Campaigns on record across the Suzuki Sv650 (1999–2006), from Transport Canada and, tagged NHTSA, the United States. Pick a model year for the Canadian listing, and check your VIN with Suzuki to confirm which apply.
MOTION PRO IS RECALLING 10,000 AFTERMARKET BRAKE LEVERS, MODEL NO. 14-0415, SOLD FOR USE ON CERTAIN MY 1999 THROUGH 2008 SUZUKI AND MY 1998 THROUGH 2003 YAMAHA MOTORCYCLES. THE LOBE HEIGHT ON SOME OF THESE LEVERS ARE SMALLER AND DO NOT PROPERLY ENGAGE THE STOMP LAMP SWITCH WHICH WILL NOT DEACTIVATE WHEN THE DRIVER RELEASES THE BRAKE LEVER. THE LEVER CAN BE IDENTIFIED BY THE MARKING "JY 378" AT THE BASE OF THE LEVER NEAR THE PIVOT BUSHING.
IF THIS OCCURS, THE STOP LAMP WILL REMAIN ON WHICH COULD POSSIBLY RESULT IN A CRASH.
MOTION PRO WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY. THE RECALL BEGAN ON SEPTEMBER 11, 2008. OWNERS MAY CONTACT MOTION PRO AT 1-877-438-7831.
08E052000 · 10,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2003 suzuki sv650 recalls
ON CERTAIN CALIFORNIA-SPECIFICATION MODEL MOTORCYCLES, REPEATED STRESS FROM VIBRATION CAN CAUSE A CRACK TO FORM IN THE AREA WHERE THE LIQUID/VAPOR SEPARATOR BRACKET IS WELDED INSIDE THE FUEL TANK. THIS CAN ALLOW FUEL LEAKAGE TO OCCUR.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 3, 2006. CUSTOMERS MAY CONTACT AMERICAN SUZUKI AT 714-572-1490.
06V013000 · 4,841 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2006 suzuki sv650 recalls
On certain motorcycles, the design of the crankcase could create a condition which could cause the oil pump not to supply adequate lubrication to the engine. This can cause severe engine damage and can result in sudden engine failure. Sudden engine failure while riding could cause rear wheel lock up, disturbing the rider's ability to control the motorcycle, and could cause a crash without prior warning. Correction: An oil plate will be installed in the crankcase of affected motorcycles which will prevent the creation of air pockets in the area of the oil pump inlet.
2000036 · 75 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2000 suzuki sv650 recalls
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE MOTORCYCLE CRANKCASE DESIGN ALLOWS THE CREATION OF AIR POCKETS NEAR THE OIL PUMP INLET DUE TO SLOSHING OF THE OIL IN THE CRANKCASE. IF THE OIL PUMP DRAWS AIR, INADEQUATE LUBRICATION TO THE ENGINE OCCURS, CAUSING SEVERE ENGINE DAMAGE AND RESULTING IN ENGINE FAILURE.
SUDDEN ENGINE FAILURE WHILE RIDING COULD CAUSE REAR WHEEL LOCKUP, ALLOWING THE DRIVER TO LOSE CONTROL OF THE MOTORCYCLE.
DEALERS WILL INSTALL AN OIL PLATE TO PREVENT THE CREATION OF AIR POCKETS IN THE AREA OF THE OIL PUMP INLET.
00V009000 · 1,458 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2000 suzuki sv650 recalls