Campaigns on record across the Audi 5000 (1978–1991), from Transport Canada and, tagged NHTSA, the United States. Pick a model year for the Canadian listing, and check your VIN with Audi to confirm which apply.
THESE BRAKE HOSE ASSEMBLIES HAVE INADEQUATE CRIMPS ATTACHING THE HOSE TO THE HOSE FITTINGS AND COULD CAUSE THE HOSE AND FITTING TO SEPARATE.
IF THE BRAKE HOSE ASSEMBLY SEPARATES, LOSS OF BRAKING POWER CAN OCCUR INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
THESE BRAKE HOSE ASSEMBLIES WILL BE REPLACED.
96E006000 · 414 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1986 audi 5000 recalls
ON VEHICLES WITH AUTOMATIC TRANSMISSION, A LOW OIL LEVEL IN THE DIFFERENTIAL COULD CAUSE PREMATURE BEARING AND GEAR WEAR AND EVENTUAL FAILURE OF THE DIFFERENTIAL. THIS COULD RESULT IN POSSIBLE DRIVE WHEEL LOCK-UP AND LOSS OF VEHICLE CONTROL. CORRECTION: DIFFERENTIAL WILL BE DRAINED AND OIL WILL BE REPLACED WITH AN ADVANCED DESIGN HIGH PERFORMANCE GEAR OIL. OWNERS WILL BE PROVIDED WITH A REVISED MAINTENANCE SCHEDULE.
1993008 · 16,455 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1991 audi 5000 recalls
THE DIFFERENTIAL OIL OF THE TRANSAXLE IS LOST OVER TIME DUE TO EVAPORATION. LOW OIL LEVELS CAUSE PREMATURE BEARING AND GEAR WEAR AND EVENTUAL FAILURE OF THE DIFFERENTIAL.
IN THE EVENT OF FAILURE, THE VEHICLE'S DRIVE WHEELS COULDLOSE POWER. IN EXTREME CIRCUMSTANCES, THE FRONT WHEELS LOCK, CAUSING RAPIDDECELERATION RESULTING IN POSSIBLE LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
DRAIN AND REPLACE THE DIFFERENTIAL GEAR OIL WITH OIL HAVING HIGHER PERFORMANCE CHARACTERISTICS.
93V006000 · 152,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1991 audi 5000 recalls
FUEL INJECTION SEALS MAY HARDEN, DUE TO HIGH TEMPERATURE AND ALCOHOL IN SOME FUELS, AND ALLOW FUEL TO ESCAPE INTO THE ENGINE COMPARTMENT.
FUEL DRIPPING ONTO HOT ENGINE COMPONENTS COULD CAUSE ANENGINE COMPARTMENT FIRE.
REPLACE ENGINES FUEL INJECTOR SEALS WITH IMPROVED SEALS PLUS IMPROVEMENTS DESIGNED TO BETTER INSULATE THE ENGINE AGAINST FIRE RISK.
89V006000 · 35,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1989 audi 5000 recalls
On certain Audi 200 turbo and 5000 turbo, the fuel injector seals may harden due to high temperature and alcohol in fuel. This could allow fuel to escape and leak into the engine compartment as a result of turbo pressure. Fuel escaping in this manner could drop onto hot engine components and cause a fire. Correction: Fuel injector seals will be replaced with improved seals, fuel lines will be replaced with fire resistant fuel lines and the sound proofing pad will be replaced with an improved surface treated non- flammable pad. Also, measures will be taken to better seal the engine against lubricant leakage.
1989007 · 7,311 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1988 audi 5000 recalls
On Audi 5000 and 5000 turbo with automatic transmissions, the idle control unit may experience isolated malfunctions of internal electronic components which could cause the idle stabilizer valve to become activated outside its normal operating range. This could cause the rpm to become erratic resulting in possible control problems. Correction: Idle control units will be replaced on all affected vehicles.
1987118 · 8,028 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1985 audi 5000 recalls
MALFUNCTIONS OF INTERNAL COMPONENTS OF IDLE CONTROL UNIT COULD CAUSE IDLE STABILIZER VALVE TO BECOME ACTIVATED OUTSIDE ITS NORMAL OPERATING RANGE.
IDLE RPM MAY BECOME ERRATIC AND, IN SOMEINSTANCES,INCREASE.
INSTALL LATEST SPECIFICATION IDLE CONTROL UNIT.
87V170000 · 57,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1985 audi 5000 recalls
CERTAIN REAR BRAKE CALIPERS COULD BIND AND CONSEQUENTLY OVERHEAT.
OVERHEATED CALIPERS COULD CAUSE BRAKE PEDAL TO FEELSPONGY AND COULD RESULT IN ONE BRAKE CIRCUIT BECOMING INOPERATIVE. BRAKINGABILITY WOULD BE AFFECTED.
REQUIRES INSPECTION OF BRAKE CALIPERS AND REPLACEMENT OF CALIPERS AS NECESSARY.
87V158000 · 16,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1987 audi 5000 recalls
REPEATED TOPPING OFF OF FUEL TANK DURING REFUELING REDUCES THE EXPANSION SPACE WITHIN THE TANK ALLOWING VAPORS TO ESCAPE FROM THE CHARCOAL FILTER TO OUTSIDE RATHER THAN BEING INDUCTED INTO THE ENGINE.
ESCAPING VAPORS COULD IGNITE BY HEAT EMITTED BY THEEXHAUST SYSTEM.
INSTALL REDESIGNED FILLER NECK AND A NEW VENT VALVE AND HOSE FOR CHARCOAL FILTER. ALSO, STOP REFUELING WHEN PUMP NOZZLE SHUTS OFF.
87V157000 · 25,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1988 audi 5000 recalls
On certain Audi 5000 turbo and 5000 Quattro, repeated `topping off' of the fuel tank after the gas station pump has stopped the fuel supply during refuelling, reduces the expansion space within the fuel tank. Consequent pressure conditions within the evaporative emission control system could result in fuel vapours being released into the engine compartment. Heat from the turbo exhaust system could ignite the vapours and cause an engine compartment fire with a risk of injury to the vehicle occupants. Correction: Vehicles will be fitted with a new vent valve and a new type charcoal filter vent hose. In addition, Quattro models will receive a redesigned fuel filler neck.
1987104 · 6,553 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorized dealer · All 1988 audi 5000 recalls
1–10 of 25