Campaigns on record across the Pontiac Aztek (2001–2005), from Transport Canada and, tagged NHTSA, the United States. Pick a model year for the Canadian listing, and check your VIN with Pontiac to confirm which apply.
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
07V349000 · 20,594 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2004 pontiac aztek recalls
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
07E021000 · 742 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2005 pontiac aztek recalls
On certain Aztek (AWD), Montana (AWD), Relay (AWD), RendezVous (AWD), RendezVous (FWD), Silhouette (AWD), Terraza (AWD), Terraza (FWD), Uplander (AWD) and Venture (AWD) vehicles equipped with independent rear suspension, when operated in extreme cold temperature and on rough roads, water and salt can intrude past the ball joint seal. The combination of theses conditions may then lead to premature wear of the ball joint. If the ball joint wear progresses to the point of separation from the lower control arm, a loss of vehicle control may occur. Correction: Dealers will replace both ball joints with new ball joints which have a revised boot and ball stud to improve the seal to the ball stud shaft.
2006199 · 49,116 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2005 pontiac aztek recalls
On certain vehicles, contamination on ignition relay contacts can cause high resistance. This can affect signals to the powertrain control module, which could result in intermittent engine stalling. In some cases, the vehicle cannot be restarted immediately. If this were to occur, it could result in a vehicle crash. Correction: Dealers will replace the ignition relay.
2005113 · 3,760 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2004 pontiac aztek recalls
ON CERTAIN SPORT UTILITY VEHICLES, CONTAMINATION ON IGNITION RELAY CONTACTS CAN CAUSE HIGH RESISTANCE. THIS CAN AFFECT SIGNALS TO THE POWERTRAIN CONTROL MODULE AND, COULD CAUSE INTERMITTENT VEHICLE STALLS AT ANY TIME.
THE VEHICLE CANNOT BE RESTARTED IMMEDIATELY. IF THIS WERE TO OCCUR, IT COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE IGNITION RELAY FREE OF CHARGE. THE RECALL BEGAN ON MAY 4, 2005. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668 AND BUICK AT 1-866-608-8080.
05V157000 · 34,186 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2004 pontiac aztek recalls
On certain vehicles, the aluminum wheels are not marked with "T" and "DOT" as required by CMVSS 120. Correction: Since this does not pose any safety risk, no corrective action is required.
2004028 · 6,168 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2003 pontiac aztek recalls
ON CERTAIN PASSENGER VEHICLES, A WELD BETWEEN THE FUEL TANK INLET CHECK VALVE AND THE FUEL TANK CAN FAIL.
IF THESE PARTS SEPARATE, THE DRIVER MAY NOTICE AN ODOR OF FUEL, THE SERVICE ENGINE SOON OR CHECK ENGINE LIGHT MAY ILLUMINATE, AND/OR FUEL MAY LEAK ONTO THE GROUND. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL INSPECT THE SERIAL NUMBER OF THE FUEL TANK TO SEE IF IT IS ON THE LIST OF AFFECTED TANKS. IF THE SERIAL NUMBER MATCHES, THE FUEL TANK WILL BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668.
03V454000 · 79 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2004 pontiac aztek recalls
On certain vehicles, a weld between the fuel tank inlet valve and the fuel tank was not made to specification and can fail. If these parts separate, the driver may notice an odour of fuel, the Service Engine Soon or Check Engine light may illuminate, and/or fuel may leak onto the ground. If a sufficient amount of fuel leaked and if an ignition source were present, a vehicle fire could occur. Correction: Dealer will inspect the fuel tank and replace it if necessary.
2003266 · 9 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2004 pontiac aztek recalls
Certain vehicles do not comply with CMVSS 225 and 210.2. The Owner's Manual does not include the location symbols for the Lower Universal Anchorage System for Restraint Systems and Booster Cushions and an explanation of the meaning of the symbols. Correction: Owner's will receive an Owner's Manual supplement.
2003172 · 54,634 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2003 pontiac aztek recalls
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
03V250000 · 1,707,825 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 2003 pontiac aztek recalls
1–10 of 16
Pontiac Aztek by year
Related recall checks
Check recalls for specific Pontiac Aztek model years