INTERNAL GRID HEATER RESISTANCE CAUSED BY IMPROPERLY TIGHTENED SCREWS MAY MELT THE SOLDER ON THE GRID HEATER CIRCUIT BOARD LEADING TO A SHORT CIRCUIT.
A SHORT-CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
THE ENGINE CONTROL LOGIC WILL BE REPROGRAMMED FREE OF CHARGE BY DETROIT DIESEL AUTHORIZED REPAIR FACILITIES AND DIRECT WARRANTY CUSTOMERS TO PROVIDE COLD WEATHER STARTING WITHOUT THE NEED OF A GRID HEATER. THE SAFETY RECALL BEGAN ON NOVEMBER 4, 2009. OWNERS MAY CONTACT DETROIT DIESEL AT 1-313-592-5800 AND DAIMLER TRUCKS AT 1-800-547-0712.
09V400000 · 18,067 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 HEAVY TRUCKS MANUFACTURED BETWEEN JANUARY 17, 2006 AND MARCH 31, 2009, EQUIPPED WITH EPA07 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES. THE PLASTIC LINES MAY EXPERIENCE LEAKS DUE TO FATIGUE CRACKS CAUSED BY STRESS AND VIBRATION COMBINED WITH HIGH INTERNAL PRESSURE.
IF A DIESEL FUEL LEAK CONTINUES UNDETECTED UNDER CERTAIN CONDITIONS FUEL MAY IGNITE ON A HOT ENGINE SURFACE AND/OR FUEL MAY SPILL ON THE ROAD INCREASING THE RISK OF A CRASH.
DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES AND DIRECT WARRANTY CUSTOMERS. THE SAFETY RECALL BEGAN ON MAY 7, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
09V391000 · 10,185 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 HEAVY TRUCKS MANUFACTURED BETWEEN MAY 5, 2008 AND JANUARY 7, 2009, EQUIPPED DD15 ENGINES AND WITH BOSCH HIGH PRESSURE FUEL PUMPS. THE FASTENERS ON THESE FUEL PUMPS COULD BE UNDER-TORQUED ALLOWING THE "O" RING BETWEEN THE PUMP HOUSING AND THE BARREL TO PROTRUDE AND LEAK.
IF A DIESEL FUEL LEAK CONTINUES UNDETECTED UNDER CERTAIN CONDITIONS FUEL MAY IGNITE ON A HOT ENGINE SURFACE AND/OR FUEL MAY SPILL ON THE ROAD INCREASING THE RISK OF A CRASH.
DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES AND DIRECT WARRANTY CUSTOMERS. THE SAFETY RECALL BEGAN ON DECEMBER 22, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
09V390000 · 2,726 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2009 TRUCKS EQUIPPED WITH INDIANA MILLS AND MANUFACTURING ROLLTEK SIDE-ROLL PROTECTION SYSTEMS. THE SENSOR DESIGNED TO DETECT VEHICLE ROLL CAN MALFUNCTION AND CAUSE THE SIDE AIRBAGS TO INADVERTENTLY DEPLOY.
INADVERTENT DEPLOYMENT OF THE SIDE AIRBAGS COULD RESULT IN A VEHICLE CRASH OR INJURY TO AN OUT OF POSITION OCCUPANT.
DAIMLER TRUCKS WILL INSPECT TO DETERMINE IF A VEHICLE CONTAINS AN AFFECTED SYSTEM AND, IF SO, THAT SYSTEM WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE NOVEMBER 20, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
09V376000 · 14 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2010 HEAVY DUTY TRUCKS MANUFACTURED FROM OCTOBER 29, 2005 THROUGH JULY 3, 2009. UNDER CERTAIN CONDITION, THE LEFT HAND INNER TIE ROD END MAY LOOSEN OVER TIME AND IF NOT CORRECTED, POTENTIALLY SEPARATE FROM THE STEERING RACK.
A SEPARATED TIE ROD ASSEMBLY CAN RESULT IN LOSS OF VEHICLE CONTROL AT HIGHER SPEEDS AND A CRASH COULD OCCUR.
DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 5, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
09V357000 · 8,882 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING 1,460 MODEL YEAR 2009 AND 2010 HEAVY DUTY TRUCKS AND FCCC CHASSIS (USED ON THOMAS BUILT SCHOOL BUSES) MANUFACTURED FROM JUNE 11 THROUGH DECEMBER 16, 2008, EQUIPPED WITH CERTAIN HALDEX QUICK RELEASE VALVES (QRV). THE RUBBER DIAPHRAGM INSIDE THE QRV MAY EXPERIENCE DELAMINATION RESULTING IN SIGNIFICANT LEVELS OF AIR PRESSURE LEAKAGE PAST AND/OR THROUGH THE DIAPHRAGM, OR THE DEVELOPMENT OF A BUBBLE IN THE DIAPHRAGM WHICH MAY TRAP AIR PRESSURE IN THE VALVE AND NOT ALLOW THE SERVICE BRAKES TO RELEASE.
MALFUNCTION OF THE AIR BRAKE SYSTEM COULD RESULT IN A VEHICLE CRASH.
DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DAIMLER TRUCKS NORTH AMERICA. THE SAFETY RECALL BEGAN ON AUGUST 12, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
09V220000 · 1,460 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING 14181 MY 2007-2009 FREIGHTLINER CASCADIA TRUCKS EQUIPPED WITH CAB SIGNAL-DETECT AND ACTIVATION MODULES (SAMS). POTENTIAL CORROSION DAMAGE DUE TO WATER INTRUSION INTO THE SAMS MAY CAUSE ELECTRICAL SHORTS OR INTERMITTENT OPERATION OF TAIL LAMPS, STOP LAMPS, SIDE MARKER LAMPS AND TRAILER LIGHTING. IN SOME CASES STARTER MOTORS HAVE ACTIVATED WITHOUT A KEY ON.
AN ELECTRICAL SHORT IN THE CAB SAM OR CHASSIS SAM MAY CAUSE MELTING IN THE SAM OR OTHER ELECTRICAL COMPONENTS WHICH MAY CAUSE A VEHICLE FIRE.
DEALERS WILL INSPECT FOR INDICATION OF WATER INTRUSION OR DAMAGE TO THE SAMS. SAMS WILL BE REPLACED AS REQUIRED AND MODIFICATIONS WILL BE COMPLETED TO CONTROL POSSIBLE SOURCES OF WATER INTRUSION. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 13, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
09V024000 · 14,181 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
2009 Freightliner Cascadia recall questions
Transport Canada lists 17 recalls for the 2009 Freightliner Cascadia model year. That counts campaigns naming this model year, not recalls on your vehicle: many cover only a VIN range or production window, and some only vehicles found on inspection. NHTSA lists 24 United States campaigns for the US-market model, shown separately; a US campaign may have no Canadian equivalent.
Enter your VIN in Freightliner's Canadian recall lookup, or call a Freightliner dealer with your VIN. In Canada the manufacturer is responsible for showing recall and repair status for each VIN, so its lookup is the authoritative answer. Cardog uses your VIN only to find the model year; the recalls shown here are listed for that model year and are not matched to your VIN.
Not necessarily. NHTSA campaigns cover vehicles sold in the United States, and NHTSA's VIN lookup has no Canadian data. When a defect also affects Canadian vehicles, the manufacturer files a separate notice with Transport Canada, often under a different number and sometimes covering a different set of vehicles. For a Canadian vehicle, go by the Transport Canada listing and Freightliner's Canadian lookup.
Safety recall repairs are normally done at no charge by an authorized Freightliner dealer. The manufacturer's notice for each campaign sets out the remedy and any conditions, so confirm with the dealer when you book.
Once Freightliner's lookup or a dealer confirms a recall applies, book the repair with an authorized Freightliner dealer and bring your VIN. If the manufacturer's notice says not to drive the vehicle or to park it outside, follow that instruction. Parts can take time, so book early.
Follow the manufacturer's notice for that recall. Most allow normal driving until the repair; some tell owners to stop driving or to park outside until it is fixed. Cardog does not grade recalls by severity: the manufacturer's notice and your dealer are the source.
Manufacturers must notify owners they have on record. If you bought the vehicle used or have moved, update your details with Freightliner Canada so notices reach you, and check the manufacturer's lookup from time to time.
Related recall checks
Compare recall listings with alternatives to the 2009 Freightliner Cascadia.