Newest first. Many cover only part of a model year, so check your VIN with Freightliner before booking a repair.
Transport Canada · listed for this model year
Issue: On certain trucks equipped with "Fleet Engineer" mud flaps, the bracket for the mud flaps may partially cover the rear reflective tape. Canadian regulations require that reflective tape must be visible on the rear of the truck. Safety Risk: Reflective tape that is covered may make the truck less visible to others and could create an increased risk of a crash. Corrective Actions: Daimler Trucks of North America (DTNA) will notify owners by mail and instruct you to take your truck to an authorized DTNA Service Facility to inspect the reflective tape. It will be moved as necessary to meet the regulations.
2020158 · 873 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles with air brakes, after several hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal. If the brake lights do not illuminate, following road users would be unaware of the intent of the driver to slow the vehicle, which could increase the risk of a crash causing injury and/or damage to property. Correction: Daimler Trucks North America authorized service facilities will repair the brake light pressure switch.
2017583 · 41,763 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles water intrusion could occur, and corrode and damage inside of the Signal-detect and Activation Module (SAM) Chassis. This corrosion could cause electrical shorts or intermittent operation of trailer tail lamps, trailer stop lamps, trailer side marker lamps and trailer lighting. Failure of the stop lamps to illuminate when the brakes are applied may result in following road users being unaware of the driver's intentions, increasing the risk of a crash causing property damage and/or personal injury. Also, under certain conditions, an electrical short in the Chassis SAM could also cause melting in the SAM or other electrical components, which could result in a vehicle fire. Correction: Dealers will inspect the Signal-detect and Activation Module (SAM) Chassis for evidence of corrosion and proper drip loop wire routing, and SAM Chassis damaged by corrosion will be replaced. A drip shield will be mounted inside the cab over the SAM chassis if not previously installed.
2015113 · 4,165 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks equipped with a Detroit Diesel DD13, DD15 or DD16 engine, the support system for the high pressure fuel line (between the fuel pump and the fuel delivery rail) may be damaged during a service repair procedure. Incorrect torque applied to the dampener "P" clip fasteners may damage the fasteners, which could allow the clips to loosen. This could result in a cracked fuel line and a diesel fuel leak. Diesel fuel leakage may ignite on a hot engine surface and cause a fire. As well, diesel fuel spilt on the roadway could endanger other road users by making the roadway unexpectedly slippery. These issues could result in property damage and/or personal injury. Correction: Dealers will replace the high pressure fuel line and install a more robust fuel line support system.
2012080 · 11,923 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles equipped with an MBE4000 (EPA07) engine, the intake air grid heater may short circuit and fail. This could result in a vehicle fire causing property damage and/or personal injury. Correction: Dealers will install an additional external relay to prevent battery connection to the grid heater when the vehicle is not running and when grid heater control signal is absent.
2011411 · 1,412 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks equipped with a rack & pinion steering system, the lower pinion bearing may corrode and fail. As a result, the vehicle may require additional steering input while driving in a straight line. This could also cause a loss of steering power assist. These issues could ultimately result in property damage and/or personal injury. Correction: Dealers will inspect the rack and pinion gear assembly. If it passes the inspection, new bellows will be installed and grease added to the bottom pinion bearing. A steering gear that fails the inspection will be replaced.
2011367 · 1,457 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, specific operating conditions (such as tight, successive, highly banked curves in opposite directions), could trigger unintended Electronic Stability Control (ESC) system intervention. As a result, the ESC may unnecessarily apply one of the front brakes in order to correct the perceived oversteer condition. This may cause the vehicle to deviate from the intended path, thereby increasing the risk of a crash causing property damage and/or personal injury. Correction: Dealers will replace the ESC module.
2011346 · 1,027 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, the plastic low-pressure fuel line between the engine-mounted fuel filter and the engine block may develop a diesel fuel leak. The location of the leak is unlikely to result in a vehicle fire; however, diesel fuel spilt on the roadway could endanger other road users by making the roadway unexpectedly slippery. This could ultimately result in a vehicle crash causing property damage and/or personal injury. Correction: Dealers will replace the plastic low-pressure fuel line with a steel version.
2011345 · 12,000 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks equipped with a DD15 or DD16 engine, the bolt attaching a rubber isolator to a support bracket may become loose, back out, and contact the starter cable. This could cause an electrical short, which could result in a fire causing property damage and/or personal injury. Correction: Dealers will install a new bolt and isolator, and apply thread-locking fluid to the fastener.
2011236 · 5,924 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, should the fuel filter become restricted, the low pressure fuel flange may develop a crack resulting in a fuel leak. Fuel leakage, in the presence of an ignition source, could result in a fire causing property damage, personal injury or death. Correction: Dealers will replace the low pressure fuel flange with a more robust component.
2010144 · 3,194 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, the "LifeGuard RollTek" Advanced Occupant Protection System, designed to provide additional protection to vehicle occupants in the event of a vehicle rollover, may not have been properly installed, which could reduce its effectiveness. Reduced effectiveness of the Advanced Occupant Protection System may increase the risk of injury or death in the event of a vehicle rollover. Correction: Dealers will inspect and, if necessary, install additional retainers.
2010076 · 50 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, the engine grid heater may fail, which could result in a vehicle fire causing property damage, personal injury or death. Correction: Dealers will reprogram the engine control logic to provide cold weather starting without the need of a grid heater. Wiring to the grid heater will be removed.
2009294 · 1,802 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, the plastic low-pressure fuel line may fatigue crack and leak. Diesel fuel leakage may ignite on a hot engine surface and cause a fire, which could result in property damage, personal injury or death. As well, diesel fuel spilt on the roadway could endanger other road users. Correction: Dealers will replace the plastic low-pressure fuel line with a steel low-pressure line.
2009287 · 3,080 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, the side-roll sensor - designed to detect vehicle pitch and control deployment of the system's seatbelt pretensioner and side airbag - may have been manufactured incorrectly. A failure of the sensor could be interpreted by the side-roll protection system as a vehicle roll, resulting in an inadvertent deployment of the seatbelt pretensioner and lateral airbags. In some instances, inadvertent deployment could cause injuries to vehicle occupants. Correction: Dealers will inspect and, if required, replace the side-roll sensor.
2009271 · 5 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, the left inner tie rod end may loosen and eventually separate from the steering rack. Tie rod failure could result in a loss of steering control and a crash, causing personal injury or death. Correction: Dealers will remove and inspect the left inner tie rod. Damaged steering racks will be replaced.
2009259 · 1,117 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, the Chassis and Cab Signal-detect and Activation Modules (SAMs) may suffer water intrusion, which could cause an electrical short or intermittent operation of tail lamps, stop lamps, side marker lamps and trailer lighting. Also, in some cases, the starter motor may activate without turning the ignition key. Failure or intermittent operation of certain lamps may result in the following road users being unaware of the driver's intentions, as well as reducing vehicle conspicuity during hours of darkness. Unintended activation of the starter in a vehicle equipped with a manual transmission may cause it to move. Both problems could result in a vehicle crash causing personal injury or death. An electrical short in the Cab SAM or Chassis SAM may cause and electrical short which could result in a vehicle fire. Correction: Dealers will inspect and, if required, replace the SAMs, and affect modifications to control possible sources of water intrusion.
2009009 · 1,161 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Certain vehicles may have been assembled with an incorrectly manufactured Bendix MV-3 dash control valve. If the double check valve becomes lodged, in the event of a primary reservoir failure, air pressure can leak past the lodged valve, thereby depleting the secondary reservoir, causing a reduced ability for modulating the emergency brakes. Extended stopping distances may result in a vehicle crash, causing property damage, and/or personal injury or death. Correction: Dealers will inspect and, if necessary, replace the dash control valve.
2008109 · 81 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain vehicles, incorrect fasteners may have been used to attached the brake caliper to the brake anchor plate during vehicle assembly. The incorrect fasteners may not provide adequate clamping force, potentially resulting in reduced brake effectiveness. Extended stopping distances may result in a vehicle crash causing injury or death. Correction: Dealers will inspect and, if incorrect bolts are found, will check for possible additional damage, and repair as required.
2008014 · 43 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, an incorrectly manufactured steering gear sector shaft may cause the steering to "stick or bind". This could severely restrict the steering turning angle, possibly resulting in a vehicle crash with injury or death. Correction: Dealers will replace the steering gear assembly.
2007411 · 255 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
On certain trucks, the fifth wheel hitch assembly's lever arm may have been incorrectly installed during the manufacturing process. The lever arm pivot bolt may have been over-tightened which could distort the pivot bolt spacer sleeve and prevent the fifth wheel latch jaw from closing and latching securely around the trailer king pin. This could allow the towed unit to separate from the towing vehicle while underway, potentially causing a crash with injury or death. Correction: Dealers will replace the pivot bolt and sleeve with a hex head shoulder bolt and washer.
2007359 · 1,063 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
United States records (NHTSA) · 22
These are NHTSA campaigns for 2008 Freightliner Cascadia vehicles sold in the United States. They are not Canadian recalls: NHTSA's VIN lookup has no Canadian data, and a US campaign may have no Canadian counterpart, or one under a different number covering different vehicles. For a vehicle sold in Canada, go by the Transport Canada listing above and Freightliner's Canadian VIN lookup.
Daimler Trucks North America LLC (DTNA) is recalling certain 2006-2020 Freightliner Columbia, 2006-2021 Freightliner Business Class M2, 2007-2020 Freightliner Coronado, 2014-2021 Freightliner 122 SD, 2007 Sterling A 9500, 2006 Freightliner Argosy, 2006-2007 Sterling AT9500, 2008-2021 Freightliner Cascadia, 2006-2008 Freightliner Classic, 2006-2011 Freightliner Century Class, 2006-2010 Freightliner FLD, and 2017 Western Star 5700 vehicles. The rear reflective tape may be partially covered by the mudflap hanger bracket, which may reduce the vehicle's visibility to other drivers on the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
The vehicle's rearward visibility may be reduced, increasing the risk of a crash.
DTNA will notify owners, and dealers will inspect and reposition the reflective tape to ensure that it is completely visible, as necessary, free of charge. The recall began May 29, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL848.
20V214000 · 63,175 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Freightliner Cascadia, Century Class, Columbia and Coronado trucks and Western Star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
DTNA will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on April 11, 2018. Owners may contact DTNA customer service at 1-800-547-0712, or contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.
17V810000 · 24,860 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America, LLC (DTNA) is recalling certain 2008-2018 Freightliner Cascadia, Western Star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.
DTNA will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on January 22, 2018. The recall began on May 9, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-756.
17V761000 · 438,255 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2007-2011 Freightliner Cascadia trucks manufactured March 26, 2007, to August 31, 2010. Water may leak into the Signal-detection and Activation Module (SAM) Chassis causing corrosion which may result in electrical shorts or possible intermittent operation of trailer lights.
Intermittent operation of the trailer lights may prevent other drivers from knowing that the truck is slowing or stopping, increasing the risk of a vehicle crash. Additionally, an electrical short in the SAM chassis may result in a a fire.
DTNA will notify owners, and dealers will inspect the SAM chassis for corrosion, replacing it as necessary. Any vehicle that does not have a drip shield mounted in the cab over the SAM chassis will receive one. These repairs will be performed free of charge. An interim letter was sent to owners on May 4, 2015. The recall began on October 8, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-679.
15V127000 · 45,036 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
Daimler Trucks North America LLC (Daimler) is recalling certain model year 2008-2015 Freightliner 114SD, Cascadia, M2 Business Class, Sterling LT8500, and Thomas Built Buses Saf-T-Liner HDX vehicles manufactured February 19, 2008, through February 11, 2014, and equipped with Cummins Westport Model ISL G and Cummins Westport Model ISX12 G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
The sensor malfunction could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.
Cummins and Cummins Westport will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Customers may contact Daimler at 1-800-385-4357 or Cummins Inc. at 1-800-343-7357. Daimler's number for this recall is FL-660.
14V080000 · 3,258 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006-2013 FREIGHTLINER, STERLING, AND WESTERN STAR VEHICLES, EQUIPPED WITH DETROIT DIESEL EPA07 AND EPA10, DD13 AND DD15/16 ENGINES, MANUFACTURED FROM JANUARY 20, 2006, THROUGH FEBRUARY 20, 2012. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.
A FUEL LEAK COULD CREATE A ROAD HAZARD, INCREASING THE RISK OF A CRASH. ALSO A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
DTNA WILL NOTIFY OWNERS, AND WHERE NECESSARY, THE HIGH PRESSURE FUEL LINE SUPPORT SYSTEM WILL BE REPLACED BY DTNA AUTHORIZED SERVICE FACILITIES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
12V074000 · 103,437 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2005-2011 FREIGHTLINER CASCADIA, COLUMBIA, CENTURY, CORONADO, AND CLASSIC XL TRUCKS MANUFACTURED FROM NOVEMBER 1, 2004, THROUGH JUNE 15, 2010 FOR THE RACK AND PINION STEERING SYSTEM. THE LOWER PINION BEARING MAY CORRODE AND FAIL. A FAILED BEARING MAY LEAD TO DAMAGE OF THE SPOOL VALVE SEALS. A DAMAGE SPOOL VALVE SEAL MAY ALLOW HYDRAULIC FLUID TO FLOW TO THE RIGHT OR LEFT TURN PORT INSTEAD OF FLOWING TO THE RETURN PORT.
THE STEERING COULD UNEXPECTEDLY TURN LEFT OR RIGHT, MAKING THE VEHICLE MORE DIFFICULT TO CONTROL AND INCREASING THE RISK OF A CRASH.
DAIMLER TRUCKS WILL INSPECT THE LOWER BEARING FOR CORROSION. IF CORROSION IS FOUND, THE RACK AND PINION SYSTEM WILL BE REPLACED. IF NO CORROSION IS FOUND, ON THE BEARING, THE BEARING WILL BE PACKED WITH GREASE AND THE RUBBER BELLOWS WILL BE REPLACED WITH SEALANT ADDED BETWEEN THE BELLOWS AND THE RACK HOUSING. AN INTERIM LETTER WAS MAILED IN DECEMBER 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
11V514000 · 9,689 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2008 HEAVY TRUCKS MANUFACTURED FROM JULY 11, 2003, THROUGH SEPTEMBER 28, 2007, EQUIPPED WITH EPA04 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES AND FUEL FILTERS MOUNTED NEAR THE CENTER OF THE ENGINE ON THE LEFT-HAND SIDE. THE PLASTIC LOW PRESSURE FUEL LINE BETWEEN ENGINE MOUNTED FUEL FILTER AND ENGINE BLOCK MAY DEVELOP A SUBSTANTIAL DIESEL FUEL LEAK.
THIS COULD CREATE A ROAD HAZARD INCREASING THE RISK OF A CRASH. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. VEHICLES WILL BE INSPECTED AND THE PLASTIC LOW PRESSURE FUEL LINE WILL BE REPLACED WITH A STEEL LOW PRESSURE FUEL LINE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON OCTOBER 28, 2011. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
11V478000 · 73,500 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006-2012 FREIGHTLINER BUSINESS CLASS M2, CASCADIA, CENTURY, COLUMBIA, CORONADO AND STERLING A-LINE VEHICLES BUILT WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) SYSTEM MANUFACTURED FROM SEPTEMBER 15, 2005 THROUGH SEPTEMBER 1, 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.
IF THE DRIVER IS SLOW TO REACT DURING THIS ESC INTERVENTION, THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL INCREASING THE RISK OF A CRASH.
DAIMLER TRUCKS WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE ESC MODULE WITH THE APPROPRIATE SOFTWARE VERSION AS NECESSARY, FREE OF CHARGE. AN INTERIM OWNER NOTIFICATION WILL BE MAILED ON OR ABOUT NOVEMBER 21, 2011. THE DATE FOR AVAILABILITY OF THE FINAL REMEDY IS SUBJECT TO VALIDATION TESTING AND PARTS AVAILABILITY. THE SAFETY RECALL BEGAN ON MARCH 28, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
11V465000 · 4,444 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DTNA IS RECALLING CERTAIN MODEL YEAR 2008-2012 FREIGHTLINER; CASCADIA, CENTURY CLASS, COLUMBIA, AND CORONADO, CERTAIN MODEL YEAR 2008-2009 STERLING; A-LINE AND L-LINE AND CERTAIN MODEL YEAR 2009-2012 WESTERN STAR CONSTELLATION VEHICLES, MANUFACTURED FROM JANUARY 14, 2008, THROUGH JUNE 15, 2011, BUILT WITH DETROIT DIESEL 15 OR 16 ENGINES. THE BOLT ATTACHING A RUBBER ISOLATOR TO A SUPPORT BRACKET MAY BECOME LOOSE AND BACK OUT, POTENTIALLY CONTACTING AN UN-FUSED STARTER CABLE AND CREATING A SHORT CIRCUIT.
A SHORT CIRCUIT BETWEEN AN UN-FUSED BATTERY CABLE AND CHASSIS GROUND COULD RESULT IN A VEHICLE FIRE.
DEALERS WILL INSTALL A NEW BOLT AND ISOLATOR AND REPAIR THE RECREATIONAL VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 21, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
11V330000 · 48,170 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 FREIGHTLINER, CASCADIA, CENTURY, COLUMBIA FLD, AND M2, STERLING 9500, AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM MARCH 20, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE4000 EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.
A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
DTNA WILL NOTIFY OWNERS OF THE RECALL DURING MARCH 2011. ANOTHER NOTIFICATION WILL BE ISSUED ONCE THE REMEDY IS RELEASED. DTNA EXPECTS THE REMEDY TO BE AVAILABLE BY DECEMBER 1, 2011. REPAIRS WILL BE PERFORMED BY DTNA DEALERS FREE OF CHARGE. OWNERS MAY CONTACT DTNA TOLL-FREE AT 1-800-547-0712. THIS RECALL IS ASSCOCIATED WITH A PREVIOUS RECALL, CAMPAIGN NUMBER 10V-341.
11V146000 · 2,073 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 FREIGHTLINER, FCCC, STERLING, AND WESTERN STAR HEAVY TRUCKS MANUFACTURED FROM SEPTEMBER 5, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.
A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 29, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
10V341000 · 5,743 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FREIGHTLINER COLUMBIA, CASCADIA, CORONADO, CENTURY, M2, STERLING 9500, AND WESTERN STAR 4900 VEHICLES EQUIPPED WITH DD 13 AND DD15/DD16 ENGINES AND MANUFACTURED FROM JANUARY 1, 2007 THROUGH APRIL 5, 2010. SHOULD THE FUEL FILTER BECOME RESTRICTED, THE LOW PRESSURE FUEL FLANGE MAY DEVELOP A CRACK RESULTING IN A FUEL LEAK.
FUEL LEAKING ONTO THE ROADWAY MAY RESULT IN VEHICLE CRASH.
THE LOW PRESSURE FUEL FLANGE WILL BE REPLACED WITH A MORE ROBUST COMPONENT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 17, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
10V189000 · 30,704 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2008 THROUGH 2010 CASCADIA EQUIPPED WITH LIFEGUARD ROLLTEK ADVANCED OCCUPANT PROTECTION SYSTEM. THE LIFEGUARD ROLLTEK IS DESIGNED TO PROVIDE ADDITIONAL PROTECTION TO VEHICLE OCCUPANTS IN THE EVENT OF A ROLLOVER ACCIDENT AND IT MAY NOT HAVE BEEN PROPERLY INSTALLED.
REDUCED EFFECTIVENESS OF THE ADVANCED OCCUPANT PROTECTION SYSTEM MAY INCREASE THE RISK OF INJURY.
DEALERS WILL INSPECT AND INSTALL AN ADDITIONAL RETAINERS TO ENSURE THE SYSTEM REMAINS FULLY FUNCTIONAL. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 4, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
10V102000 · 490 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING MODEL YEAR 2007-2010 FREIGHTLINER, STERLING AND WESTERN STAR VEHICLES EQUIPPED WITH DETROIT DIESEL DD15 EPA07 ENGINES WHICH WERE MANUFACTURED WITH GRID HEATERS. INCREASED INTERNAL GRID HEATER RESISTANCE CAUSED BY IMPROPERLY TIGHTENED SCREWS MAY MELT THE SOLDER ON THE GRID HEATER CIRCUIT BOARD LEADING TO A SHORT CIRCUIT.
A SHORT-CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
THE ENGINE CONTROL LOGIC WILL BE REPROGRAMMED FREE OF CHARGE BY DETROIT DIESEL AUTHORIZED REPAIR FACILITIES AND DIRECT WARRANTY CUSTOMERS TO PROVIDE COLD WEATHER STARTING WITHOUT THE NEED OF A GRID HEATER. THE SAFETY RECALL BEGAN ON NOVEMBER 4, 2009. OWNERS MAY CONTACT DETROIT DIESEL AT 1-313-592-5800 AND DAIMLER TRUCKS AT 1-800-547-0712.
09V400000 · 18,067 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 HEAVY TRUCKS MANUFACTURED BETWEEN JANUARY 17, 2006 AND MARCH 31, 2009, EQUIPPED WITH EPA07 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES. THE PLASTIC LINES MAY EXPERIENCE LEAKS DUE TO FATIGUE CRACKS CAUSED BY STRESS AND VIBRATION COMBINED WITH HIGH INTERNAL PRESSURE.
IF A DIESEL FUEL LEAK CONTINUES UNDETECTED UNDER CERTAIN CONDITIONS FUEL MAY IGNITE ON A HOT ENGINE SURFACE AND/OR FUEL MAY SPILL ON THE ROAD INCREASING THE RISK OF A CRASH.
DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES AND DIRECT WARRANTY CUSTOMERS. THE SAFETY RECALL BEGAN ON MAY 7, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
09V391000 · 10,185 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2009 TRUCKS EQUIPPED WITH INDIANA MILLS AND MANUFACTURING ROLLTEK SIDE-ROLL PROTECTION SYSTEMS. THE SENSOR DESIGNED TO DETECT VEHICLE ROLL CAN MALFUNCTION AND CAUSE THE SIDE AIRBAGS TO INADVERTENTLY DEPLOY.
INADVERTENT DEPLOYMENT OF THE SIDE AIRBAGS COULD RESULT IN A VEHICLE CRASH OR INJURY TO AN OUT OF POSITION OCCUPANT.
DAIMLER TRUCKS WILL INSPECT TO DETERMINE IF A VEHICLE CONTAINS AN AFFECTED SYSTEM AND, IF SO, THAT SYSTEM WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE NOVEMBER 20, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
09V376000 · 14 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2010 HEAVY DUTY TRUCKS MANUFACTURED FROM OCTOBER 29, 2005 THROUGH JULY 3, 2009. UNDER CERTAIN CONDITION, THE LEFT HAND INNER TIE ROD END MAY LOOSEN OVER TIME AND IF NOT CORRECTED, POTENTIALLY SEPARATE FROM THE STEERING RACK.
A SEPARATED TIE ROD ASSEMBLY CAN RESULT IN LOSS OF VEHICLE CONTROL AT HIGHER SPEEDS AND A CRASH COULD OCCUR.
DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 5, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
09V357000 · 8,882 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING 14181 MY 2007-2009 FREIGHTLINER CASCADIA TRUCKS EQUIPPED WITH CAB SIGNAL-DETECT AND ACTIVATION MODULES (SAMS). POTENTIAL CORROSION DAMAGE DUE TO WATER INTRUSION INTO THE SAMS MAY CAUSE ELECTRICAL SHORTS OR INTERMITTENT OPERATION OF TAIL LAMPS, STOP LAMPS, SIDE MARKER LAMPS AND TRAILER LIGHTING. IN SOME CASES STARTER MOTORS HAVE ACTIVATED WITHOUT A KEY ON.
AN ELECTRICAL SHORT IN THE CAB SAM OR CHASSIS SAM MAY CAUSE MELTING IN THE SAM OR OTHER ELECTRICAL COMPONENTS WHICH MAY CAUSE A VEHICLE FIRE.
DEALERS WILL INSPECT FOR INDICATION OF WATER INTRUSION OR DAMAGE TO THE SAMS. SAMS WILL BE REPLACED AS REQUIRED AND MODIFICATIONS WILL BE COMPLETED TO CONTROL POSSIBLE SOURCES OF WATER INTRUSION. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 13, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
09V024000 · 14,181 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
DAIMLER TRUCKS IS RECALLING 900 MY 2008 FREIGHTLINER ARGOSY, ARGOSY RHD, CASCADIA, COLUMBIA, CENTURY ST, CORONADO, STERLING ACTERRA, L-LINE AND WESTERN STAR 4900 TRUCKS EQUIPPED WITH BENDIX MV-3 DASH CONTROL VALVES. THE MOLDED VALVE BODY HAS AN INCORRECT CORE PIN IN THE INJECTION MOLD CAUSING THE VALVE BODY TO BE OVERSIZED IN THE DOUBLE CHECK VALVE AREA. THIS CONDITION CAN ALLOW THE RUBBER DOUBLE CHECK VALVE TO BECOME LODGED IN THE BODY OPENING UNDER CERTAIN CIRCUMSTANCES.
IF THE DOUBLE CHECK VALVE BECOMES LODGED, IN THE EVENT OF A PRIMARY RESERVOIR FAILURE, AIR PRESSURE CAN LEAK PAST THE LODGED DOUBLE CHECK VALVE THEREBY DEPLETING THE SECONDARY RESERVOIR, CAUSING REDUCED ABILITY FOR MODULATING THE SERVICE EMERGENCY BRAKES INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE MV-3 DASH VALVE FOR THE PRODUCTION DATE CODE. VALVES IN THE AFFECTED PRODUCTION LOTS WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 9, 2008. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
08V159000 · 900 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
ON CERTAIN TRUCKS AND MOTOR HOMES CHASSIS, INCORRECT FASTENERS MAY NOT PROVIDE ADEQUATE CLAMPING FORCE BETWEEN THE BRAKE CALIPER AND BRAKE ANCHOR PLATE POTENTIALLY RESULTING IN REDUCED BRAKE EFFECTIVENESS.
REDUCED BRAKE EFFECTIVENESS COULD LEAD TO A VEHICLE CRASH.
DEALERS WILL INSPECT THE VEHICLES TO DETERMINE IF INCORRECT BOLTS WERE USED. IF INCORRECT BOLTS ARE FOUND, VEHICLES WILL BE INSPECTED FOR POSSIBLE ADDITIONAL DAMAGE AND REPAIRED AS REQUIRED. THE RECALL BEGAN ON JUNE 6, 2008. OWNERS MAY CONTACT DAIMLER TRUCKS NORTH AMERICA AT 1-800-547-0712.
08V029000 · 473 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
ON CERTAIN TRUCKS EQUIPPED WITH TRW STEERING GEARS, MODELS TAS85 AND RCS85, THESE STEERING GEARS CONTAIN POTENTIALLY DEFECTIVE SECTOR SHAFTS WITH AN INCORRECT GEAR TOOTH WHICH MAY INTERFERE WITH THE RACK-PISTON TEETH, RESULTING IN A STICK OR BIND CONDITION.
THIS CONDITION HAS THE POTENTIAL TO CAUSE THE STEERING GEAR TO STALL AND RESTRICT THE STEERING TURNING ANGLE OF THE VEHICLE WHICH COULD RESULT IN A VEHICLE CRASH.
FREIGHTLINER IS WORKING WITH TRW TO REPLACE THE DEFECTIVE STEERING GEAR (PLEASE SEE 07E101). THE RECALL BEGAN ON APRIL 18, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
07V592000 · 220 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer
2008 Freightliner Cascadia recall questions
Transport Canada lists 20 recalls for the 2008 Freightliner Cascadia model year. That counts campaigns naming this model year, not recalls on your vehicle: many cover only a VIN range or production window, and some only vehicles found on inspection. NHTSA lists 22 United States campaigns for the US-market model, shown separately; a US campaign may have no Canadian equivalent.
Enter your VIN in Freightliner's Canadian recall lookup, or call a Freightliner dealer with your VIN. In Canada the manufacturer is responsible for showing recall and repair status for each VIN, so its lookup is the authoritative answer. Cardog uses your VIN only to find the model year; the recalls shown here are listed for that model year and are not matched to your VIN.
Not necessarily. NHTSA campaigns cover vehicles sold in the United States, and NHTSA's VIN lookup has no Canadian data. When a defect also affects Canadian vehicles, the manufacturer files a separate notice with Transport Canada, often under a different number and sometimes covering a different set of vehicles. For a Canadian vehicle, go by the Transport Canada listing and Freightliner's Canadian lookup.
Safety recall repairs are normally done at no charge by an authorized Freightliner dealer. The manufacturer's notice for each campaign sets out the remedy and any conditions, so confirm with the dealer when you book.
Once Freightliner's lookup or a dealer confirms a recall applies, book the repair with an authorized Freightliner dealer and bring your VIN. If the manufacturer's notice says not to drive the vehicle or to park it outside, follow that instruction. Parts can take time, so book early.
Follow the manufacturer's notice for that recall. Most allow normal driving until the repair; some tell owners to stop driving or to park outside until it is fixed. Cardog does not grade recalls by severity: the manufacturer's notice and your dealer are the source.
Manufacturers must notify owners they have on record. If you bought the vehicle used or have moved, update your details with Freightliner Canada so notices reach you, and check the manufacturer's lookup from time to time.
Related recall checks
Compare recall listings with alternatives to the 2008 Freightliner Cascadia.